Abstract：Aiming at the wide output voltage fluctuation range of photovoltaic solar panels, an isolated DC/DC converter with wide range input based on variable topology is proposed. Through the dual-mode dual-edge modulation, the converter is working with a variable topology, to achieve a wide range of voltage input. At the same time, the inductor current ripple and its average for the converter in the modulation are reduced, and the current stress of the switch is low. Besides, the conduction and the switching loss are also small. As a result, the efficiency is higher than that of the single-mode modulation. Finally, an experimental prototype with input voltage of 24V~120V, output voltage of 360V and a rated power of 200W was constructed. The experimental data have verified the feasibility of the proposed variable topology converter running in the wide input voltage range as well as the effectiveness of the modulation strategy.
李山, 宋立风, 章治国, 刘述喜, 郭强. 基于变拓扑的超宽输入范围直流变换器及调制策略[J]. 电工技术学报, 2019, 34(2): 326-336.
Li Shan, Song Lifeng, Zhang Zhiguo, Liu Shuxi, Guo Qiang. Wide Input Range DC Converter Based on Variable Topology and Its Modulation Strategy. Transactions of China Electrotechnical Society, 2019, 34(2): 326-336.
[1] 姚川, 阮新波, 王学华. 宽输入电压范围下隔离型全桥Boost变换器的高效率控制[J]. 电工技术学报, 2012, 27(2): 1-9. Yao Chuan, Ruan Xinbo, Wang Xuehua.Efficient control of isolated full-bridge Boost converter in wide input voltage range[J]. Journal of Electrical Engineering, 2012, 27(2): 1-9. [2] 张犁, 孙凯, 吴田进, 等. 基于光伏发电的直流微电网能量变换与管理[J]. 电工技术学报, 2013, 28(2): 248-254. Zhang Li, Sun Kai, Wu Tianjin, et al.Energy conversion and management of DC microgrid based on photovoltaic power generation[J]. Journal of Electrical Engineering, 2013, 28(2): 248-254. [3] Zhao Xiaonan, Zhang Lanhua, Born R, et al.A high-efficiency hybrid resonant converter with wide- input regulation for photovoltaic applications[J]. IEEE Transactions on Industrial Electronics, 2017, 64(5): 3684-3695. [4] 陆杨军, 邢岩, 吴红飞, 等. 宽电压范围双移相控制多倍压高增益软开关隔离升降压变换器[J]. 电工技术学报, 2016, 31(13): 10-17. Lu Yangjun, Xing Yan, Wu Hongfei, et al.Wide voltage range double phase shift control multi- voltage high gain soft-switching isolation Buck- Boost converter[J]. Journal of Electrical Engineering, 2016, 31(13): 10-17. [5] Yang Bo, Li Wuhua, Zhao Yi, et al.Design and analysis of a grid-connected photovoltaic power system[J]. IEEE Transactions on Power Electronics, 2010, 25(4): 992-1000. [6] Lee J P, Min B D, Kim T J, et al.A novel topology for photovoltaic DC/DC full-bridge converter with flat efficiency under wide PV module voltage and load range[J]. IEEE Transactions on Industrial Electronics, 2008, 55(7): 2655-2663. [7] 陈权, 李令冬, 王群京, 等. 光伏发电并网系统的仿真建模及对配电网电压稳定性影响[J]. 电工技术学报, 2013, 28(3): 241-247. Chen Quan, Li Lingdong, Wang Qunjing, et al.Simulation modeling of photovoltaic power generation grid-connected system and its influence on voltage stability of distribution network[J]. Transactions of China Electrotechnical Society, 2013, 28(3): 241-247. [8] Walker G R, Sernia P C.Cascaded DC-DC converter connection of photovoltaic modules[J]. IEEE Transactions on Power Electronics, 2002, 19(4): 1130-1139. [9] Femia N, Lisi G, Petrone G, et al.Distributed maximum power point tracking of photovoltaic arrays: novel approach and system analysis[J]. IEEE Transactions on Industrial Electronics, 2008, 55(7): 2610-2621. [10] 胡海兵, 吴红飞, 刘薇, 等. 一族有源钳位正激变换器[J]. 电工技术学报,2013, 28(12): 245-250, 261. Hu Haibing, Wu Hongfei, Liu Wei, et al.A family of active clamp forward converters[J]. Transactions of China Electrotechnical Society, 2013, 28(12): 245-250, 261. [11] 李龙春, 嵇保健, 洪峰, 等. 1500V三电平正激变换器[J]. 电工技术学报, 2018, 33(9): 2044-2054. Li Longchun, Ji Baojian, Hong Feng, et al.1500V three-level forward converter[J]. Transactions of China Electrotechnical Society, 2018, 33(9): 2044-2054. [12] Perrin R, Quentin N, Allard B, et al.High- temperature GaN active-clamp flyback converter with resonant operation mode[J]. IEEE Journal of Emerging & Selected Topics in Power Electronics, 2017, 4(3): 1077-1085. [13] 姚川, 阮新波, 曹伟杰, 等. 双管Buck-Boost变换器的输入电压前馈控制策略[J]. 中国电机工程学报, 2013, 33(21): 36-44. Yao Chuan, Ruan Xinbo, Cao Weijie, et al.Input voltage feedforward control strategy for double-tube Buck-Boost converter[J]. Proceedings of the CSEE, 2013, 33(21): 36-44. [14] 雷志方, 汪飞, 高艳霞, 等. 面向直流微网的双向DC-DC变换器研究现状和应用分析[J]. 电工技术学报, 2016, 31(22): 137-147. Lei Zhifang, Wang Fei, Gao Yanxia, et al.Research status and application of bidirectional DC-DC converters for DC microgrid[J]. Transactions of China Electrotechnical Society, 2016, 31(22): 137-147. [15] Park J, Fan Jiwei, Wang Xiaopeng, et al.A sample- data model for double edge current programmed mode control (DECPM) in high-frequency and wide- range DC-DC converters[J]. IEEE Transactions on Power Electronics, 2010, 25(4): 1023-1033. [16] Chen C W, Chen K H, Chen Y M.Modeling and controller design of an autonomous PV module for DMPPT PV systems[J]. IEEE Transactions on Power Electronics, 2014, 29(9): 4723-4732. [17] Tsai Y Y, Tsai Y S, Tsai C W, et al.Digital noninverting-Buck-Boost converter with enhanced duty-cycle-overlap control[J]. IEEE Transactions on Circuits & Systems II: Express Briefs, 2017, 64(1): 41-45. [18] Kumar A, Sensarma P.A 4-switch single-stage single- phase Buck-Boost inverter[J]. IEEE Transactions on Power Electronics, 2017, 32(7): 5282-5292. [19] 任小永, 阮新波, 李明秋, 等. 双沿调制的四开关Buck-Boost变换器[J]. 中国电机工程学报, 2009, 29(12): 16-23. Ren Xiaoyong, Ruan Xinbo, Li Mingqiu, et al.Four-switch Buck-Boost converter with double-edge modulation[J]. Proceeding of the CSEE, 2009, 29(12): 16-23. [20] 张建丰, 许建平, 周翔, 等. 一种基于辅助网络的软开关二次型Boost高增益变换器[J]. 电工技术学报, 2017, 32(24): 71-79. Zhang Jianfeng, Xu Jianping, Zhou Xiang, et al.A soft switch quadratic Boost high gain converter based on auxiliary networks[J]. Transactions of China Electrotechnical Society, 2017, 32(24): 71-79. [21] 姚川. 适用于宽输入电压范围的Buck-Boost直流变换器及其控制策略的研究[D]. 武汉: 华中科技大学, 2013.
2019, Vol. 34 
