Thrust Cooperative Control and Speed Measurement Algorithm of Segmented Long Primary Double-Sided Linear Induction Motor
Zhang Mingyuan1,2, Shi Liming1,2, Fan Manyi1,2, Zhou Shijiong1,2, Zhu Haibin1,2
1. Key Laboratory of Power Electronics and Electric Drive Institute of Electrical Engineering Chinese Academy of Sciences Beijing 100190 China; 2. University of Chinese Academy of Sciences Beijing 100049 China
Abstract：Long primary double-sided induction motors (LP-DSLIM) are widely used in rail transit and linear motor based electro-magnetic launch system, with the advantages of large thrust weight ratio and small dynamics longitudinal end effect during high-speed operation. To reduce the voltage and capacity of the inverter and to improve the power factor of LP-DSLIM, the long primary is segmented into several primary segments and the power supply mode of multiple inverters is adopted. However, the thrust characterization method and high-performance cooperative control strategy of segmented LP-DSLIM powered by multiple inverters have to be studied deeply. Besides, in the field oriented control, the speed participates in the field orientation and the speed measurement accuracy will directly affect the thrust control effect. It is necessary to increase the speed measurement accuracy in motor drive. This paper proposes a thrust cooperative control strategy of segmented LP-DSLIM powered by multiple inverters and a linear speed measurement algorithm. Firstly, the characteristics of one inverter driving a unit motor are studied basing on unit motor mathematical model of segmented LP-DSLIM. When the d axis currents of all unit motors are equal to isd and the q axis currents of all unit motors are equal to isq, the secondary flux equation and electromagnetic thrust equation of segmented LP-DSLIM powered by multiple inverters are similar to that of rotating induction motor. When isd is a constant value, the secondary flux linkage is kept constant and the electromagnetic thrust is controlled by isq. The thrust of each unit motor is naturally proportional to the length of the coupling secondary, which realizes cooperative thrust control. Then, according to the linear motor motion equation and the thrust model, the linear extended state observer (LESO) is established to observe the speed. The speed observer is compared with the tracking differentiator (TD) speed measurement algorithm. Simulation results and experimental results verified the effectiveness of the established speed observer and the proposed thrust cooperative control strategy. When the filter factor h0 in TD is small, the observed velocity noise is large and the thrust fluctuation is large. When h0 in TD is large, the observed velocity lags seriously and the thrust loss is large. The constructed speed observer can simultaneously meet the requirements of low noise and no lag, small speed measurement error. Meanwhile, the thrust fluctuation is small and there is less thrust loss when the observation speed of constructed speed observer is applied for field oriented control. Under the proposed control strategy, the thrust of each unit motor is proportional to the length of its coupling secondary, the total thrust is kept constant. The following conclusions can be drawn: ①Under the proposed cooperative control strategy, the secondary flux equation and electromagnetic thrust equation of segmented LP-DSLIM powered by multiple inverters are similar to that of rotating induction motor. The thrust of each unit motor is naturally proportional to the length of the coupling secondary. The cooperative control strategy is suitable to electromagnetic thrust system. ②The low noise and small lag of TD velocity measurement algorithm cannot be obtained simultaneously, which will lead to large thrust noise or thrust loss in the field oriented control. The speed measurement algorithm of the constructed speed observer is simple with low noise and no lag. When the constructed speed observer is used for field orientation, the thrust fluctuation is small, the thrust loss is small, and the control effect is better than that of the TD speed measurement algorithm.
张明远, 史黎明, 范满义, 周世炯, 朱海滨. 长初级双边直线感应电动机分段推力协同控制和测速算法[J]. 电工技术学报, 2023, 38(3): 659-669.
Zhang Mingyuan, Shi Liming, Fan Manyi, Zhou Shijiong, Zhu Haibin. Thrust Cooperative Control and Speed Measurement Algorithm of Segmented Long Primary Double-Sided Linear Induction Motor. Transactions of China Electrotechnical Society, 2023, 38(3): 659-669.
[1] Ma Weiming, Lu Junyong.Thinking and study of electromagnetic launch technology[J]. IEEE Transactions on Plasma Science, 2017, 45(7): 1071-1077. [2] 张千, 刘慧娟, 马杰芳, 等. 考虑后退行波的长初级双边直线感应电机电磁性能计算[J]. 电工技术学报, 2020, 35(7): 1398-1409. Zhang Qian, Liu Huijuan, Ma Jiefang, et al.Calculation of electromagnetic performance for long primary double sided linear induction motors considering backward traveling wave[J]. Transactions of China Electrotechnical Society, 2020, 35(7): 1398-1409. [3] 徐伟, 肖新宇, 董定昊, 等. 直线感应电机效率优化控制技术综述[J]. 电工技术学报, 2021, 36(5): 902-915, 934. Xu Wei, Xiao Xinyu, Dong Dinghao, et al.Review on efficiency optimization control strategies of linear induction machines[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 902-915, 934. [4] 苏光靖, 李红梅, 李争, 等. 永磁同步直线电机无模型电流控制[J]. 电工技术学报, 2021, 36(15): 3182-3190. Su Guangjing, Li Hongmei, Li Zheng, et al.Research on model-free current control of permanent magnet synchronous linear motor[J]. Transactions of China Electrotechnical Society, 2021, 36(15): 3182-3190. [5] 曹瑞武, 苏恩超, 张学. 轨道交通用次级分段型直线磁通切换永磁电机研究[J]. 电工技术学报, 2020, 35(5): 1001-1012. Cao Ruiwu, Su Enchao, Zhang Xue.Investigation of linear flux-switching permanent magnet motor with segmented secondary for rail transit[J]. Transactions of China Electrotechnical Society, 2020, 35(5): 1001-1012. [6] 张明元, 马伟明, 何娜. 长初级直线电动机分段供电技术综述[J]. 中国电机工程学报, 2013, 33(27): 96-104, 14. Zhang Mingyuan, Ma Weiming, He Na.Application of block feeding methods in long primary linear motors[J]. Proceedings of the CSEE, 2013, 33(27): 96-104, 14. [7] 鲁军勇, 马伟明, 许金. 高速长定子直线感应电动机的建模与仿真[J]. 中国电机工程学报, 2008, 28(27): 89-94. Lu Junyong, Ma Weiming, Xu Jin.Modeling and simulation of high speed long primary double-sided linear induction motor[J]. Proceedings of the CSEE, 2008, 28(27): 89-94. [8] 李卫超, 胡安, 马伟明, 等. 新型长定子直线感应电机闭环控制策略[J]. 中国电机工程学报, 2010, 30(增刊1): 226-231. Li Weichao, Hu An, Ma Weiming, et al.Control strategy of a novel double-sided long primary linear induction motor[J]. Proceedings of the CSEE, 2010, 30(S1): 226-231. [9] 马名中, 马伟明, 范慧丽, 等. 长初级直线感应电机分段供电切换暂态过程[J]. 电机与控制学报, 2015, 19(9): 1-7. Ma Mingzhong, Ma Weiming, Fan Huili, et al.Switch transient process of section powered long-primary linear induction motor[J]. Electric Machines and Control, 2015, 19(9): 1-7. [10] 张明元, 马伟明, 徐兴华, 等. 一种考虑电流过零的直线电机分段供电策略[J]. 海军工程大学学报, 2019, 31(4): 11-16. Zhang Mingyuan, Ma Weiming, Xu Xinghua, et al.A block feeding strategy for linear motor considering switching at current-crossing point[J]. Journal of Naval University of Engineering, 2019, 31(4): 11-16. [11] 孙晓. 多模块双边直线感应电机控制策略研究[D]. 北京: 中国科学院大学, 2018. [12] 张志华. 分段式长初级双边直线感应电机特性研究[D]. 北京: 中国科学院大学, 2014. [13] Sun Xiao, Shi Liming, Zhang Zhihua, et al.Thrust control of a double-sided linear induction motor with segmented power supply[J]. IEEE Transactions on Industrial Electronics, 2019, 66(6): 4891-4900. [14] 张明远, 史黎明, 郭科宇, 等. 分段长初级双边直线感应电动机建模分析[J]. 电工技术学报, 2021, 36(11): 2344-2354. Zhang Mingyuan, Shi Liming, Guo Keyu, et al.Modeling and analysis of segmented long primary double-sided linear induction motor[J]. Transactions of China Electrotechnical Society, 2021, 36(11): 2344-2354. [15] 王成元, 夏加宽, 孙宜标. 现代电机控制技术[M]. 2版. 北京: 机械工业出版社, 2014. [16] 罗成, 李孺涵, 杨凯, 等. 基于电流优化的无速度传感器感应电机零频穿越策略[J]. 电工技术学报, 2022, 37(19): 4947-4956. Luo Cheng, Li Ruhan, Yang Kai, et al.Current optimization-based zero frequency ride-through method for speed-sensorless induction motor drive[J]. Transactions of China Electrotechnical Society, 2022, 37(19): 4947-4956. [17] 陈伯时. 电力拖动自动控制系统: 运动控制系统[M]. 3版. 北京: 机械工业出版社, 2003. [18] 耿捷. 激光测距研究与设计[D]. 北京: 北方工业大学, 2016. [19] 梁超宇. 高响应直线电机伺服系统信号检测技术的研究[D]. 武汉: 华中科技大学, 2007. [20] 韩京清, 王伟. 非线性跟踪—微分器[J]. 系统科学与数学, 1994, 14(2): 177-183. Han Jingqing, Wang Wei.Nonlinear tracking-differentiator[J]. Journal of Systems Science and Mathematical Sciences, 1994, 14(2): 177-183. [21] 韩京清, 袁露林. 跟踪-微分器的离散形式[J]. 系统科学与数学, 1999, 19(3): 268-273. Han Jingqing, Yuan Lulin.The discrete form of tracking-differentiator[J]. Journal of Systems Science and Mathematical Sciences, 1999, 19(3): 268-273. [22] 武利强, 林浩, 韩京清. 跟踪微分器滤波性能研究[J]. 系统仿真学报, 2004, 16(4): 651-652, 670. Wu Liqiang, Lin Hao, Han Jingqing.Study of tracking differentiator on filtering[J]. Acta Simulata Systematica Sinica, 2004, 16(4): 651-652, 670. [23] 韩京清. 从PID技术到“自抗扰控制”技术[J]. 控制工程, 2002, 9(3): 13-18. Han Jingqing.From PID technique to active disturbances rejection control technique[J]. Control Engineering of China, 2002, 9(3): 13-18. [24] Pu Zhiqiang, Yuan Ruyi, Yi Jianqiang, et al.A class of adaptive extended state observers for nonlinear disturbed systems[J]. IEEE Transactions on Industrial Electronics, 2015, 62(9): 5858-5869. [25] 郑大钟. 线性系统理论[M]. 2版. 北京: 清华大学出版社, 2002. [26] Gao Zhiqiang.Scaling and bandwidth-parameterization based controller tuning[C]//Proceedings of the 2003 American Control Conference, Denver, CO, USA, 2003: 4989-4996.
2023, Vol. 38 
