Status and Prospect of Fault Diagnosis and Tolerant Control Methods for Switched Reluctance Motor Drive System
Sun Debo1,2, Hu Yanfang1,2, Niu Feng1,2, Li Yongjian1,2
1. Key Laboratory of Electromagnetic Field and Electrical Apparatus Reliability of Hebei Province Hebei University of Technology Tianjin 300130 China; 2. State Key Laboratory of Reliability and Intelligence of Electrical Equipment Hebei University of Technology Tianjin 300130 China
Abstract：Switched reluctance motor (SRM)is giventhe advantages of high reliability, low manufacturing cost, fast response speed, simple structure, and so on. However, due to complicated external factors likeoverheating, humidity, overvoltage and complex operating conditions including frequent start/stop, variablespeed/load, the failures of SRM, power converters, or sensors may be caused. And the failureswill exacerbatethe problems such as overcurrent, torque rippleand noise, and affectthe normal operation of the switched reluctance motor drive system (SRD). Therefore, it is necessary to carry out reliability research for SRD. On basis of the domestic and foreign literatures on SRD reliability research, the principles, scope of application, merits and defeats of current fault diagnosis and tolerant control methods of SRD are analyzed comprehensively and presented separately from the three aspects of power converter, SRM, and sensor in this paper. Finally, the development trend of SRD fault diagnosis and tolerant control methods is predicted.
孙德博, 胡艳芳, 牛峰, 李永建. 开关磁阻电机调速系统故障诊断和容错控制方法研究现状及展望[J]. 电工技术学报, 2022, 37(9): 2211-2229.
Sun Debo, Hu Yanfang, Niu Feng, Li Yongjian. Status and Prospect of Fault Diagnosis and Tolerant Control Methods for Switched Reluctance Motor Drive System. Transactions of China Electrotechnical Society, 2022, 37(9): 2211-2229.
[1] Li Sufei, Zhang Shen, Habetler T G, et al.Modeling, design optimization, and applications of switched reluctance machines-a review[J]. IEEE Transactions on Industry Applications, 2019, 55(3): 2660-2681. [2] 卿龙, 王惠民, 葛兴来. 一种高效率开关磁阻电机转矩脉动抑制方法[J]. 电工技术学报, 2020, 35(9): 1912-1920. Qing Long, Wang Huimin, Ge Xinglai.A high efficiency torque ripple suppression method for switched reluctance motor[J]. Transactions of China Electrotechnical Society, 2020, 35(9): 1912-1920. [3] Kohei Aiso, Kan Akatsu.High speed SRM using vector control for electric vehicle[J]. CES Transactions on Electrical Machines and Systems, 2020, 4(1): 61-68. [4] 闫文举, 陈昊, 刘永强, 等. 一种用于电动汽车磁场解耦型双定子开关磁阻电机的新型功率变换器[J]. 电工技术报, 2021, 36(24): 5081-5091. Yan Wenju, Chen Hao, Liu Yongqiang, et al.A novel power converter on magnetic field decoupling double stator switched reluctance machine for electric vehicles[J]. Transactions of China Electrotechnical Society, 2021, 36(24): 5081-5091. [5] Gan Chun, Chen Yu, Qu Ronghai, et al.An overview of fault-diagnosis and fault-tolerance techniques for switched reluctance machine systems[J]. IEEE Access, 2019, 7: 174822-174838. [6] 张璇. 开关磁阻电机驱动系统可靠性定量评估研究[D]. 徐州: 中国矿业大学, 2019. [7] Ali N, Gao Qiang, Xu Cai, et al.Fault diagnosis and tolerant control for power converter in SRM drives[J]. The Journal of Engineering, 2018, 2018(13): 546-551. [8] Ali N, Gao Qiang, Sovicka P, et al.Power converter fault detection and isolation using high-frequency voltage injection in switched reluctance motor drives for automotive applications[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, DOI: 10.1109/JESTPE.2020.3022575. [9] Ro H S, Kim D H, Jeong H G, et al.Tolerant control for power transistor faults in switched reluctance motor drives[J]. IEEE Transactions on Industry Applications, 2015, 51(4): 3187-3197. [10] 韩国强. 开关磁阻电机系统容错控制研究[D]. 徐州: 中国矿业大学, 2019. [11] Gan Chun, Wu Jianhua, Yang Shiyou, et al.Wavelet packet decomposition-based fault diagnosis scheme for SRM drives with a single current sensor[J]. IEEE Transactions on Energy Conversion, 2016, 31(1): 303-313. [12] 甘醇, 吴建华, 杨仕友. 基于小波包能量分析的开关磁阻电机功率变换器故障诊断[J]. 中国电机工程学报, 2014, 34(10): 1415-1422. Gan Chun, Wu Jianhua, Yang Shiyou.Fault diagnosis of power converters for switched reluctance motors based on wavelet packet energy analysis[J]. Proceedings of the CSEE, 2014, 34(10): 1415-1422. [13] 唐琛, 杨剑, 任兴, 等. 基于小波变换的开关磁阻电机系统功率变换器故障诊断[J]. 电机与控制应用, 2018, 45(10): 125-131. Tang Chen, Yang Jian, Ren Xing, et al.Fault diagnosis of power converter for switched reluctance motor system based on wavelet transform[J]. Electric Machines and Control Application, 2018, 45(10): 125-131. [14] 徐帅. 开关磁阻电机系统可靠性评估与提高方法研究[D]. 徐州: 中国矿业大学, 2019. [15] 史先强. 开关磁阻电机功率变换器故障诊断研究[D]. 徐州: 中国矿业大学, 2018. [16] 王熔基, 刘勇智, 管振水. 基于区间电流的SRM功率变换器短路故障诊断[J]. 北京航空航天大学学报, 2020, 47(6): 1085-1094. Wang Rongji, Liu Yongzhi, Guan Zhenshui.Short-circuit fault diagnosis of SRM power converter based on interval current[J]. Journal of Beijing University of Aeronautics and Astronautics, 2020, 47(6): 1085-1094. [17] Chen Hao, Chen Haobiao, Han Guoqiang, et al.Power transistors’fault diagnosis method of SR S/G for more electric aircraft with cross-leg current analysis[J]. IEEE Transactions on Transportation Electrification, 2020, 6(4): 1528-1536. [18] Han Guoqiang, Chen Hao, Guan Guorui.Generalised fault diagnostic method for power transistors in asymmetric half-bridge power converter of SRM drive[J]. IET Electric Power Applications, 2019, 13: 168-180. [19] Marques J F, Estima J O, Gameiro N S, et al.A new diagnostic technique for real-time diagnosis of power converter faults in switched reluctance motor drives[J]. IEEE Transactions on Industry Applications, 2014, 50(3): 1854-1860. [20] Hu Yihua, Gan Chun, Cao Wenping, et al.Flexible fault-tolerant topology for switched reluctance motor drives[J]. IEEE Transactions on Power Electronics, 2016, 31(6): 4654-4668. [21] Pires V F, Cordeiro A, Foito D, et al.A multilevel fault-tolerant power converter for a switched reluctance machine drive[J]. IEEE Access, 2020, 8: 21917-21931. [22] Ma Mingyao, Yuan Kexiang, Yang Qingqing, et al.Open-circuit fault-tolerant control strategy based on five-level power converter for SRM system[J]. CES Transactions on Electrical Machines and Systems, 2019, 3(2): 178-186. [23] 王瑞. 电动汽车用开关磁阻电机电驱逆变器故障分析及容错控制[D]. 合肥: 合肥工业大学, 2019. [24] Xu Shuai, Chen Hao, Yang Jian.Performance evaluation and reliability enhancement of switched reluctance drive system by a novel integrated power converter[J]. IEEE Transactions on Power Electronics, 2019, 34(11): 11090-11102. [25] Sun Qingguo, Wu Jianhua, Gan Chun, et al.Modular full-bridge converter for three-phase switched reluctance motors with integrated fault-tolerance capability[J]. IEEE Transactions on Power Electronics, 2019, 34(3): 2622-2634. [26] Ding Wen, Hu Yanfang, Wu Luming.Investigation and experimental test of fault-tolerant operation of a mutually coupled dual three-phase SRM drive under faulty conditions[J]. IEEE Transactions on Power Electronics, 2015, 30(12): 6857-6872. [27] Xu Shuai, Chen Hao, Dong Feng, et al.Online sensorless fault diagnosis and remediation strategies selection of transistors for power converter in SRD[J]. IET Electric Power Applications, 2019, 13(11): 1553-1564. [28] Li Wei, Cheng Ming.Investigation of influence of winding structure on reliability of permanent magnet machines[J]. CES Transactions on Electrical Machines and Systems, 2020, 4(2): 87-95. [29] 胡胜龙, 左曙光, 刘明田. 开关磁阻电机非线性径向电磁力解析建模[J]. 电工技术学报, 2020, 35(6): 1189-1197. Hu Shenglong, Zuo Shuguang, Liu Mingtian.Analytical modeling of nonlinear radial electromagnetic force in switched reluctance motors[J]. Transactions of China Electrotechnical Society, 2020, 35(6): 1189-1197. [30] Hoseini S R K, Farjah E, Ghanbari T. Extended Kalman filter-based method for inter-turn fault detection of the switched reluctance motors[J]. IET Electric Power Applications, 2016, 10(8): 714-722. [31] 王胜权. 开关磁阻电机系统故障诊断研究[D]. 徐州: 中国矿业大学, 2015. [32] Zhang Pinjia, Li Kecheng, Yu Shenglong, et al.A novel fault diagnosis technique of inter-turn short-circuit fault for SRM in current chopper mode[J]. IEEE Transactions on Industrial Electronics, 2021, 69: 3037-3046. [33] Han Guoqiang, Chen Hao, Shi Xianqiang.Modelling, diagnosis, and tolerant control of phase-to-phase fault in switched reluctance machine[J]. IET Electric Power Applications, 2017, 11(9): 1527-1537. [34] 张蕾, 曹鑫, 邓智泉, 等. 一种单绕组无轴承开关磁阻电机绕组开路故障容错控制策略[J]. 电工技术学报, 2018, 33(15): 3564-3571. Zhang Lei, Cao Xin, Deng Zhiquan, et al.A fault-tolerant control strategy for open circuit in single-winding bearingless switched reluctance motor[J]. Transactions of China Electrotechnical Society, 2018, 33(15): 3564-3571. [35] Chen Qian, Xu Dezhi, Xu Liang, et al.Fault-tolerant operation of a novel dual-channel switched reluctance motor using two 3-phase standard inverters[J]. IEEE Transactions on Applied Superconductivity, 2018, 28(3): 1-5. [36] Weiss C P, Singh S, De Doncker R W. Radial force minimization control for fault tolerant switched reluctance machines with distributed inverters[J]. IEEE Transactions on Transportation Electrification, 2020, 7(1): 193-201. [37] Ullah S, McDonald S P, Martin R, et al. A permanent magnet assist, segmented rotor, switched reluctance drive for fault tolerant aerospace applications[J]. IEEE Transactions on Industry Applications, 2019, 55(1): 298-305. [38] He Yong, Zhao Wenxiang, Tang Hongyu, et al.Auxiliary teeth design to reduce short-circuit current in permanent magnet generators[J]. CES Transactions on Electrical Machines and Systems, 2020, 4(3): 198-205. [39] Torkaman H, Afjei E.Sensorless method for eccentricity fault monitoring and diagnosis in switched reluctance machines based on stator voltage signature[J]. IEEE Transactions on Magnetics, 2013, 49(2): 912-920. [40] 肖丽, 范书瑞, 刘卫朋, 等. 基于电流分析的四相开关磁阻电机气隙偏心故障综合检测方法[J]. 电工技术学报, 2015, 30(6): 122-132. Xiao Li, Fan Shurui, Liu Weipeng, et al.Fault detection method of air gap eccentricity for switched reluctance motors based on analysis of current[J]. Transactions of China Electrotechnical Society, 2015, 30(6): 122-132. [41] Torkaman H, Afjei E, Yadegari P.Static, dynamic, and mixed eccentricity faults diagnosis in switched reluctance motors using transient finite element method and experiments[J]. IEEE Transactions on Magnetics, 2012, 48(9): 2254-2264. [42] 肖丽, 范书瑞, 李洁, 等. 开关磁阻电机气隙偏心故障综合检测方法[J]. 电机与控制学报, 2015, 19(2): 66-74. Xiao Li, Fan Shurui, Li Jie, et al.Fault detection method of air gap eccentricity for switched reluctance motor based on analysis of current[J]. Electric Machines and Control, 2015, 19(2): 66-74. [43] Yang H Y, Lim Y C, Kim H C.Acoustic noise/vibration reduction of a single-phase SRM using skewed stator and rotor[J]. IEEE Transactions on Industrial Electronics, 2013, 60(10): 4292-4300. [44] Grace F L, Xuan S N, Jeong K I, et al.Design and performance analysis of switched reluctance motor with inner holes to reduce radial force[C]//2020 IEEE Energy Conversion Congress and Exposition (ECCE), Detroit, MI, USA, 2020: 11-15. [45] Dai Cong, Liu Yongzhi, Sun Haoshui, et al.Research on fault-tolerant control for SRM air gap eccentricity fault[C]//2018 IEEE CSAA Guidance, Navigation and Control Conference (CGNCC), Xiamen, China, 2018: 10-12. [46] Han Guoqiang, Chen Hao, Shi Xianqiang.Phase current reconstruction strategy for switched reluctance machines with fault-tolerant capability[J]. IET Electric Power Applications, 2017, 11(3): 399-411. [47] Peng W, Gyselinck J J C, Ahn J W, et al. Minimal current sensing strategy for switched reluctance machine control with enhanced fault-detection capability[J]. IEEE Transactions on Industry Applications, 2019, 55(4): 3725-3735. [48] 张磊, 刘闯, 兴志. 开关磁阻电机无位置传感器故障诊断与容错技术[J]. 电机与控制学报, 2018, 22(12): 96-104. Zhang Lei, Liu Chuang, Xing Zhi.Fault diagnosis and fault-tolerant sensorless technique for switched reluctance motors[J]. Electric Machines and Control, 2018, 22(12): 96-104. [49] Chen Hao, Guan Guorui, Han Guoqiang, et al.Fault diagnosis and tolerant control strategy for position sensors of switched reluctance starter/generator systems[J]. IEEE Transactions on Transportation Electrification, 2020, 6(4): 1508-1518. [50] Shao Jie, Deng Zhiquan, Gu Yu.Fault-tolerant control of position signals for switched reluctance motor drives[J]. IEEE Transactions on Industry Applications, 2017, 53(3): 2959-2966. [51] Cai Jun, Deng Zhiquan, Hu Rongguang.Position signal faults diagnosis and control for switched reluctance motor[J]. IEEE Transactions on Magnetics, 2014, 50(10): 1-11. [52] Cai Jun, Zhao Xingqiang.Synthetic hybrid-integral- threshold logic-based position fault diagnosis scheme for SRM drives[J]. IEEE Transactions on Instrumentation and Measurement, 2021, 70: 1-8. [53] Han Guoqiang, Chen Hao, Guan Guorui.Rotor position tolerant detection method for SRM drive system with misaligned position sensors[J]. IET Electric Power Applications, 2019, 13(6): 730-741. [54] Cai Jun, Liu Zeyuan, Zeng Yu.Aligned position estimation based fault-tolerant sensorless control strategy for SRM drives[J]. IEEE Transactions on Power Electronics, 2019, 34(9): 7754-7762. [55] 许爱德, 任萍, 陈加贵, 等. 基于电感特殊位置点的开关磁阻电机转子位置检测及误差补偿[J]. 电工技术学报, 2020, 35(8): 1613-1623. Xu Aide, Ren Ping, Chen Jiagui, et al.Rotor position detection and error compensation of switched reluctance motor based on special inductance position[J]. Transactions of China Electrotechnical Society, 2020, 35(8): 1613-1623. [56] 匡斯建, 张小平, 刘苹, 等. 基于相电感非饱和区定位的开关磁阻电机无位置传感器控制方法[J]. 电工技术学报, 2020, 35(20): 4296-4305. Kuang Sijian, Zhang Xiaoping, Liu Ping, et al.Sensorless control method for switched reluctance motors based on locations of phase inductance characteristic points[J]. Transactions of China Electrotechnical Society, 2020, 35(20): 4296-4305. [57] Ding Wen, Song Kaidi.Position sensorless control of switched reluctance motors using reference and virtual flux linkage with one-phase current sensor in medium and high speed[J]. IEEE Transactions on Industrial Electronics, 2020, 67(4): 2595-2606. [58] 梁晓燕. 开关磁阻电机无位置传感器控制系统的研究[D]. 大连: 大连理工大学, 2014.
2022, Vol. 37 
