计及铜蒸气介质的小电流直流电弧仿真与实验

doi:10.19595/j.cnki.1000-6753.tces.190552

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2853 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要因导线的绝缘劣化、接触不良等因素引起的直流电弧故障时有发生,但因无过零点特征无法自然熄弧可能导致设备损毁或者引发火灾,研究直流电弧特性对于电弧故障的检测与保护具有重要意义。光谱测试数据表明,在直流电弧中存在铜元素,因此,基于平衡态等离子体理论新增了含铜蒸气介质的电导率-温度特性曲线。建立小电流空气直流电弧的有限元模型,分析电弧稳定燃烧时的温度场分布和电弧电阻及电极间距的关系,同时,开展电弧实验,验证仿真模型的合理性。数据表明：相比纯空气介质,引入铜蒸气的仿真结果与实验数据更接近。这体现在当电弧稳定燃烧时,两者电极的温度场分布基本一致,等离子体气体温度最高到6 000~7 500K;电弧电阻和电极间距的仿真数据与实验数据最大偏差是2.283Ω,最大相对误差为13.45%。可见,含铜蒸气介质的电弧仿真模型能更准确、全面地研究直流电弧的电导率特性,为小电流直流电弧的电气特性和温度特性研究提供理论基础。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	钟昱铭
	熊兰
	杨子康
	杨军
	郭珂

关键词 ：直流电弧, 铜蒸气, 等离子体, 输运参数, 有限元仿真

Abstract：DC arc faults occur frequently due to factors such as insulation degradation and poor contact of cables. The DC arc can not be extinguished naturally because of no zero-crossing current/voltage so that it may cause device damage or fire. It is important to study DC arc properties for the detection of arc faults and safety protection for electrical appliances. Light spectral test data indicate the presence of copper particle in the arc. Therefore, conductivity-temperature characteristic curves of air containing copper vapor medium is proposed based on the equilibrium plasma theory. Meanwhile, a finite element model of small current air DC arc is built, then the temperature field distribution and the relationship between arc resistance and electrode spacing are obtained. By comparing experimental data and the simulation results, we find that the simulation data are much closer to experimental data when copper vapor is considered than that with pure air medium. When the arc burns stably, both the multi-physics field simulation and the experimental test show the similar temperature field distribution along two electrodes, in addition, the maximum gas temperature of plasma reaches 6 000 K~7 500K. The maximum deviation of arc resistance, versus electrode distance, between the simulation and experiment data is 2.283Ω, namely the relative error is 13.45%. Therefore, the arc simulation model considering copper vapor medium is more rational to study the conductivity properties of DC arc. Research work above provides a theoretical basis for electrical characteristics and temperature characteristics of small current DC arcs.

Key words： DC arc copper vapor plasma transport coefficients finite element simulation

收稿日期: 2019-05-09

PACS:

TM501.2

基金资助:国家自然科学基金资助项目（51477021）

通讯作者: 熊兰女,1972年生,教授,硕士生导师,研究方向为电力设备在线监测与故障诊断。E-mail：lxiong@cqu.edu.cn

作者简介: 钟昱铭男,1996年生,硕士,研究方向为等离子体多物理场仿真。E-mail：201711131175@cqu.edu.cn

引用本文:

钟昱铭, 熊兰, 杨子康, 杨军, 郭珂. 计及铜蒸气介质的小电流直流电弧仿真与实验[J]. 电工技术学报, 2020, 35(13): 2913-2921. Zhong Yuming, Xiong Lan, Yang Zikang, Yang Jun, Guo Ke. Numerical Simulation and Experiment of Small Current DC Arc Considering Copper Vapor Medium. Transactions of China Electrotechnical Society, 2020, 35(13): 2913-2921.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.190552 https://dgjsxb.ces-transaction.com/CN/Y2020/V35/I13/2913

[1] 王伟宗, 荣命哲, Yan J D, 等. 高压断路器SF₆电弧电流零区动态特征和衰减行为的研究综述[J]. 中国电机工程学报, 2015, 35(8): 2059-2072.
Wang Weizong, Rong Mingzhe, Yan J D, et al.Investigation of the dynamic characteristics and decaying behavior of SF₆ arcs in high voltage circuit breakers during current-zero period: a review[J]. Proceedings of the CSEE, 2015, 35(8): 2059-2072.
[2] 吴翊, 荣命哲, 王小华, 等. 触头打开过程中低压空气电弧等离子体的动态分析[J]. 电工技术学报, 2008, 23(5):12-17.
Wu Yi, Rong Mingzhe, Wang Xiaohua, et al.Dynamic analysis of low-voltage air arc plasma during contact opening process[J]. Transactions of China Electrotechnical Society, 2008, 23(5): 12-17.
[3] Murphy A B. The effects of metal vapour in arc welding[J]. Journal of Physics D: Applied Physics, 2010, 43(43):434001(1)-434001(31).
[4] 林莘, 李鑫涛, 王飞鸣, 等. 触头烧损对SF₆断路器介质恢复特性的影响[J]. 高电压技术, 2014, 40(10): 3125-3134.
Lin Xin, Li Xintao, Wang Feiming, et al.Dielectric recovery characteristics of SF₆ circuit breaker considering contact burning loss[J]. High Voltage Engineering, 2014, 40(10): 3125-3134.
[5] Cressault Y.Influence of metallic vapours on the properties of air thermal plasmas[J]. Plasma Sources Science and Technology, 2008, 17(3): 35016-35016.
[6] 姚钢, 纪飞鹏, 殷志柱, 等. 直流配电电能质量研究综述[J]. 电力系统保护与控制, 2017, 45(16): 163-170.
Yao Gang, Ji Feipeng, Yin Zhizhu, et al.Review on the research of DC power distribution power quality[J]. Power System Protection and Control, 2017, 45(16): 163-170.
[7] 陈博博, 屈卫锋, 杨宏宇, 等. 小电流接地系统单相接地综合电弧模型与选线方法的研究[J]. 电力系统保护与控制, 2016, 44(16): 1-7.
Chen Bobo, Qu Weifeng, Yang Hongyu, et al.Research on single phase grounding arc model and line selection for neutral ineffectively grounding system[J]. Power System Protection and Control, 2016, 44(16): 1-7.
[8] 李建南, 张慧媛, 王鲜花, 等. 中压电缆网接地故障的电弧建模及仿真研究[J]. 电力系统保护与控制, 2016, 44(24): 105-109.
Li Jiannan, Zhang Huiyuan, Wang Xianhua, et al.Arc modeling and simulation of the ground faults of the middle voltage cable network[J]. Power System Protection and Control, 2016, 44(24): 105-109.
[9] 荣命哲, 仲林林, 王小华, 等. 平衡态与非平衡态电弧等离子体微观特性计算研究综述[J]. 电工技术学报, 2016, 31(19): 54-65.
Rong Mingzhe, Zhong Linlin, Wang Xiaohua, et al.Review of microscopic property calculation of equilibrium and non-equilibrium arc plasma[J]. Transactions of China Electrotechnical Society, 2016, 31(19): 54-65.
[10] 翟国富, 薄凯, 周学, 等. 直流大功率继电器电弧研究综述[J]. 电工技术学报, 2017, 32(22): 257-269.
Zhai Guofu, Bo Kai, Zhou Xue, et al.Investigation on breaking arc in DC high-power relays: a review[J]. Transactions of China Electrotechnical Society, 2017, 32(22): 257-269.
[11] 司马文霞,贾文彬,袁涛,等. 多段微孔结构中电弧的磁流体模型及气吹灭弧性能仿真[J]. 高电压技术, 2016, 42(11): 3376-3382.
Sima Wenxia, Jia Wenbin, Yuan Tao, et al.MHD model of arc in multi-segment microhole structure and simulation of air-blowing arc-quenching performance[J]. High Voltage Engineering, 2016, 42(11): 3376-3382.
[12] 张仲麟, 聂秋月, 王志斌, 等. 大气压介质阻挡放电双频调制技术数值模拟研究[J]. 电工技术学报, 2017, 32(8): 48-54.
Zhang Zhonglin, Nie Qiuyue, Wang Zhibin, et al.Numerical studies on the modulated strategy of atmospheric pressure dielectric barrier discharge plasmas driven by dual-frequency[J]. Transactions of China Electrotechnical Society, 2017, 32(8): 48-54.
[13] 伍玉鑫, 王阳明, 杨泽锋, 等. 电弧作用下浸铜碳材料烧蚀过程的数值模拟[J]. 电工技术学报, 2019, 34(6): 5-12.
Wu Yuxin, Wang Yangming, Yang Zefeng, et al.Numerical simulation of ablation process of copper-impregnated carbon material under arc action[J]. Transactions of China Electrotechnical Society, 2019, 34(6): 5-12.
[14] Boulos M I, Fauchais P, Pfender E.Thermal plasmas[M]. New York: Springer US, 1994.
[15] 崔行磊,周学,张勇,等. 基于彩色摄像和光谱分析联合测温方法的电弧温度场分布测量[J]. 电工技术学报, 2017, 32(15): 128-135.
Cui Xinglei, Zhou Xue, Zhang Yong, et al.Measurement of static arc temperature distribution based on colorful photographing and spectroscopy analysis[J]. Transactions of China Electrotechnical Society, 2017, 32(15): 128-135.
[16] Chervy B.Thermodynamic properties and transport coefficients in SF₆-Cu mixtures at temperatures of 300-30000K and pressures of 0.1-1 MPa[J]. Journal of Physics D: Applied Physics, 1994, 27(6): 1193-1206.
[17] 李和平, 于达仁, 孙文廷, 等. 大气压放电等离子体研究进展综述[J]. 高电压技术, 2016, 42(12): 3697-3727.
Li Heping, Yu Daren, Sun Wenting, et al.State-of-the-art of atmospheric discharge plasmas[J]. High Voltage Engineering, 2016, 42(12): 3697-3727.
[18] 胡海星, 高国强, 魏文赋, 等. 基于莫尔偏折的低温等离子体气体温度参数研究[J]. 电工技术学报, 2017, 32(20): 97-103.
Hu Haixing, Gao Guoqiang, Wei Wenfu, et al.Research on the low gas temperature of discharge produced plasma based on Moire deflectometry[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 97-103.
[19] 戴栋, 宁文军, 邵涛. 大气压低温等离子体的研究现状与发展趋势[J]. 电工技术学报, 2017, 32(20): 1-9.
Dai Dong, Ning Wenjun, Shao Tao.A review on the state of art and future trends of atmospheric pressure low temperature plasmas[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 1-9.