基于多特征融合与改进QPSO-RVM的万能式断路器故障振声诊断方法

doi:10.19595/j.cnki.1000-6753.tces.160769

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (14152 KB)
输出: BibTeX | EndNote (RIS)

摘要为可靠地进行万能式断路器机械故障诊断,在基于振动信号故障诊断的基础上,提出了一种多特征融合与改进量子粒子群（QPSO）优化的相关向量机（RVM）相结合的万能式断路器分合闸故障振声诊断方法。首先,对振声信号进行小波包软硬阈值结合去噪预处理,并利用互补总体经验模态分解算法对处理后的振声信号进行分解,提取固有模态函数能量系数、样本熵、功率谱熵,并组成多特征参数;然后,通过组合核函数核主元分析对多特征参数降维,并将其特征融合组成特征向量作为RVM的输入,解决单一特征识别断路器分合闸故障的低准确率和低稳定性;最后,利用改进QPSO优化分类模型参数,建立基于RVM的次序二叉树模型对断路器故障进行辨识。实验结果表明,该方法能有效提升不同故障状态下诊断结果的可靠性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	孙曙光
	于晗
	杜太行
	王景芹
	赵黎媛

关键词 ：万能式断路器, 故障诊断, 振声特征融合, 互补总体经验模态分解, 改进量子粒子群, 相关向量机

Abstract：In order to diagnose the mechanical fault of conventional circuit breaker reliably, a vibration and acoustic joint diagnosis method on the switching fault of conventional circuit breakers based on multi-feature fusion and improved quantum particle swarm optimization (QPSO)-relevance vector machine (RVM) was proposed. Firstly, the vibration signal and acoustic signal were denoised by hard and soft threshold wavelet packet denoising algorithm and the processed signals were decomposed by complementary ensemble empirical mode decomposition (CEEMD). Then the energy coefficient, sample entropy and spectrum entropy were extracted from the intrinsic mode functions to form multi feature parameters. Secondly, it reduced the dimensionality of multi feature parameters by combined kernel function kernel principal component analysis and fused the result to form the feature vector as the input of RVM, solving the problem of low recognition accuracy and low stability of single feature. Finally, the improved QPSO was used to optimize classification model parameters, and the binary tree model based on RVM was established to identify machinery fault. Experiment results show that the proposed method can effectively improve the reliability of the diagnostic results at different machinery fault condition.

Key words： Conventional circuit breaker fault diagnosis vibration and acoustic feature fusion complementary ensemble empirical mode denoising(CEEMD) quantum particle swarm optimization (QPSO) relevance vector machine(RVM)

收稿日期: 2016-05-29 出版日期: 2017-10-25

PACS:

TM561

作者简介: 孙曙光男,1979年生,博士,副教授,研究方向为电器检测与试验。E-mail：sunshuguang_2000@163.com（通信作者）于晗男,1990年生,硕士研究生,研究方向为计算机智能控制与应用。E-mail：mr_yuhan@126.com

引用本文:

孙曙光,于晗,杜太行,王景芹,赵黎媛. 基于多特征融合与改进QPSO-RVM的万能式断路器故障振声诊断方法[J]. 电工技术学报, 2017, 32(19): 107-117. Sun Shuguang, Yu Han, Du Taihang, Wang Jingqin, Zhao Liyuan. Vibration and Acoustic Joint Fault Diagnosis of Conventional Circuit Breaker Based on Multi-Feature Fusion and Improved QPSO-RVM. Transactions of China Electrotechnical Society, 2017, 32(19): 107-117.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.160769 https://dgjsxb.ces-transaction.com/CN/Y2017/V32/I19/107

[1] 杨志泽, 梁良, 李小勇, 等. 灰色关联模型在高压断路器故障诊断中的应用[J] . 电网技术, 2015, 39(6): 1731-1735.
Yang Zhize, Liang Liang, Li Xiaoyong, et al. Application of the gray correlation model in fault diagnosis of high-voltage circuit breakers[J] . Power System Technology, 2015, 39(6): 1731-1735.
[2] Tang Jianzhong, Lu Shisong, Xie Jing, et al. Contact force monitoring and its application in vacuum circuit breakers[J] . IEEE Transactions on Power Delivery, 2017, 32(5): 2154-2161.
[3] 赵书涛, 张佩, 申路, 等. 高压断路器振声联合故障诊断方法[J] . 电工技术学报, 2014, 29(7): 216-221.
Zhao Shutao, Zhang Pei, Shen Lu, et al. Vibration and acoustic joint mechanical fault diagnosis method of high voltage circuit breakers[J] . Transactions of China Electrotechnical Society, 2014, 29(7): 216-221.
[4] 黄建, 胡晓光, 巩玉楠. 基于经验模态分解的高压断路器机械故障诊断方法[J] . 中国电机工程学报, 2011, 31(12): 108-113.
Huang Jian, Hu Xiaoguang, Gong Yunan. Machinery fault diagnosis of high voltage circuit breaker based on empirical mode decomposition[J] . Proceedings of the CSEE, 2011, 31(12): 108-113.
[5] 常广, 王毅, 王玮. 采用振动信号零相位滤波时频熵的高压断路器机械故障诊断[J] . 中国电机工程学报, 2013, 33(3): 155-162.
Chang Guang, Wang Yi, Wang Wei. Mechanical fault diagnosis of high voltage circuit breakers utilizing zero-phase filter time-frequency entropy of vibration signal[J] . Proceedings of the CSEE, 2013, 33(3): 155-162.
[6] 孙一航, 武建文, 廉世军, 等. 结合经验模态分解能量总量法的断路器振动信号特征向量提取[J] . 电工技术学报, 2014, 29(3): 228-236.
Sun Yihang, Wu Jianwen, Lian Shijun, et al. Extraction of vibration signal feature vector of circuit breaker based on empirical mode decomposition amount of energy[J] . Transactions of China Electrotechnical Society, 2014, 29(3): 228-236.
[7] 孙来军, 胡晓光, 纪延超. 一种基于振动信号的高压断路器故障诊断新方法[J] . 中国电机工程学报, 2006, 26(6): 157-161.
Sun Laijun, Hu Xiaoguang, Ji Yanchao. A new method of fault diagnosis for high voltage circuit breakers based on vibration signals[J] . Proceedings of the CSEE, 2006, 26(6): 157-161.
[8] Rong Mingzhe, Wang Xiaohua, Yang Wu, et al. Mechanical condition recognition of medium-voltage vacuum circuit breaker based on mechanism dynamic features simulation and ANN[J] . IEEE Transactions on Power Delivery, 2005, 20(3): 1904-1909.
[9] Leong J H, Zhu Z Q. Acoustic noise and vibration of direct-torque-controlled permanent magnet brushless DC drives[C] //6th IET International Conference on Power Electronics, Machines and Drives, Bristol, UK, 2012: 1-6.
[10] 缪希仁, 吴晓梅, 石敦义, 等. 采用HHT振动分析的低压断路器合闸同期辨识[J] . 电工技术学报, 2014, 29(11): 154-161.
Miao Xiren, Wu Xiaomei, Shi Dunyi, et al. Switching synchronism identification of low voltage circuit breaker utilizing HHT analysis to vibration signal[J] . Transactions of China Electrotechnical Society, 2014, 29(11): 154-161.
[11] Wang Yanxue, He Zhengjia, Zi Yanyang. Enhancement of signal denoising and multiple fault signatures detecting in rotating machinery using dual-tree complex wavelet transform[J] . Mechanical Systems and Signal Processing, 2010, 24(1): 119-137.
[12] Yeh J R, Shieh J S. Complementary ensemble empirical mode decomposition: a noise enhanced data analysis method[J] . Advances in Adaptive Data Analysis, 2010, 2(2): 1-41.
[13] Jiang Qingchao, Yan Xuefeng. Weighted kernel principal component analysis based on probability density estimation and moving window and its application in nonlinear chemical process monitoring[J] . Chemometrics and Intelligent Laboratory Systems, 2013, 127(15): 121-131.
[14] 尹金良, 朱永利, 俞国勤. 基于多分类相关向量机的变压器故障诊断新方法[J] . 电力系统保护与控制, 2013, 41(5): 77-82.
Yin Jinliang, Zhu Yongli, Yu Guoqin. New transformer fault diagnosis method based on multi-class relevance vector machine[J] . Power System Protection and Control, 2013, 41(5): 77-82.
[15] 黄泽霞, 俞攸红, 黄德才. 惯性权自适应调整的量子粒子群优化算法[J] . 上海交通大学学报, 2012, 46(2): 228-232.
Huang Zexia, Yu Youhong, Huang Decai. Quantum-behaved particle swarm algorithm with self-adapting adjustment of inertia weight[J] . Journal of Shanghai Jiaotong University, 2012, 46(2): 228-232.
[16] Smola A. Sparse bayesian learning and the relevance vector machine[J] . Journal of Machine Learning Research, 2001, 1(3): 211-244.
[17] Frans Van Den Bergh. An analysis of particle swarm optimizers[D] . South Africa: Department of Computer Science, University of Pretoria, 2002.
[18] Sun Jun, Xu Wenbo, Feng Bin. A global search strategy of quantum-behaved particle swarm optimization[C] //IEEE Congress on Cybernetics and Intelligent Systems, Singapore, 2004: 111-116.
[19] Donoho D L, Johnstone J M. Ideal spatial adaptation by wavelet shrinkage[J] . Biometrika, 1994, 81(3): 425-455.
[20] 杨恢先, 王绪四, 谢鹏鹤, 等. 改进阈值与尺度间相关的小波红外图像去噪[J] . 自动化学报, 2011, 37(10): 1167-1174.
Yang Huixian, Wang Xusi, Xie Penghe, et al. Infrared image denoising based on improved threshold and inter-scale correlations of wavelet transform[J] . Acta Automatica Sinica, 2011, 37(10): 1167-1174.
[21] Alcaraz R, Rieta J J. A review on sample entropy applications for the non-invasive analysis of atrial fibrillation electrocardiograms[J] . Biomedical Signal Processing and Control, 2010, 5(1): 1-14.
[22] 王凯明, 钟宁, 周海燕. 基于改进功率谱熵的抑郁症脑电信号活跃性研究[J] . 物理学报, 2014, 63(17): 399-406.
Wang Kaiming, Zhong Ning, Zhou Haiyan. Activity analysis of depression electroencephalogram based on modified power spectral entropy[J] . Acta Physica Sinica, 2014, 63(17): 399-406.