Research On Concrete Damage Detection under Stray Current Environment Based on Ground Penetrating Radar
Cai Zhichao1,2,3, Yu Yiru2, Zhang Jing2
1. State Key Laboratory of Rail Transit Infrastructure Performance Testing and Guarantee East China Jiaotong University Nanchang 330013 China; 2. School of Electrical and Automation Engineering East China Jiaotong University Nanchang 330013 China; 3. State Key Laboratory of Reliability and Intelligence of Electrical Equipment Hebei University of Technology Tianjin 300130 China
Abstract：Due to the incomplete insulation of the running rail to the ground, stray current leakage occurs during subway operation, which leads to electrochemical corrosion of reinforced concrete structure along the subway. The purpose of this study is to study the electrochemical corrosion of steel bars and the evolution of concrete damage caused by stray current, and to detect cracks caused by corrosion damage of reinforced concrete by ground penetrating radar (GPR). Firstly, a two-dimensional reinforced concrete model was established. Then, in order to more realistically simulate the evolution of cracks in reinforced concrete due to reinforcement corrosion, a tertiary current distribution, Nernst-Plank interface, is added to simulate electrochemical corrosion of reinforcement induced by external oxygen, in which oxygen diffuses from the left surface of the concrete to the interior. At the same time, solid mechanics physical field is added to simulate the strain of reinforcement and concrete due to reinforcement corrosion. Secondly, based on the multi-physics method, the two-dimensional transient simulation of the electrochemical corrosion process of reinforced concrete is studied, and the approximate actual corrosion damage map of reinforced concrete structure under different service times is obtained. Then, the obtained damage map was transformed by gray scale, and the corresponding electrical parameters (relative permeability, conductivity and relative permeability) were assigned to different media regions (concrete, steel bars and cracks) in the damage map. Finally, based on the ground penetrating radar numerical forward simulation method, the damage map after gray level change was simulated by A-scan and B-scan. The evolution of concrete damage caused by electrochemical corrosion of rebar during 0~3 800 days in service time was studied. Only when the expansion stress generated by the corrosion products is greater than the tensile strength of the concrete, the cracks will appear in the concrete around the rebar and gradually expand to the surrounding areas, and the distribution of cracks gradually changes from uniform distribution to uneven distribution. During service, the maximum thickness of the corrosion products of the rebar is only about 18.5 μm, and the maximum reduction in the radius of the rebar is only about 8.5 μm. The results of A-scan forward modeling of GPR on the obtained damage map show that the increase of the thickness of steel corrosion products and the decrease in the radius of rebars have little influence on the detection signal of GPR, and the degree of crack expansion is directly related to the degree of electrochemical corrosion of the rebar, and the reflected signal of the crack can be used as the basis for evaluating the damage degree of concrete. At the same time, the B-scan forward modeling results of GPR show that the hyperbola formed by the reflected wave signal of the rebar has no obvious change when there is no crack. When the cracks appear, the reflected wave signal strength of cracks is higher than that of the rebar, and with the increase of service time, the hyperbolic peak value of the reflected wave of cracks decreases gradually. Finally, the influence of different factors on the crack reflection signal is studied. The results show that when the crack is evenly distributed, the higher the degree of the electrochemical corrosion of the reinforcement, the larger the peak value of the crack reflected wave and the shorter the propagation time. The conclusion of this paper shows that the increase of corrosion product thickness and the decrease of radius of reinforcement have little influence on the detection signal of GPR during the process of electrochemical corrosion of reinforced concrete, and the concrete cracks caused by expansion stress play a major role in the influence of GPR detection signal.
蔡智超, 虞一孺, 张敬. 基于探地雷达的杂散电流环境下混凝土损伤检测研究[J]. 电工技术学报, 2024, 39(21): 6636-6646.
Cai Zhichao, Yu Yiru, Zhang Jing. Research On Concrete Damage Detection under Stray Current Environment Based on Ground Penetrating Radar. Transactions of China Electrotechnical Society, 2024, 39(21): 6636-6646.
[1] 韩宝明, 习喆, 孙亚洁, 等. 2022年世界城市轨道交通运营统计与分析综述[J]. 都市快轨交通, 2023, 36(1): 1-8. Han Baoming, Xi Zhe, Sun Yajie, et al.Statistical analysis of urban rail transit operation in the world in 2022: a review[J]. Urban Rapid Rail Transit, 2023, 36(1): 1-8. [2] 夏宁, 于孝民, 任青文. 混凝土结构耐久性研究现状[J]. 水利水电科技进展, 2005, 25(4): 63-66, 70. Xia Ning, Yu Xiaomin, Ren Qingwen.Current situation of research on durability of concrete structures[J]. Advances in Science and Technology of Water Resources, 2005, 25(4): 63-66, 70. [3] 曹立梅. 浅析混凝土中钢筋锈蚀的原因及其预防措施[J]. 山西建筑, 2018, 44(21): 48-49. Cao Limei.Causes and preventive measures of steel corrosion in concrete[J]. Shanxi Architecture, 2018, 44(21): 48-49. [4] 李海娥. 基于无损检测技术的钢筋混凝土检测研究[J]. 城市建筑, 2022(22): 160-163. Li Haie.Research on reinforced concrete testing based on nondestructive testing technology[J]. Urbanism and Architecture, 2022(22): 160-163. [5] 董军锋, 王耀南, 昝帅. 超声波检测矩形钢管混凝土脱空缺陷的研究[J]. 建筑科学, 2018, 34(1): 103-107. Dong Junfeng, Wang Yaonan, Zan Shuai.Study on ultrasonic detection about void defects of concrete filled rectangular steel tube[J]. Building Science, 2018, 34(1): 103-107. [6] 孙红芳, 赵钿钿, 李冠桦, 等. 利用X射线微型计算机断层扫描技术(Micro-XCT)进行钢筋的通电腐蚀行为及裂缝的三维分布研究[J]. 电子显微学报, 2015, 34(6): 514-520. Sun Hongfang, Zhao Diandian, Li Guanhua, et al.Study of 3D distribution of corrosion products and cracks in rebar reinforced system by micro-XCT[J]. Journal of Chinese Electron Microscopy Society, 2015, 34(6): 514-520. [7] 刘岩. 组合回弹法检测混凝土抗压强度研究[J]. 建筑结构, 2023, 53(10): 91-96. Liu Yan.Study on testing compressive strength of concrete by combined rebound method[J]. Building Structure, 2023, 53(10): 91-96. [8] 王伟, 郑睿. 基于探地雷达的道路半刚性基层含水率检测[J]. 武汉大学学报(工学版), 2022, 55(12): 1248-1255. Wang Wei, Zheng Rui.Water content detection of road semi-rigid base based on ground penetrating radar[J]. Engineering Journal of Wuhan University, 2022, 55(12): 1248-1255. [9] 温世儒, 吴霞. 基于探地雷达和位移反分析的灰岩边坡稳定性数值模拟[J]. 公路交通科技, 2022, 18(10):40-48. Wen Shiru, Wu Xia.Stability numerical simulation of limestone slope based on ground penetrating radar and displacement back analysis[J]. Journal of Highway and Transportation Research and Development, 2022, 18(10):40-48. [10] 涂善波, 郭士明, 耿青松, 等. 郑州市极端暴雨灾后交通工程隐患应急检测分析[J]. 河海大学学报(自然科学版), 2022, 50(3): 9-16. Tu Shanbo, Guo Shiming, Geng Qingsong, et al.Emergency detection analysis of traffic projects' problems after the extreme rainstorm disaster in Zhengzhou City[J]. Journal of Hohai University (Natural Sciences), 2022, 50(3): 9-16. [11] Zaki A, Megat Johari M A, Wan Hussin W M A, et al. Experimental assessment of rebar corrosion in concrete slab using ground penetrating radar (GPR)[J]. International Journal of Corrosion, 2018, 2018: 5389829. [12] Hubbard S, Zhang Jieying, Monteiro P, et al.Experimental detection of reinforcing bar corrosion using nondestructive geophysical techniques[J]. Materials Journal, 2003, 100(6): 501-510. [13] Eisenmann D, Margetan F, Chiou C P T, et al. Ground penetrating radar applied to rebar corrosion inspection[C]//AIP Conference Proceedings, Denver, Colorado, USA, 2013, 1511(1): 1341-1348. [14] Hasan M I, Yazdani N.An experimental study for quantitative estimation of rebar corrosion in concrete using ground penetrating radar[J]. Journal of Engineering, 2016, 2016: 8536850. [15] Sossa V, Pérez-Gracia V, González-Drigo R, et al.Lab non destructive test to analyze the effect of corrosion on ground penetrating radar scans[J]. Remote Sensing, 2019, 11(23): 2814. [16] Hong Shuxian, Chen Dingzhong, Dong Biqin.Numerical simulation and mechanism analysis of GPR-based reinforcement corrosion detection[J]. Construction and Building Materials, 2022, 317: 125913. [17] 吴旭东, 何文勇, 龙万学, 等. 基于探地雷达的路基病害正演模拟及分析[J]. 中外公路, 2020, 40(增刊2): 105-109. Wu Xudong, He Wenyong, Long Wanxue, et al.Forward modeling and analysis of roadbed disease based on ground penetrating radar[J]. Chinese and Foreign Highways, 2020, 40(S2): 105-109. [18] 金文辉. 地铁车辆段杂散电流分析与防护方案[J]. 电气技术, 2023, 24(2): 11-17. Jin Wenhui.Analysis and protection scheme of stray current in subway depot[J]. Electrical Engineering, 2023, 24(2): 11-17. [19] 王淼, 杨晓峰, 李世翔, 等. 城市轨道交通直流自耦变压器牵引供电系统故障保护研究[J]. 电工技术学报, 2022, 37(4): 976-989. Wang Miao, Yang Xiaofeng, Li Shixiang, et al.Fault protection of DC auto-transformer traction power supply system for urban rail transit[J]. Transactions of China Electrotechnical Society, 2022, 37(4): 976-989. [20] 刘炜, 周林杰, 唐宇宁, 等. 直流牵引供电回流系统与杂散电流扩散的联合仿真模型[J]. 电工技术学报, 2023, 38(16): 4421-4432. Liu Wei, Zhou Linjie, Tang Yuning, et al.Co-simulated model of DC traction power supply return system and stray current diffusion[J]. Transactions of China Electrotechnical Society, 2023, 38(16): 4421-4432. [21] 刘炜, 郑杰, 李田, 等. 排流装置对直流牵引供电系统杂散电流分布的影响[J]. 电工技术学报, 2022, 37(18): 4565-4574. Liu Wei, Zheng Jie, Li Tian, et al.The influence of drainage device on stray current distribution in DC traction power supply system[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4565-4574. [22] 顾靖达, 杨晓峰, 郑琼林, 等. 基于不同接地方式与列车工况的负阻变换器牵引供电系统轨道电位与杂散电流[J]. 电工技术学报, 2021, 36(8): 1703-1717. Gu Jingda, Yang Xiaofeng, Zheng Qionglin, et al.Rail potential and stray current on negative resistance converter traction power system under different grounding schemes and train conditions[J]. Transactions of China Electrotechnical Society, 2021, 36(8): 1703-1717. [23] Yee Kane.Numerical solution of initial boundary value problems involving Maxwell's equations in isotropic media[J]. IEEE Transactions on Antennas and Propagation, 1966, 14(3): 302-307. [24] 冯德山, 王珣, 戴前伟. 探地雷达数值模拟及程序实现[M]. 长沙: 中南大学出版社, 2018. [25] 王凤平, 敬和民, 辛春梅. 腐蚀电化学[M]. 2版. 北京: 化学工业出版社, 2017. [26] 万红霞, 宋东东, 陈长风, 等. 杂散电流对碳钢的腐蚀影响研究实验探索与设计[J]. 广州化工, 2020, 48(18): 47-49. Wan Hongxia, Song Dongdong, Chen Changfeng, et al.Experimental exploration and design of stray current effect on carbon steel corrosion[J]. GuangZhou Chemical Industry, 2020, 48(18): 47-49. [27] Berenger J P.A perfectly matched layer for the absorption of electromagnetic waves[J]. Journal of Computational Physics, 1994, 114(2): 185-200. [28] Chen Y H, Chew W C, Oristaglio M L.Application of perfectly matched layers to the transient modeling of subsurface EM problems[J]. Geophysics, 1997, 62(6): 1730-1736.
2024, Vol. 39 
