电工技术学报  2021, Vol. 36 Issue (14): 3081-3089    DOI: 10.19595/j.cnki.1000-6753.tces.200434
高电压与放电 |
高压直流电缆附件XLPE/SIR材料特性及界面电荷积聚对电场分布的影响
李国倡1, 王家兴1, 魏艳慧1, 张升2, 雷清泉1
1. 青岛科技大学先进电工材料研究院 青岛 266042;
2. 全球能源互联网研究院有限公司 北京 102200
Effect of Material Properties of XLPE/SIR and Interface Charge Accumulation on Electric Field Distribution of HVDC Cable Accessory
Li Guochang1, Wang Jiaxing1, Wei Yanhui1, Zhang Sheng2, Lei Qingquan1
1. Institute of Advanced Electrical Materials Qingdao University of Science and Technology Qingdao 266042 China;
2. Global Energy Interconnection Research Institute Beijing 102200 China
全文: PDF (6258 KB)   HTML
输出: BibTeX | EndNote (RIS)      
摘要 双层绝缘介质界面电荷积聚是导致高压直流电缆附件界面放电的重要原因。该文测量分析交联聚乙烯(XLPE)和硅橡胶(SIR)两种介质的介电性能、电导特性和导热特性;通过建立高压直流附件电-热仿真模型,研究不同温度下XLPE/SIR界面电荷积聚特性及局部电场畸变引起的附件内部电场变化规律。实验结果表明,室温下SIR的电导率略高于XLPE材料,随着温度的升高,XLPE的电导率增加较为明显,而SIR的电导率增加则相对缓慢,高温下两种介质电导率不匹配是导致界面电荷积聚的重要原因。室温下XLPE/SIR界面积聚负电荷面密度约为3.42×10-4C/m2,这部分电荷会增强电缆主绝缘电场,削弱应力锥根部电场畸变,主绝缘电场增加约36%,应力锥根部电场畸变下降约62%。当温度超过约36℃时,XLPE/SIR界面开始积聚正电荷,随着温度的升高,开始出现极性反转现象,造成应力锥根部局部电场畸变加重,70℃时最大畸变电场达到12kV/mm。
服务
把本文推荐给朋友
加入我的书架
加入引用管理器
E-mail Alert
RSS
作者相关文章
李国倡
王家兴
魏艳慧
张升
雷清泉
关键词 直流电缆附件电导特性电场分布界面电荷积聚    
Abstract:Interface charge accumulation between double-layer dielectric is the key factor causing interface discharge of the high voltage direct current (HVDC) cable accessory. In this paper, the dielectric properties, conductivity and thermal conductivity of XLPE and SIR were measured. The charge accumulation properties of the XLPE/SIR interface and the variation of internal electric field caused by local electric field distortion were studied. The experimental results show that as the temperature increases, the conductivity of XLPE increases significantly, while the conductivity of SIR increases relatively slowly. The mismatch of the conductivity of the two materials at high temperature is an important reason for the interface charge accumulation. At room temperature, the negative charge at the XLPE/SIR interface is about 3.42×10-4C/m2, which will enhance the electric field of the cable main insulation and weaken the electric field distortion at the root of the stress cone. Electric field of the main insulation increases about 36% and the electric field distortion at the stress cone root decreases about 62%. When the temperature exceeds about 36℃, positive charges begin to accumulate at the interface of XLPE/SIR. As the temperature increases, polarity reversal phenomenon occurs, which leads to aggravation of the local electric field distortion at the root of stress cone, and the maximum distortion electric field reaches 12kV/mm at 70℃.
Key wordsDC cable accessory    conductivity properties    electric field distribution    interface charge accumulation   
收稿日期: 2020-05-05     
PACS: TM853  
基金资助:国家电网公司资助项目(SGTYHT/15-JS-191)
通讯作者: 魏艳慧 女,1986年生,博士,副教授,硕士生导师,研究方向为高压设备绝缘状态评估、高压电缆半导电屏蔽料特性及应用。E-mail: Weiyhui@126.com   
作者简介: 李国倡 男,1985年生,博士,副教授,硕士生导师,研究方向为电力设备绝缘材料与绝缘技术、多场耦合下绝缘部件电场仿真与结构优化。E-mail: Lgc@qust.edu.cn
引用本文:   
李国倡, 王家兴, 魏艳慧, 张升, 雷清泉. 高压直流电缆附件XLPE/SIR材料特性及界面电荷积聚对电场分布的影响[J]. 电工技术学报, 2021, 36(14): 3081-3089. Li Guochang, Wang Jiaxing, Wei Yanhui, Zhang Sheng, Lei Qingquan. Effect of Material Properties of XLPE/SIR and Interface Charge Accumulation on Electric Field Distribution of HVDC Cable Accessory. Transactions of China Electrotechnical Society, 2021, 36(14): 3081-3089.
链接本文:  
https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.200434          https://dgjsxb.ces-transaction.com/CN/Y2021/V36/I14/3081