锂离子电池在不同区间下的衰退影响因素分析及任意区间的老化趋势预测

doi:10.19595/j.cnki.1000-6753.tces.200071

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2020 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要准确估计锂离子电池的健康状态（SOH）对于控制策略制定和运行维护至关重要。考虑到充放电区间和电压相变过程对电池老化的影响,该文针对2.75A•h 18650型号三元电池设计了11个荷电状态（SOC）区间的循环寿命测试与性能测试。根据实验结果,分别分析循环区间荷电状态（SOC）宽度、恒压充电时间、平均SOC和充电相变过程对电池老化快慢的作用机制。结合电池老化机理和实验结果,提取量化SOC区间对老化影响程度大小的特征参数。建立预测健康状态的循环神经网络（LSTM RNN）模型,用于学习电池老化对于循环次数及特征参数的长期依赖关系。分别采用误差最大值、平均绝对误差、方均根误差和方差对模型的准确性和可靠性进行分析。结果表明,该文提出的区间循环寿命模型能实现任意区间的老化趋势预测,节省测试时间和测试成本。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	孙丙香
	任鹏博
	陈育哲
	崔正韬
	姜久春

关键词 ：锂离子电池, SOC区间, 老化预测, 循环神经网络

Abstract：The accurate estimation of the state of health（SOH）of lithium-ion batteries is very important for the development of controlling strategies and operating maintenance. Considering the influence of charge-discharge interval and voltage phase transition process on battery aging, in this paper, 11 cycle life and performance tests in different state of charge (SOC) intervals were designed for 2.75Ah 18650 energy Lithium-ion battery. According to the experimental results, the mechanism of SOC width, constant voltage charging process, average SOC and charging phase transition process on battery aging were analyzed. Based on the aging mechanism and experimental results of batteries, the characteristic parameters which quantify the influence of partial SOC intervals on aging were extracted. The SOH prediction model based on recurrent neural network with long-short term memory network (LSTM RNN) was established to study the long-term dependence of battery aging on cycle numbers and characteristic parameters. The accuracy and reliability of the model were analyzed by the maximum error, the average absolute error, the root mean square error and the variance. The results show that the cycle life model proposed in this paper can predict the capacity degradation trend of any SOC interval and save testing time and cost.

Key words： Lithium-ion battery SOC intervals aging prediction recurrent neural network

收稿日期: 2020-01-16

PACS:

TM911

基金资助:家重点研发计划（2018YFB0104400）和国家自然科学基金（51907005）资助项目

通讯作者: 孙丙香女,1979年生,副教授,博士生导师,研究方向为动力电池成组应用技术。E-mail：bxsun@bjtu.edu.cn

作者简介: 任鹏博男,1992年生,硕士研究生,研究方向为动力电池成组应用技术。E-mail：16121507@bjtu.edu.cn

引用本文:

孙丙香, 任鹏博, 陈育哲, 崔正韬, 姜久春. 锂离子电池在不同区间下的衰退影响因素分析及任意区间的老化趋势预测[J]. 电工技术学报, 2021, 36(3): 666-674. Sun Bingxiang, Ren Pengbo, Chen Yuzhe, Cui Zhengtao, Jiang Jiuchun. Analysis of Influencing Factors of Degradation under Different Interval Stress and Prediction of Aging Trend in Any Interval for Lithium-Ion Battery. Transactions of China Electrotechnical Society, 2021, 36(3): 666-674.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.200071 https://dgjsxb.ces-transaction.com/CN/Y2021/V36/I3/666

[1] 陈景文, 莫瑞瑞, 党宏社, 等. 储能型光伏系统电池容量优化配置及经济性分析[J]. 科学技术与工程, 2019, 19(28): 165-171.
Chen Jingwen, Mo Ruirui, Dang Hongshe, et al.Battery capacity optimal configuration and economical analysis of energy storage photuvataic system[J]. Sciece Technology and Engineering, 2019, 19(28): 165-171.
[2] 孙丙香, 姜久春, 韩智强, 等. 基于不同衰退路径下的锂离子动力电池低温应力差异性[J]. 电工技术学报, 2016, 31(10): 159-167.
Sun Bingxiang, Jiang Jiuchun, Han Zhiqiang, et al.The lithium-ion battery low temperature stress based on different degradation paths[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 159-167.
[3] Guo Binqi, Niu Meng, Lai Xiaokang, et al.Application research on large-scale battery energy storage system under global energy interconnection framework[J]. Global Energy Interconnection, 2018, 1(1): 79-86.
[4] Saxena S, Hendricks C, Pecht M.Cycle life testing and modeling of graphite/LiCoO₂ cells under different state of charge ranges[J]. Journal of Power Sources, 2016, 327: 394-400.
[5] Gao Yang, Jiang Jiuchun, Zhang Caiping, et al.Lithium-ion battery aging mechanisms and life model under different charging stresses[J]. Journal of Power Sources, 2017, 356: 103-114.
[6] Ecker M, Nieto N, Stefan K, et al.Calendar and cycle life study of Li(NiMnCo)O₂-based 18650 lithium-ion batteries[J]. Journal of Power Sources, 2014, 248: 839-851.
[7] Xu Bolun, Oudalov A, Ulbig A, et al.Modeling of lithium-ion battery degradation for cell life assessment[J]. IEEE Transactions on Smart Grid, 2018, 9(2): 1131-1140.
[8] 马泽宇, 姜久春, 张维戈, 等. 锂离子动力电池热老化的路径依赖性研究[J]. 电工技术学报, 2014, 29(5): 221-227.
Ma Zeyu, Jiang Jiuchun, Zhang Weige, et al.Path dependence of thermal aging of Li-ion power battery[J]. Transactions of China Electrotechnical Society, 2014, 29(5): 221-227.
[9] Hu Xiaosong, Xu Le, Lin Xianke, et al.Battery lifetime prognostics[J]. Joule, 2020, 4(2): 310-346.
[10] Li Y, Abdel-Monem M, Gopalakrishnan R, et al.A quick on-line state of health estimation method for Li-ion battery with incremental capacity curves processed by Gaussian filter[J]. Journal of Power Sources, 2018, 373: 40-53.
[11] Xiong Rui, Tian Jinpen, Mu Hao, et al.A systematic model-based degradation behavior recognition and health monitoring method for lithium-ion batteries[J]. Applied Energy, 2017, 207: 372-383.
[12] Hu Xiaosong, Feng Fei, Liu Kailong, et al.State estimation for advanced battery management: key challenges and future trends[J]. Renewable and Sustainable Energy Reviews, 2019, 114: 109334.
[13] Lam L, Bauer P.Practical capacity fading model for li-ion battery cells in electric vehicles[J]. IEEE Transactions on Power Electronics, 2013, 28(12): 5910-5918.
[14] 薛楠, 孙丙香, 白恺, 等. 基于容量增量分析的复合材料锂电池分区间循环衰退机理[J]. 电工技术学报, 2017, 32(13): 145-152.
Xue Nan, Sun Bingxiang, Bai Kai, et al.Different state of charge range cycle degradation mechanism of composite material lithium-ion batteries based on incremental capacity analysis[J]. Transactions of China Electrotechnical Society, 2017, 32(13): 145-152.