具有恒压输出特性的电场耦合式动态无线电能传输技术

doi:10.19595/j.cnki.1000-6753.tces.221705

摘要
图/表
参考文献
相关文章 (13)

全文: PDF (2160 KB)
输出: BibTeX | EndNote (RIS)

摘要

电场耦合式无线电能传输(Electric-filed Coupled Wireless Power Transfer, EC-WPT)技术具有耦合机构轻、涡流损耗小和抗偏移性强等优势,这些优势很好的契合了动态无线电能传输系统的需求。但是,耦合参数和负载电阻的时变性会对EC-WPT系统的输出电压平稳性产生影响。因此,本文提出了一种具有变负载与过分段恒压输出特性的动态EC-WPT系统。基于反混合G参数建立了多端口电场耦合机构数学模型和等效电路,在此模型上提出了兼具极板恒压与输出恒压特性的高阶补偿网络,并分析了发射端同侧耦合对系统谐振的影响。理论分析表明所设计的动态EC-WPT系统兼具变负载和过分段输出电压平稳的特性,同时论证了同侧耦合对系统的谐振的影响为感性。实验结果显示当直流侧负载从100 Ω切换到30 Ω时,系统输出电压变化率最大为11.58%,变负载电压基本恒定。30 Ω负载下系统动态经过供电分段时输出电压跌落最大为2.33%,100 Ω负载下系统动态经过供电分段时则为2.06%,过供电分段输出电压基本保持恒定。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	唐丁源
	周玮
	黄亮
	麦瑞坤
	何正友

关键词 ：动态无线电能传输, 电场耦合式无线电能传输, 变负载, 过分段, 恒压输出

Abstract：

Electric-field coupled wireless power transfer (EC-WPT) system uses high frequency electric field among metal plates to realize power transmission, which has the advantages of light coupling interface, low eddy current and better anti-misalignment. Dynamic wireless power transfer (DWPT) technology can realize continuous power supply during the moving process of electrical equipment. The advantages of EC-WPT technology are highly consistent with the special requirements of DWPT, because the moving equipment has restrict requirements on the volume and weight of the power receiving unit of the DWPT system.
DWPT system usually adopts segmented transmitting coils or plates. However, the segmented transmitting structure introduces two new problems for DWPT systems: (1) when the distance between the adjacent transmitting plates is small, the mutual coupling between the transmitting ports will affect the system resonance; on the contrary, when the adjacent plates are far apart, the output voltage will drop when the receiver is moving over the segments. (2) How to keep the system voltage gain consistent when the receiver position and load resistance change.
In the existing researches on EC-WPT system, decoupled electric-field coupler that suitable for DWPT system has not been proposed, so the same-sided coupling between adjacent transmitters of EC-WPT system is unavoidable. Moreover, the influence principle of same-sided coupling on the resonance of dynamic EC-WPT system is not well researched either. Because the EC-WPT system uses electric field as power transfer medium, the electric field intensity around transmitting plates should be evenly distributed to ensure a constant induced voltage on the receiver under different operating conditions. Then the output voltage of the dynamic EC-WPT system can be kept constant under varying receiver positions and load resistance by using a LCLC-S compensation network. The main contents of this paper are as follows:
For the segmented coupler of the dynamic EC-WPT system, an inverse hybrid G-parameter model of multi-port electric field coupler is proposed based on the existing multi-port Z-parameter model. In the proposed model, the self-capacitance on the primary side is connected with the reflected impedance (or controlled source) in parallel. Then the constant voltage of the transmitting plates is achieved by using a high-order compensation network of LCLC-S topology. Finally, the influence of the same-side coupling between the transmitters on the zero-voltage switching (ZVS) condition of the inverter is also analyzed in detail.
Theoretical analysis shows that the proposed system has the properties of constant output voltage against the variable load and different receiver positions. The influence of the same-sided coupling makes the input impedance slightly inductive, which is beneficial to the ZVS condition of inverters. In the experiment, a prototype of dynamic EC-WPT system is constructed. The experimental results show that when the load varies from 100 Ω to 30 Ω, the maximum change rate of the system output voltage is 11.58%. When the power pickup moves over two adjacent transmitters, the change rate of the system output voltage is no more than 2.33% when the load is 30 Ω, and no more than 2.06% when the load is 100 Ω. Overall, the output voltage of the proposed system is approximately constant in both cases above.

Key words： Dynamic wireless power transfer electric-field coupled wireless power transfer (EC-WPT) load variation over segment constant voltage output

收稿日期: 2022-09-06

PACS:

TM724

基金资助:

国家自然科学基金（51907170）和四川省科技计划（2021YFH0039）资助项目

通讯作者: 周玮男,1990年生,博士,副研究员,硕士生导师,研究方向为无线电能传输技术及其应用。E-mail：wzhou@swjtu.edu.cn

作者简介: 唐丁源男,1999年生,硕士研究生,研究方向电场耦合式无线电能传输技术。E-mail：tdy@my.swjtu.edu.cn

引用本文:

唐丁源, 周玮, 黄亮, 麦瑞坤, 何正友. 具有恒压输出特性的电场耦合式动态无线电能传输技术[J]. 电工技术学报, 0, (): 84-84. Tang Dingyuan, Zhou Wei, Huang Liang, Mai Ruikun, He Zhengyou. Dynamic Electric-Filed Coupled Wireless Power Transfer System with Constant Voltage Output Characteristics. Transactions of China Electrotechnical Society, 0, (): 84-84.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.221705 https://dgjsxb.ces-transaction.com/CN/Y0/V/I/84

[1] 陈希有, 伍红霞, 牟宪民, 等. 电容耦合式无线电能传输系统阻抗变换网络的设计[J]. 电工电能新技术, 2015, 34(09): 57-63.
Cheng Xiyou, Wu Hongxia, Mu Xianmin, et al.Design of impedance conversion network employed for capacitive coupled wireless power transmission system[J]. Advanced Technology of Electrical Engineering and Energy, 2015, 34(09): 57-63.
[2] Qing X, Wang Z, Su Y, et al.Parameter design method with constant output voltage characteristic for bilateral LC-compensated CPT system[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, 8(3): 2707-2715.
[3] 赵鱼名, 王智慧, 苏玉刚, 等. 基于T型CLC谐振网络的恒压型电场耦合电能传输系统负载自适应技术[J]. 电工技术学报, 2020, 35(01): 106-114.
Zhao Yuming, Wang Zhihui, Su Yugang, et al.Load adaptive technology of constant voltage electric-field coupled power transfer system based on T-CLC resonant network[J]. Transactions of China Electrotechnical Society, 2020, 35(01): 106-114.
[4] Wang S, Liang J, Fu M.Analysis and design of capacitive power transfer systems based on induced voltage source model[J]. IEEE Transactions on Power Electronics, 2020, 35(10): 10532-10541.
[5] 廖志娟,周磊,吴镇,魏国玉,夏晨阳.变结构LC-CLCL拓扑恒压恒流型电场耦合电能传输系统[J].中国电机工程学报, 2021, 41(17): 6039-6050.
Liao Zhijuan, Zhou Lei, Wu Zhen, et al.An electric-field coupled power transfer system with constant voltage and constant current output based on changeable LC-CLCL resonant circuit[J]. Proceedings of the CSEE, 2021, 41(17): 6039-6050.
[6] 卿晓东, 苏玉刚. 电场耦合无线电能传输技术综述[J]. 电工技术学报, 2021, 36(17): 3649-3663.
Qing Xiaodong, Su Yugang.An Overview of Electric-Filed Coupling Wireless Power Transfer Technology[J] Transactions of China Electrotechnical Society, 2021, 36(17): 3649-3663.
[7] 苏玉刚, 刘家鸣, 王智慧, 等. 磁耦合机构拾取线圈平面金属的影响及其抑制方法[J]. 电工技术学报, 2022, 37(3): 578-588.
Su Yugang, Liu Jiaming, Wang Zhihui, et al.Influence analysis of metal in the same plane with pickup coil on magnetic coupler and suppression method[J]. Transactions of China Electrotechnical Society, 2022, 37(3): 578-588.
[8] 苏玉刚, 钱林俊, 刘哲, 等. 水下具有旋转耦合机构的电场耦合无线电能传输系统及参数优化方法[J]. 电工技术学报, 2022, 37(10): 2399-2410.
Su Yugang, Qian Linjun, Liu Zhe, et al.Underwater electric-filed coupled wireless power transfer system with rotary coupler and parameter optimization method[J]. Transactions of China Electrotechnical Society, 2022, 37(10): 2399-2410.
[9] 武帅, 陈星维, 孟祥尧, 等. 具有强抗偏移及轻量化特性的电场耦合式无人机无线电能传输系统[J]. 中国电机工程学报, 2022:1-11. (Online)
Wu Shuai, Cheng Xinwei, Meng Xiangyao, et al.An electric-field coupled wireless power transfer system with misalignment-tolerance and light-weight characteristics for unmanned aerial vehicle applications[J]. Proceedings of the CSEE, 2022: 1-11.
[10] 郭历谋, 罗博, 麦瑞坤. 基于电场耦合式的电动汽车无线充电技术电压优化方法[J]. 电工技术学报, 2020, 35(S1): 19-27.
Guo Limou, Luo Bo, Mai Ruikun.Voltage optimization method for wireless charging of electric vehicles based on capacitive power transfer[J]. Transactions of China Electrotechnical Society, 2020, 35(S1): 19-27.
[11] Zhu J, Ban Y, Xu R, et al.An NFC-CPT-combined coupler with series-none compensation for metal-cover smartphone applications[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2021, 9(3): 3758-3769.
[12] Liu Z, Su Y, Zhao Y, et al.Capacitive power transfer system with double T-type resonant network for mobile devices charging/supply[J]. IEEE Transactions on Power Electronics, 2022, 37(2): 2394-2403.
[13] 蒋成, 孙跃, 王智慧, 等. 电动汽车无线供电导轨切换模式分析[J]. 电力系统自动化, 2017, 41(12): 188-193.
Jiang Cheng, Sun Yue, Wang Zhihui, et al.Switching mode analysis of wireless supplying rail for electric vehicles[J]. Automation of Electric Power Systems, 2017, 41(12): 188-193.
[14] Jiang J, Dai X, Hu A P.A dynamic tuning method for ZPA frequency operation of MEU-WPT system by DC input voltages regulation[J]. IEEE Transactions on Power Electronics, 2022, 37(9): 11369-11381.
[15] Budhia M, Boys J T, Covic G A, et al.Development of a single-sided flux magnetic coupler for electric vehicle IPT charging systems[J]. IEEE Transactions on Industrial Electronics, 2013, 60(1): 318-328.
[16] Zaheer A, Neath M, Beh H Z, et al.A dynamic EV charging system for slow moving traffic applications[J]. IEEE Transactions on Transportation Electrification, 2017, 3(2): 354-369.
[17] 庄廷伟, 姚友素, 袁悦, 等. 基于DDQ/DD耦合机构的强抗偏移电动汽车用无线充电系统[J]. 中国电机工程学报, 2022,42(15):5675-5685
Zhuang Tingwei, Yao Yousu, Yuan Yue, et al.A DDQ/DD-coupler-based wireless power transfer system for electric vehicles (EV) charging featuring high misalignment tolerance[J]. Proceedings of the CSEE, 2022,42(15):5675-5685.
[18] Liu Y R, Mai R K, Li D W, et al.Efficiency optimization for wireless dynamic charging system with overlapped DD coil arrays[J]. IEEE Transactions on Power Electronics, 2018, 33(4): 2832-2846.
[19] Zhou W, Huang L, Luo B, et al.A general mutual coupling model of MIMO capacitive coupling interface with arbitrary number of ports[J]. IEEE Transactions on Power Electronics, 2021, 36(6): 6163-6167.
[20] Cheng C, Li W, Zhou Z, et al.A load-independent wireless power transfer system with multiple constant voltage outputs[J]. IEEE Transactions on Power Electronics, 2020, 35(4): 3328-3331.
[21] Mao X, Chen J, Zhang Y, et al.A simple and reconfigurable wireless power transfer system with constant voltage and constant current charging[J]. IEEE Transactions on Power Electronics, 2022,37(5):4921-4925.
[22] Su Y, Zhang S, Hu C, et al.An embeddable transmitter coil applied to electric vehicles powered by IPT system[J]. International journal of applied electromagnetics and mechanics, 2016, 50(4): 627-636.
[23] Zhu Q, Wang L, Guo Y, et al.Applying LCC compensation network to dynamic wireless EV charging system[J]. IEEE Transactions on Industrial Electronics, 2016, 63(10): 6557-6567.
[24] Feng H, Cai T, Duan S, et al.An LCC-compensated resonant converter optimized for robust reaction to large coupling variation in dynamic wireless power transfer[J]. IEEE Transactions on Industrial Electronics, 2016, 63(10): 6591-6601.
[25] Lu F, Zhang H, Hofmann H, et al.A dynamic capacitive power transfer system with reduced power pulsation[C], 2016 IEEE PELS Workshop on Emerging Technologies: Wireless Power Transfer (WoW), Knoxville, TN, USA, 2016.
[26] Li S, Liu Z, Zhao H, et al.Wireless power transfer by electric field resonance and its application in dynamic charging[J]. IEEE Transactions on Industrial Electronics, 2016, 63(10): 6602-6612.