Abstract:The SiC/Si hybrid switch (SiC/Si HyS) is composed of a SiC metal oxide semiconductor field effect transistor (MOSFET) and Si insulated gate bipolar transistor (IGBT) in parallel, attracting much attention due to its low loss and low cost. However, the existing HyS research mainly focuses on changing the switching sequence to optimize its loss or reliability, which has the disadvantage of single control parameters. Besides, the HyS integrated drive circuit with multiple control parameters is lacking. Therefore, this paper proposes a SiC/Si HyS drive circuit with autonomous and coordinated control of switching sequences and driving voltages. Three switching patterns of different switching sequences and driving voltages for HyS can be provided, and the autonomous coordinated control of switching sequences and driving voltages is realized according to the load current level. Firstly, the effects of the switching sequence and driving voltage on the loss and electrical stress of SiC/Si HyS are analyzed. Then, a SiC/Si HyS switching strategy is proposed with coordinated control of the switching sequence and driving voltage. Secondly, the basic structure of the proposed drive circuit is introduced, which is mainly composed of a current sensor, field programmable gate array (FPGA), driving chip, auxiliary triodes, power module, and coupling capacitor. The switching principle and operation logic of the switching sequence and driving voltage are introduced. A HyS-type single-phase inverter based on the proposed drive circuit is built, and the effectiveness of the proposed drive circuit is verified. Finally, the advantages of the proposed drive circuit are analyzed in terms of inverter efficiency, drive circuit power loss, and drive circuit cost. The following conclusions can be drawn. (1) A SiC/Si HyS single-phase inverter is built to test the proposed drive circuit. The experimental results show that the proposed drive circuit can actively switch the switching sequence and driving voltage of SiC/Si HyS under different output power of the inverter. (2) The advantages of the proposed drive circuit in improving the efficiency of the inverter are analyzed. Compared with the existing drive circuit with a variable switching sequence, the efficiency of the inverter operating with the proposed drive circuit is improved by 0.73% and 0.42% when the output power of the inverter is 3 kW and 1.5 kW, respectively. Therefore, the proposed drive circuit can improve the operating efficiency of the inverter in the whole working domain. (3) The power loss and cost of the proposed and existing drive circuits are compared. The results show that the power loss and cost of the proposed drive circuit are increased by 0.065 W ( fs=100 kHz) and 2.72 yuan RMB (4.19%), respectively. Therefore, the power loss and cost increase can be negligible.
肖标, 郭祺, 涂春鸣, 肖凡, 龙柳. 面向开关时序与驱动电压自主协同调控的SiC/Si混合开关驱动电路[J]. 电工技术学报, 2025, 40(4): 1117-1128.
Xiao Biao, Guo Qi, Tu Chunming, Xiao Fan, Long Liu. SiC/Si Hybrid Switch Drive Circuit with Autonomous and Coordinated Control of Switching Sequences and Driving Voltages. Transactions of China Electrotechnical Society, 2025, 40(4): 1117-1128.
[1] 李鑫, 罗毅飞, 史泽南, 等. 一种基于物理的SiC MOSFET改进电路模型[J]. 电工技术学报, 2022, 37(20): 5214-5226. Li Xin, Luo Yifei, Shi Zenan, et al.An improved physics-based circuit model for SiC MOSFET[J]. Transactions of China Electrotechnical Society, 2022, 37(20): 5214-5226. [2] 邹铭锐, 曾正, 孙鹏, 等. 基于变电阻驱动的SiC器件开关轨迹协同调控[J]. 电工技术学报, 2023, 38(16): 4286-4300. Zou Mingrui, Zeng Zheng, Sun Peng, et al.Coordinated switching trajectory regulation of SiC device using variable resistance gate driver[J]. Transactions of China Electrotechnical Society, 2023, 38(16): 4286-4300. [3] 朱小全, 刘康, 叶开文, 等. 基于SiC器件的隔离双向混合型LLC谐振变换器[J]. 电工技术学报, 2022, 37(16): 4143-4154. Zhu Xiaoquan, Liu Kang, Ye Kaiwen, et al.Isolated bidirectional hybrid LLC converter based on SiC MOSFET[J]. Transactions of China Electrotechnical Society, 2022, 37(16): 4143-4154. [4] 张少昆, 孙微, 范涛, 等. 基于分立器件并联的高功率密度碳化硅电机控制器研究[J]. 电工技术学报, 2023, 38(22): 5999-6014. Zhang Shaokun, Sun Wei, Fan Tao, et al.Research on high power density silicon carbide motor controller based on parallel connection of discrete devices[J]. Transactions of China Electrotechnical Society, 2023, 38(22): 5999-6014. [5] 任鹏, 涂春鸣, 侯玉超, 等. 基于Si和SiC器件的混合型级联多电平变换器及其调控优化方法[J]. 电工技术学报, 2023, 38(18): 5017-5028. Ren Peng, Tu Chunming, Hou Yuchao, et al.Research on a hybrid cascaded multilevel converter based on Si and SiC device and its control optimization method[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 5017-5028. [6] 刘平, 陈梓健, 苗轶如, 等. 基于开关瞬态反馈的SiC MOSFET有源驱动电路[J]. 电工技术学报, 2022, 37(17): 4446-4457. Liu Ping, Chen Zijian, Miao Yiru, et al.Active gate driver for SiC MOSFET based on switching transient feedback[J]. Transactions of China Electrotechnical Society, 2022, 37(17): 4446-4457. [7] 任鹏, 涂春鸣, 侯玉超, 等. 考虑异质器件混用与输出电平倍增的混合型MMC及其调控方法[J]. 电力系统自动化, 2024, 48(5): 128-136. Ren Peng, Tu Chunming, Hou Yuchao, et al.Hybrid modular multilevel converter considering heterogeneous device mixing and output level doubling and its regulation method[J]. Automation of Electric Power Systems, 2024, 48(5): 128-136. [8] Huang A Q, Song Xiaoqing, Zhang Liqi.6.5 kV Si/SiC hybrid power module: an ideal next step?[C]// 2015 IEEE International Workshop on Integrated Power Packaging (IWIPP), Chicago, IL, USA, 2015: 64-67. [9] 宁圃奇, 李磊, 曹瀚, 等. 基于Si IGBT/SiC MOSFET的混合开关器件综述[J]. 电工电能新技术, 2018, 37(10): 1-9. Ning Puqi, Li Lei, Cao Han, et al.Summary of Si IGBT/SiC MOSFET based hybrid switching device[J]. Advanced Technology of Electrical Engineering and Energy, 2018, 37(10): 1-9. [10] 李宗鉴, 王俊, 余佳俊, 等. SiC JMOS和SiC DMOS在Si/SiC混合器件单相逆变器中的应用研究[J]. 中国电机工程学报, 2019, 39(19): 5674-5682, 5895. Li Zongjian, Wang Jun, Yu Jiajun, et al.Application of SiC JMOS and SiC DMOS in Si/SiC hybrid switch based single-phase inverter[J]. Proceedings of the CSEE, 2019, 39(19): 5674-5682, 5895. [11] Wang Ye, Chen Min, Yan Cheng, et al.Efficiency improvement of grid inverters with hybrid devices[J]. IEEE Transactions on Power Electronics, 2019, 34(8): 7558-7572. [12] Li Lei, Ning Puqi, Wen Xuhui, et al.A 1200 V/200 a half-bridge power module based on Si IGBT/SiC MOSFET hybrid switch[J]. CPSS Transactions on Power Electronics and Applications, 2018, 3(4): 292-300. [13] Deshpande A, Luo Fang.Practical design considerations for a Si IGBT SiC MOSFET hybrid switch: parasitic interconnect influences, cost, and current ratio optimization[J]. IEEE Transactions on Power Electronics, 2019, 34(1): 724-737. [14] Deshpande A, Luo Fang.Design of a silicon-WBG hybrid switch[C]//2015 IEEE 3rd Workshop on Wide Bandgap Power Devices and Applications (WiPDA), Blacksburg, VA, USA, 2015: 296-299. [15] 涂春鸣, 韩硕, 龙柳, 等. 面向Si/SiC混合器件逆变器全寿命周期安全工作区的多开关模式主动切换策略[J]. 电力自动化设备, 2023, 43(10): 128-135. Tu Chunming, Han Shuo, Long Liu, et al.Multi-mode active switching strategy for safe operating area of Si/SiC-hybrid-switch-based inverter throughout life cycle[J]. Electric Power Automation Equipment, 2023, 43(10): 128-135. [16] 龙柳, 肖凡, 涂春鸣, 等. 基于热网络分区等效策略的Si/SiC混合器件耦合热参数辨识方法[J]. 电工技术学报, 2024, 39(12): 3718-3731. Long Liu, Xiao Fan, Tu Chunming, et al.Enhanced identification approach for RC parameters of Si/SiC hybrid switches based on thermal network partition scheme[J]. Transactions of China Electrotechnical Society, 2024, 39(12): 3718-3731. [17] Peng Zishun, Wang Jun, Liu Zeng, et al.Adaptive gate delay-time control of Si/SiC hybrid switch for efficiency improvement in inverters[J]. IEEE Transactions on Power Electronics, 2021, 36(3): 3437-3449. [18] Li Zongjian, Zhang Chao, Yu Jiajun, et al.Dynamic gate delay time control of Si/SiC hybrid switch for loss minimization in voltage source inverter[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2022, 10(4): 4160-4170. [19] Li Zongjian, Wang Jun, Deng Linfeng, et al.Active gate delay time control of Si/SiC hybrid switch for junction temperature balance over a wide power range[J]. IEEE Transactions on Power Electronics, 2020, 35(5): 5354-5365. [20] Ou Ling, Peng Zishun, Liu Zeng, et al.An EMI suppression strategy for Si/SiC hybrid switch based single-phase inverter[C]//2020 IEEE Energy Conversion Congress and Exposition (ECCE), Detroit, MI, USA, 2020: 3548-3551. [21] He Jiangbiao, Katebi R, Weise N.A currentdependent switching strategy for Si/SiC hybrid switch-based power converters[J]. IEEE Transactions on Industrial Electronics, 2017, 64(10): 8344-8352. [22] Song Xiaoqing, Zhang Liqi, Huang A Q.Threeterminal Si/SiC hybrid switch[J]. IEEE Transactions on Power Electronics, 2020, 35(9): 8867-8871. [23] Zhang Liqi, Zhao Xin, Song Xiaoqing, et al.Gate driver design and continuous operation of an improved 1200V/200A FREEDM-pair half-bridge power module[C]//2018 IEEE Applied Power Electronics Conference and Exposition (APEC), San Antonio, TX, USA, 2018: 1261-1265. [24] Fu Yongsheng, Ma Zhengrong, Ren Haipeng.A low cost compact SiC/Si hybrid switch gate driver circuit for commonly used triggering patterns[J]. IEEE Transactions on Power Electronics, 2022, 37(5): 5212-5223. [25] Fu Yongsheng, Ren Haipeng.A novel single-gate driver circuit for SiC Si hybrid switch with variable triggering pattern[J]. IEEE Transactions on Power Electronics, 2021, 36(10): 11953-11966. [26] Stecca M, Tan Changyu, Xu Junzhong, et al.Hybrid Si/SiC switch modulation with minimum SiC MOSFET conduction in grid connected voltage source converters[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2022, 10(4): 4275-4289. [27] Zeng Zheng, Li Xiaoling.Comparative study on multiple degrees of freedom of gate drivers for transient behavior regulation of SiC MOSFET[J]. IEEE Transactions on Power Electronics, 2018, 33(10): 8754-8763. [28] Yano H, Kanafuji N, Osawa A, et al.Threshold voltage instability in 4H-SiC MOSFETs with phosphorus-doped and nitrided gate oxides[J]. IEEE Transactions on Electron Devices, 2015, 62(2): 324-332. [29] 徐子珂, 蔡雨萌, 孙鹏, 等. 考虑阈值迟滞的碳化硅MOSFE态解析模型[J]. 高电压技术, 2023, 49(7): 3051-3061. Xu Zike, Cai Yumeng, Sun Peng, et al.Analytical model of silicon carbide MOSFET switching transient considering threshold hysteresis[J]. High Voltage Engineering, 2023, 49(7): 3051-3061. [30] Cai Yumeng, Xu Hao, Sun Peng, et al.Effect of threshold voltage hysteresis on switching characteristics of silicon carbide MOSFETs[J]. IEEE Transactions on Electron Devices, 2021, 68(10): 5014-5021. [31] Asllani B, Morel H, Planson D, et al.SiC power MOSFETs threshold-voltage hysteresis and its impact on short circuit operation[C]//2018 IEEE International Conference on Electrical Systems for Aircraft, Railway, Ship Propulsion and Road Vehicles & International Transportation Electrification Conference (ESARS-ITEC), Nottingham, UK, 2018: 1-7. [32] Available: https://assets.wolfspeed.com/uploads/2024/ 01/Wolfspeed_C2M0160120D_data_sheet.pdf. [33] Available: https://www.infineon.com/dgdl/Infineon-IGW25N120H3-DataSheet-v02_01-EN.pdf?fileId= db3a304325305e6d01258d0f50a8369e. [34] Camacho A P, Sala V, Ghorbani H, et al.A novel active gate driver for improving SiC MOSFET switching trajectory[J]. IEEE Transactions on Industrial Electronics, 2017, 64(11): 9032-9042. [35] Available: https://www.infineon.com/dgdl/Infineon-2ED020I12-F2-DataSheet-v02_00-EN.pdf?fileId= db3a304333227b5e013344c70fc64cc8.