Abstract：Wireless power transfer (WPT) technology has garnered widespread attention in recent years due to its advantages in safety, reliability, and flexibility. However, these benefits are often dependent on the precise alignment of the coupling mechanism. In practical applications, as perfect alignment cannot always be ensured, misalignment leads to a reduction in the coupling coefficient, significantly degrading transmission efficiency and system performance. Traditional flat solenoid coils perform well in resisting longitudinal misalignment, but when lateral misalignment occurs, especially near the coil's edge, the coupling coefficient and efficiency drop rapidly. To address this issue, this paper proposes an improved flat solenoid coil WPT system. First, an equivalent model of the LCC/S compensation circuit is established to analyze the effects of circuit parameters on output characteristics, and a method for configuring the parameters of resonant elements is derived, revealing key circuit parameters affecting voltage gain. Then, an equivalent magnetic circuit model is built to analyze the magnetic field distribution characteristics of the coil, demonstrating that core shape and winding configuration significantly influence the coupling coefficient. Consequently, an optimized winding distribution is proposed using an arithmetic progression for the inter-turn spacing, and the specific optimization process is provided. Additionally, the core shape of the transmitter coil in the traditional flat solenoid design is improved to better concentrate the magnetic field lines, enhancing magnetic field uniformity and increasing the misalignment tolerance of the coupling mechanism. To verify the optimization effects, multiple simulation models were created with core shape and winding configuration as variables for comparison. Finite element simulation results show that the improved transmitter core achieves more uniform magnetic flux density distribution, significantly reducing the rate of change in the coupling coefficient. Magnetic field uniformity and misalignment tolerance are markedly improved. Finally, a 100 W WPT system prototype was built, and thermal imaging was used to analyze the system’s loss distribution. Experimental results show that when the receiver is laterally misaligned within ±50% in both the X and Y directions, the output voltage fluctuation is controlled within 5%, and transmission efficiency reaches 89%. These results validate the effectiveness and feasibility of the proposed system.
冯波, 彭大为, 杨奕, 郭科, 刘则阳. 改进型扁平螺线管线圈高抗偏移无线电能传输系统[J]. 电工技术学报, 2025, 40(12): 3716-3726.
Feng Bo, Peng Dawei, Yang Yi, Guo Ke, Liu Zeyang. Enhanced Flat Solenoid Coil with High Misalignment Tolerance for Wireless Power Transfer System. Transactions of China Electrotechnical Society, 2025, 40(12): 3716-3726.
[1] 唐丁源, 周玮, 黄亮, 等. 具有恒压输出特性的电场耦合式动态无线电能传输技术[J]. 电工技术学报, 2023, 38(20): 5385-5397. Tang Dingyuan, Zhou Wei, Huang Liang, et al.Dynamic electric-filed coupled wireless power transfer system with constant voltage output characteristics[J]. Transactions of China Electrotechnical Society, 2023, 38(20): 5385-5397. [2] 周玮, 高侨, 陈泽林, 等. 基于同侧解耦型电场耦合机构的多发射多接收无线电能传输系统[J]. 电工技术学报, 2023, 38(18): 4811-4822. Zhou Wei, Gao Qiao, Chen Zelin, et al.Same-sided decoupled electric-field coupler based wireless power transfer system with multi-transmitter and multi-receiver[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 4811-4822. [3] 谢文燕, 陈为. 全方向无线电能传输技术研究进展[J]. 电力系统自动化, 2020, 44(4): 202-215. Xie Wenyan, Chen Wei.Research progress of omnidirectional wireless power transfer technology[J]. Automation of Electric Power Systems, 2020, 44(4): 202-215. [4] 闫争超, 胡谦宇, 赵晨旭, 等. 水下航行器感应式无线电能传输技术研究综述[J]. 中国电机工程学报, 2023, 43(24): 9668-9682. Yan Zhengchao, Hu Qianyu, Zhao Chenxu, et al.Summary of research on induction wireless power transmission technology of underwater vehicle[J]. Proceedings of the CSEE, 2023, 43(24): 9668-9682. [5] 焦超群, 杨旭, 杨俊峰, 等. 基于多目标优化理论的耦合无关恒压输出型LCC/S补偿感应电能传输系统[J]. 电工技术学报, 2023, 38(24): 6565-6580. Jiao Chaoqun, Yang Xu, Yang Junfeng, et al.Coupling-independent constant-voltage output LCC/S compensation inductive power transfer system based on multi-objective optimization theory[J]. Transactions of China Electrotechnical Society, 2023, 38(24): 6565-6580. [6] 谢诗云, 杨奕, 李恋, 等. 基于双极性耦合磁场调控的高抗偏移偏转无线电能传输系统[J]. 电工技术学报, 2023, 38(18): 4838-4852. Xie Shiyun, Yang Yi, Li Lian, et al.Wireless power transfer system with high misalignment tolerance based on bipolar coupling magnetic-field control[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 4838-4852. [7] Yao Yousu, Wang Yijie, Liu Xiaosheng, et al.A novel unsymmetrical coupling structure based on concentrated magnetic flux for high-misalignment IPT applications[J]. IEEE Transactions on Power Electronics, 2019, 34(4): 3110-3123. [8] Hao Hao, Covic G A, Boys J T.An approximate dynamic model of LCL-T-based inductive power transfer power supplies[J]. IEEE Transactions on Power Electronics, 2014, 29(10): 5554-5567. [9] Gati E, Kampitsis G, Manias S.Variable frequency controller for inductive power transfer in dynamic conditions[J]. IEEE Transactions on Power Elec-tronics, 2017, 32(2): 1684-1696. [10] Liu Yeran, Madawala U K, Mai Ruikun, et al.An optimal multivariable control strategy for inductive power transfer systems to improve efficiency[J]. IEEE Transactions on Power Electronics, 2020, 35(9): 8998-9010. [11] Chen Shuxin, Li Hongchang, Tang Yi.Extending the operating region of inductive power transfer systems through dual-side cooperative control[J]. IEEE Transa-ctions on Industrial Electronics, 2020, 67(11): 9302-9312. [12] 麦建伟, 曾宪瑞, 刘治钢, 等. 基于S/SP补偿拓扑的强抗偏移感应式无线电能传输系统[J]. 中国电机工程学报, 2023, 43(4): 1525-1536. Mai Jianwei, Zeng Xianrui, Liu Zhigang, et al.An IPT system based on S/SP compensation topology with high misalignment tolerance[J]. Proceedings of the CSEE, 2023, 43(4): 1525-1536. [13] Hou Jia, Chen Qianhong, Wong S C, et al.Analysis and control of series/series-parallel compensated resonant converter for contactless power transfer[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2015, 3(1): 124-136. [14] Wang Yijie, Wang Haoyu, Liang Tian, et al.Analysis and design of an LCC/S compensated resonant con-verter for inductively coupled power transfer[C]//2017 IEEE Transportation Electrification Conference and Expo, Asia-Pacific (ITEC Asia-Pacific), Harbin, China, 2017: 1-5. [15] Kim S, Covic G A, Boys J T.Tripolar pad for inductive power transfer systems for EV charging[J]. IEEE Transactions on Power Electronics, 2017, 32(7): 5045-5057. [16] 徐先峰, 吴慧玲, 杨雄政, 等. 空间约束下电动汽车无线充电系统磁耦合结构优化[J]. 电工技术学报, 2024, 39(12): 3581-3588. Xu Xianfeng, Wu Huiling, Yang Xiongzheng, et al.Optimization of magnetically coupled structure of wireless charging system for electric vehicles under space constraint[J]. Transactions of China Electro-technical Society, 2024, 39(12): 3581-3588. [17] 王懿杰, 陆凯兴, 姚友素, 等. 具有强抗偏移性能的电动汽车用无线电能传输系统[J]. 中国电机工程学报, 2019, 39(13): 3907-3917. Wang Yijie, Lu Kaixing, Yao Yousu, et al.An electric vehicle (EV)-oriented wireless power transfer system featuring high misalignment tolerance[J]. Proceedings of the CSEE, 2019, 39(13): 3907-3917. [18] 杨奕, 郭科, 郭强, 等. 网格型螺线管线圈单管逆变无线电能传输系统研究与设计[J]. 仪器仪表学报, 2023, 44(12): 161-174. Yang Yi, Guo Ke, Guo Qiang, et al.Research and design of single-switch inverter wireless power transfer system for grid flat spiral pad coils[J]. Chinese Journal of Scientific Instrument, 2023, 44(12): 161-174. [19] 谷鹏, 王懿杰, 关弘路, 等. 基于改进型三维螺线管磁耦合结构的多线圈长气隙无线电能传输系统研究[J]. 中国电机工程学报, 2022, 42(23): 8762-8772. Gu Peng, Wang Yijie, Guan Honglu, et al.Research on multi-coil large air gap wireless power transfer system based on improved 3D solenoid magnetic coupling structure[J]. Proceedings of the CSEE, 2022, 42(23): 8762-8772. [20] Zhao Jinbo, Cai Tao, Duan Shanxu, et al.A general design method of primary compensation network for dynamic WPT system maintaining stable transmission power[J]. IEEE Transactions on Power Electronics, 2016, 31(12): 8343-8358. [21] Villa J L, Sallan J, Sanz Osorio J F, et al. High-misalignment tolerant compensation topology for ICPT systems[J]. IEEE Transactions on Industrial Electronics, 2012, 59(2): 945-951. [22] 李中启, 张晨曦, 王建斌, 等. 基于变频重构S/SP拓扑的无线电能传输系统恒压恒流研究[J]. 电工技术学报, 2024, 39(15): 4718-4732. Li Zhongqi, Zhang Chenxi, Wang Jianbin, et al.Research on constant current and constant voltage of WPT system based on variable frequency recon-figuration S/SP topology[J]. Transactions of China Electrotechnical Society, 2024, 39(15): 4718-4732. [23] Wei Yuchen, Wu Fengjiang, Liu Hongchen.Indirect control strategy of secondary charging voltage and current and transient analysis of LCC-S WPT system[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(2): 2364-2376. [24] 杨奕, 张葛, 曹桂梅, 等. 基于多线圈阵列的单管无线电能传输电路优化[J]. 电工技术学报, 2023, 38(20): 5398-5410. Yang Yi, Zhang Ge, Cao Guimei, et al.Optimization on single-switch wireless power transfer circuit based on multi-coils array[J]. Transactions of China Elec-trotechnical Society, 2023, 38(20): 5398-5410.
2025, Vol. 40 
