退役高压电缆附件绝缘状态及理化性能分析

doi:10.19595/j.cnki.1000-6753.tces.200367

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (4629 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要为了探究长期服役对高压电缆附件老化状态的影响,研究退役电缆附件的绝缘特性及理化性能。以三元乙丙橡胶（EPDM）和硅橡胶（SIR）两种退役电缆附件绝缘为研究对象,测试其力学性能、微观结构及化学成分,测试并分析其介电性能和绝缘状态。结果表明,EPDM样品中C-O-C键的出现以及SIR样品分子链上有机基团的减少可作为电缆附件绝缘老化的标志,附件的绝缘老化在宏观上表现为力学特性的下降;经历老化或击穿事故的电缆附件,其分子链在电、热等综合作用下断裂成小分子,小分子可能重结晶,导致样品晶型及聚集状态的改变;经历严重老化的电缆附件,其介电性能发生明显劣化。样品理化性能及介电性能的改变可基本反映电缆附件的绝缘及老化状态。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	陈杰
	吴世林
	胡丽斌
	任成燕
	邵涛

关键词 ：电缆附件, 绝缘性能, 力学特性, 微观结构, 老化状态

Abstract：In order to investigate the effect of long-term service on the aging state of high-voltage cable accessories, this paper studied the insulation characteristics and physicochemical properties of retired cable accessories. Taking two types of retired cable accessories of ethylene-propylene-diene monomer (EPDM) and silicone rubber (SIR) as research objects, the mechanical properties, micro- structure, and chemical composition were tested, and the dielectric properties and insulation status were tested and analyzed. The results show that the obvious appearance of the C-O-C bond and the continuous reduction of organic groups on the molecular chain indicate a decline in mechanical properties on a macro level. For cable accessories that have undergone aging or breakdown accidents, the molecular chain are broken into small molecules under the combined effects of electricity and heat. These small molecules may recrystallize, resulting in changes in the crystal form and aggregation state. Meanwhile, the dielectric properties are obviously deteriorated for severely aged cable accessories. The changes in physicochemical properties and dielectric properties of the samples can reflect the insulation and aging state of the cable accessories.

Key words： Cable accessory insulating property mechanical property microstructure aging state

收稿日期: 2020-04-17

PACS:

TM247

基金资助:国家电网公司总部科技项目（5200-201917070A-0-0-00）、中国科学院科研仪器设备研制项目（YJKYYQ20170004）和国家自然科学基金项目（51977202）资助

通讯作者: 任成燕, 女,1979年生,硕士,副研究员,研究方向为高电压与绝缘技术、气体放电与等离子体应用。E-mail: rcy@mail.iee.ac.cn

作者简介: 陈杰,男,1984年生,博士,高级工程师,研究方向为电力电缆线路状态检测及评估技术。E-mail:15105161377@163.com

引用本文:

陈杰, 吴世林, 胡丽斌, 任成燕, 邵涛. 退役高压电缆附件绝缘状态及理化性能分析[J]. 电工技术学报, 2021, 36(12): 2650-2658. Chen Jie, Wu Shilin, Hu Libin, Ren Chengyan, Shao Tao. Analysis of Insulation State and Physicochemical Property of Retired High-Voltage Cable Accessories. Transactions of China Electrotechnical Society, 2021, 36(12): 2650-2658.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.200367 https://dgjsxb.ces-transaction.com/CN/Y2021/V36/I12/2650

[1] 曹俊平, 王少华, 蒋愉宽, 等. 浙江电网高压电缆线路运行情况分析[J]. 电线电缆, 2017(3): 39-43.
Cao Junping, Wang Shaohua, Jiang Yukuan, et al.High-voltage cable operation analysis of Zhejiang power grid[J]. Electric Wire & Cable, 2017(3): 39-43.
[2] 王伟, 何东欣, 宋鹏先, 等. 电热联合老化对电缆附件应力锥处空间电荷积聚特性的影响[J]. 高电压技术, 2019, 45(6): 1737-1744.
Wang Wei, He Dongxin, Song Pengxian, et al.Effects of electrical-thermal aging on space charge accumulation characteristics at the position of the stress cone in the accessory[J]. High Voltage Engineering, 2019, 45(6): 1737-1744.
[3] 黄兴溢, 张军, 江平开. 热塑性电力电缆绝缘材料:历史与发展[J]. 高电压技术, 2018, 44(5): 1377-1398.
Huang Xingyi, Zhang Jun, Jiang Pingkai.Thermo- plastic insulation materials for power cables: history and progress[J]. High Voltage Engineering, 2018, 44(5): 1377-1398.
[4] 杜伯学, 韩晨磊, 李进, 等. 高压直流电缆聚乙烯绝缘材料研究现状[J]. 电工技术学报, 2019, 34(1): 179-191.
Du Boxue, Han Chenlei, Li Jin, et al.Research status of polyethylene insulation for high voltage direct current cables[J]. Transactions of China Electro- technical Society, 2019, 34(1): 179-191.
[5] 王俏华, 顾金, 吴建东, 等. 预处理温度对高压直流电缆附件绝缘材料空间电荷的影响[J]. 电网技术, 2011, 35(1): 122-126.
Wang Qiaohua, Gu Jin, Wu Jiandong, et al.Influence of pretreating temperature on space charge of insu- lation materials for cable accessories used in HVDC transmission projects[J]. Power System Technology, 2011, 35(1): 122-126.
[6] 黄光磊, 李喆, 杨丰源, 等. 直流交联聚乙烯电缆泄漏电流试验特性研究[J]. 电工技术学报, 2019, 34(1): 192-201.
Huang Guanglei, Li Zhe, Yang Fengyuan, et al.Experimental research on leakage current of DC cross linked polyethylene cable[J]. Transactions of China Electrotechnical Society, 2019, 34(1): 192-201.
[7] 谢强, 何轶聪, 庄严. 110kV电缆终端连续故障原因及防范分析[J]. 电线电缆, 2019(6): 31-33.
Xie Qiang, He Yicong, Zhuang Yan.Causes of continuous failure of 110kV cable terminal and its prevention[J]. Electric Wire & Cable, 2019(6): 31-33.
[8] 钟力生, 任海洋, 曹亮, 等. 挤包绝缘高压直流电缆的发展[J]. 高电压技术, 2017, 43(11): 3473-3489.
Zhong Lisheng, Ren Haiyang, Cao Liang, et al.Development of high voltage direct current extruded cables[J]. High Voltage Engineering, 2017, 43(11): 3473-3489.
[9] 吕亮, 王霞, 何华琴, 等. 硅橡胶/三元乙丙橡胶界面上空间电荷的形成[J]. 中国电机工程学报, 2007, 27(15): 106-109.
Lü Liang, Wang Xia, He Huaqin, et al.Formation of space charges at interface between ethylene propylene diene terpolymer and silicone rubber[J]. Proceedings of the CSEE, 2007, 27(15): 106-109.
[10] 白龙雷, 周利军, 邢立勐, 等. 高寒环境下低温对乙丙橡胶电缆终端界面放电特性的影响[J]. 电工技术学报, 2020, 35(3): 646-658.
Bai Longlei, Zhou Lijun, Xing Limeng, et al.Effect of low temperature on interface discharge characteri- stics of ethylene-propylene rubber cable termination in high-cold environment[J]. Transactions of China Electrotechnical Society, 2020, 35(3): 646-658.
[11] 刘通, 傅明利, 侯帅, 等. 温度梯度影响高压直流电缆用交联聚乙烯中空间电荷分布的作用机理[J]. 高电压技术, 2015, 41(8): 2665-2673.
Liu Tong, Fu Mingli, Hou Shuai, et al.Mechanism of space charge distribution in XLPE used in HVDC cables under temperature gradient[J]. High Voltage Engineering, 2015, 41(8): 2665-2673.
[12] 刘昌, 惠宝军, 傅明利, 等. 机械应力对硅橡胶高压电缆附件运行可靠性的影响[J]. 高电压技术, 2018, 44(2): 518-526.
Liu Chang, Hui Baojun, Fu Mingli, et al.Influence of mechanical stress on the operation reliability of silicone rubber high voltage cable accessories[J]. High Voltage Engineering, 2018, 44(2): 518-526.
[13] 仇炜, 李莹, 崔江静, 等. 电缆弯曲对中间接头界面压力的影响规律研究[J]. 绝缘材料, 2020, 53(1): 76-82.
Qiu Wei, Li Ying, Cui Jiangjing, et al.Effect rule of cable bending on interface pressure inside cable joint[J]. Insulating Materials, 2020, 53(1): 76-82.
[14] 王佩龙, 王锦明, 李智文, 等. 电缆附件非线性扩张变形及其对策[J]. 电线电缆, 2016(6): 1-3.
Wang Peilong, Wang Jinming, Li Zhiwen, et al.Nonlinear elastic deformation of cable accessories during expansion and their solutions[J]. Electric Wire & Cable, 2016(6): 1-3.
[15] 张运周, 冯冰, 李明, 等. 退役110kV XLPE电缆绝缘材料聚集态结构分析[J]. 绝缘材料, 2016, 49(7): 20-26.
Zhang Yunzhou, Feng Bing, Li Ming, et al.Analysis on aggregation structure of retired 110kV XLPE cables insulation[J]. Insulating Materials, 2016, 49(7): 20-26.
[16] 惠宝军, 彭阳涛, 傅明利, 等. 机械应力作用下硅橡胶材料的击穿特性研究[J]. 绝缘材料, 2019, 52(7): 29-35.
Hui Baojun, Peng Yangtao, Fu Mingli, et al.Breakdown characteristics of silicone rubber under mechanical stress[J]. Insulating Materials, 2019, 52(7): 29-35.
[17] 罗潘, 任志刚, 徐阳, 等. 退役高压交联聚乙烯电缆绝缘老化状态分析[J]. 电工技术学报, 2013, 28(10): 41-46.
Luo Pan, Ren Zhigang, Xu Yang, et al.Aging condi- tion analysis of high voltage XLPE cables out of service[J]. Transactions of China Electrotechnical Society, 2013, 28(10): 41-46.
[18] 刘刚, 谢月, 杨婉琪, 等. 高压退役电缆空间电荷特性[J]. 高电压技术, 2016, 42(11): 3607-3615.
Liu Gang, Xie Yue, Yang Wanqi, et al.Space charge characteristics of high voltage retired cable[J]. High Voltage Engineering, 2016, 42(11): 3607-3615.
[19] Chi Qingguo, Yang Meng, Zhang Changhai, et al.Nonlinear electrical conductivity and thermal pro- perties of AgNPs/BN/EPDM composites for cable accessory[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2019, 26(4): 1081-1088.
[20] 杨娟娟, 贺伟. 高压电缆附件用橡胶的性能考核要求讨论[J]. 电线电缆, 2017(5): 35-38.
Yang Juanjuan, He Wei.Discussion for property requirements of rubber insulation in high-voltage power cable accessories[J]. Electric Wire & Cable, 2017(5): 35-38.
[21] Zhu Mingxiao, Gao Ying, Chen Jiming, et al.Effect of XLPE/EPDM interface on space charge behavior in cable accessory[J]. IEEE Access, 2019, 7: 183554-183564.
[22] 周凯, 吴科, 万利, 等. 无机纳米颗粒抑制中压电缆终端气隙缺陷局部放电的有效性[J]. 电工技术学报, 2016, 31(22): 230-238.
Zhou Kai, Wu Ke, Wan Li, et al.Validity of inorganic nano-particles on the suppression of partial discharge in air gap defects for medium voltage cable termi- nations[J]. Transactions of China Electrotechnical Society, 2016, 31(22): 230-238.
[23] 李维康, 张翀, 闫轰达, 等. 高压直流电缆用交联聚乙烯绝缘材料交联特性及机理[J]. 高电压技术, 2017, 43(11): 3599-3606.
Li Weikang, Zhang Chong, Yan Hongda, et al.Crosslinking characteristic and mechanism of cross- linked polyethylene insulating materials used for high voltage direct current cables[J]. High Voltage Engin- eering, 2017, 43(11): 3599-3606.
[24] 梁英, 郭兴五. 基于FTIR的硅橡胶绝缘材料的老化程度评估[J]. 高压电器, 2015, 51(8): 62-67.
Liang Ying, Guo Xingwu.Aging condition assessment of silicone rubber for composite insulators based on FTIR[J]. High Voltage Apparatus, 2015, 51(8): 62-67.
[25] 夏云峰, 宋新明, 何建宗, 等. 复合绝缘子用硅橡胶老化状态评估方法[J]. 电工技术学报, 2019, 34(增刊1): 440-448.
Xia Yunfeng, Song Xinming, He Jianzong, et al.Evaluation method of aging for silicone rubber of composite insulator[J]. Transactions of China Electro- technical Society, 2019, 34(S1): 440-448.
[26] Li Jin, Du Boxue, Su Jingang, et al.Surface layer fluorination-modulated space charge behaviors in HVDC cable accessory[J]. Polymers, 2018, 10(5): 500.
[27] 杨帆, 杨旗, 程鹏, 等. 电缆接头内部气隙放电缺陷下的绝缘劣化程度表征方法[J]. 电工技术学报, 2017, 32(2): 24-32.
Yang Fan, Yang Qi, Cheng Peng, et al.Study of cracking extent for gap discharge in insulating material of power cable joint[J]. Transactions of China Electrotechnical Society, 2017, 32(2): 24-32.
[28] He Dongxin, Meng Fansong, Liu Hongshun, et al.The influence mechanism of semiconductive material on space charge accumulation in HVDC cable acce- ssory[J]. IEEE Transactions on Dielectrics and Elec- trical Insulation, 2019, 26(5): 1479-1486.
[29] 吴世林, 杨庆, 邵涛. 低温等离子体表面改性电极材料对液体电介质电荷注入的影响[J]. 电工技术学报, 2019, 34(16): 3494-3503.
Wu Shilin, Yang Qing, Shao Tao.Effect of surface- modified electrode by low temperature plasma on charge injection of liquid dielectric[J]. Transactions of China Electrotechnical Society, 2019, 34(16): 3494-3503.
[30] Shang Nanqiang, Chen Qingguo, Wei Xinzhe.Pre- paration and dielectric properties of SiC/LSR nanocomposites for insulation of high voltage direct current cable accessories[J]. Materials, 2018, 11(3): 403.
[31] 戴征宇, 姜芸, 罗俊华. 预制型电缆附件沿面放电试验研究[J]. 高电压技术, 2002, 28(9): 7-8.
Dai Zhengyu, Jiang Yun, Luo Junhua.Test and research of surface discharge in pre-moulded power cable accessories[J]. High Voltage Engineering, 2002, 28(9): 7-8.