Abstract：Lithium batteries are widely used in the new energy sector due to their high energy density and low self-discharge rate. As the capacity of each battery unit is different, overcharging and over-discharging greatly affect the battery life. This paper focuses on the safety of series lithium batteries. Firstly, the existing series of lithium battery equalization circuits are summarized, and the advantages and disadvantages of different circuits are analyzed. Regarding the disadvantages of multi-winding transformer-type equalization circuits, this paper proposes a Lithium-ion battery equalization circuit based on a bidirectional half-bridge CLLLC resonant converter. Secondly, the working principle and mode of the bidirectional half-bridge CLLLC resonant converter are explained, and its resonance and gain characteristics are analyzed using fundamental analysis. In addition, a control method for synchronous rectification of the secondary side of the half-bridge CLLLC resonant converter is proposed. Then, for the proposed Lithium-ion battery equalization circuit, the operating principles of its four equalization paths are analyzed, and the equalization current expressions for each path are derived. The parameter design method of the equalization circuit is given according to the analysis of the bidirectional half-bridge CLLLC resonant converter. Based on the four equalization paths of the equalization circuit and the different purposes of dynamic and static equalization, two equalization strategies are proposed. Finally, the relevant hardware parameters of the equalization circuit are designed, and the device selection is carried out. The fabrication method of the magnetic components is also given. A set of equalization circuits for six battery cells is built. The equalization path and the soft circuit switching are verified by simulation and experiment. According to the proposed control strategy, static equalization and dynamic equalization are carried out for six battery cells. The experimental results show that the proposed equalization circuit has the advantages of a flexible equalization path, fast equalization speed, high equalization efficiency, and a half number of windings.
蔡瑞佳, 马运东, 王鹏飞, 王鹏. 基于双向半桥CLLLC谐振变换器的锂电池均衡电路[J]. 电工技术学报, 2024, 39(15): 4868-4882.
Cai Ruijia, Ma Yundong, Wang Pengfei, Wang Peng. Lithium-Ion Battery Equalization Circuit Based on Bidirectional Half-Bridge CLLLC Resonant Converter. Transactions of China Electrotechnical Society, 2024, 39(15): 4868-4882.
[1] Pascual C, Krein P T.Switched capacitor system for automatic series battery equalization[C]//Proceedings of APEC 97-Applied Power Electronics Conference, Atlanta, GA, USA, 2002: 848-854. [2] 刘红锐, 张昭怀. 锂离子电池组充放电均衡器及均衡策略[J]. 电工技术学报, 2015, 30(8): 186-192. Liu Hongrui, Zhang Zhaohuai.The equalizer of charging and discharging and the balancing strategies for lithium-ion battery pack[J]. Transactions of China Electrotechnical Society, 2015, 30(8): 186-192. [3] 李泉, 周云山, 王建德, 等. 基于双层准谐振开关电容的锂电池组均衡方法[J]. 电工技术学报, 2017, 32(21): 9-15. Li Quan, Zhou Yunshan, Wang Jiande, et al.Equalization method of lithium battery pack based on double-tiered quasi-resonant switched capacitor[J]. Transactions of China Electrotechnical Society, 2017, 32(21): 9-15. [4] Lim C, Lee K, Ku N, et al.A modularized equalization method based on magnetizing energy for a series-connected lithium-ion battery string[J]. IEEE Transactions on Power Electronics, 2014: 1791-1799. [5] 刘倩怡, 徐顺刚, 许建平, 等. 一种基于推挽变换器的模块化电池均衡电路[J]. 电工技术学报, 2018, 33(14): 3213-3221. Liu Qianyi, Xu Shungang, Xu Jianping, et al.A modularized equalizer for series-connected batteries based on push-pull converter[J]. Transactions of China Electrotechnical Society, 2018, 33(14): 3213-3221. [6] Shang Yunlong, Xia Bing, Zhang Chenghui, et al.An automatic battery equalizer based on forward and flyback conversion for series-connected battery strings[C]//2017 IEEE Applied Power Electronics Conference and Exposition (APEC), Tampa, FL, USA, 2017: 3218-3222. [7] Peng Faxiang, Wang Haoyu, Wei Zhengqi.An LLC-based highly efficient S2M and C2C hybrid hierarchical battery equalizer[J]. IEEE Transactions on Power Electronics, 2020, 35(6): 5928-5937. [8] Park H S, Kim C E, Kim C H, et al.A modularized charge equalizer for an HEV lithium-ion battery string[J]. IEEE Transactions on Industrial Electronics, 2009, 56(5): 1464-1476. [9] 赵靖英, 胡劲, 张雪辉, 等. 基于锂电池模型和分数阶理论的SOC-SOH联合估计[J]. 电工技术学报, 2023, 38(17): 4551-4563. Zhao Jingying, Hu Jin, Zhang Xuehui, et al.Joint estimation of the SOC-SOH based on lithium battery model and fractional order theory[J]. Transactions of China Electrotechnical Society, 2023, 38(17): 4551-4563. [10] 高凯. 基于Buck-Boost变换器的电池均衡电路研究[D]. 成都: 西南交通大学, 2021. [11] 魏业文, 李应智, 曹斌, 等. 含Buck电路的锂电池低功耗电量均衡技术研究[J]. 电工技术学报, 2018, 33(11): 2575-2583. Wei Yewen, Li Yingzhi, Cao Bin, et al.Research on power equalization of lithium-ion batteries with less-loss Buck chopper[J]. Transactions of China Electrotechnical Society, 2018, 33(11): 2575-2583. [12] Wei Zhengqi, Wang Haoyu, Lu Yiqing, et al.Bidire- ctional constant current S2C battery equalizer based on fixed-frequency L2C3 resonant converter[C]//2022 IEEE Applied Power Electronics Conference and Exposition (APEC), Houston, TX, USA, 2022: 52-57. [13] 廖嘉睿, 杭丽君, 但志敏, 等. 宽范围CLLLC双向同步整流数字控制方法[J]. 电工技术学报, 2022, 37(14): 3632-3642. Liao Jiarui, Hang Lijun, Dan Zhimin, et al.Digital control method of wide-range CLLLC bidirectional synchronous rectification[J]. Transactions of China Electrotechnical Society, 2022, 37(14): 3632-3642. [14] Zhang Zhiliang, Gui Handong, Gu Dongjie, et al.A hierarchical active balancing architecture for lithium- ion batteries[J]. IEEE Transactions on Power Elec- tronics, 2017, 32(4): 2757-2768. [15] 周国华, 王淇, 邓伦博. 宽增益高效率CLLLC变换器的变频双移相调制策略[J]. 电工技术学报, 2024, 39(8): 2511-2522. Zhou Guohua, Wang Qi, Deng Lunbo.Variable- frequency dual-phase-shift modulation strategy for CLLLC converter with wide voltage gain and high efficiency[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2511-2522. [16] Lee Y S, Cheng Mingwang.Intelligent control battery equalization for series connected lithium-ion battery strings[J]. IEEE Transactions on Industrial Elec- tronics, 2005, 52(5): 1297-1307. [17] Zhang Chenghui, Shang Yunlong, Li Zeyuan, et al.An interleaved equalization architecture with self- learning fuzzy logic control for series-connected battery strings[J]. IEEE Transactions on Vehicular Technology, 2017, 66(12): 10923-10934. [18] Mestrallet F, Kerachev L, Crebier J C, et al.Multi- phase interleaved converter for lithium battery active balancing[J]. IEEE Transactions on Power Electronics, 2014, 29(6): 2874-2881. [19] Lim C S, Lee Kuijun, Ku N J, et al.A modularized equalization method based on magnetizing energy for a series-connected lithium-ion battery string[J]. IEEE Transactions on Power Electronics, 2014, 29(4): 1791-1799. [20] Imtiaz A M, Khan F H.Time shared flyback converter based regenerative cell balancing technique for series connected Li-ion battery strings[J]. IEEE Transa- ctions on Power Electronics, 2013, 28(12): 5960-5975. [21] Ugle R, Li Yaoyu, Dhingra A.Equalization integrated online monitoring of health map and worthiness of replacement for battery pack of electric vehicles[J]. Journal of Power Sources, 2013, 223: 293-305. [22] Costinett D, Nguyen H, Zane Regan, et al.GaN-FET based dual active bridge DC-DC converter[C]//2011 Twenty-Sixth Annual IEEE Applied Power Elec- tronics Conference and Exposition (APEC), Fort Worth, TX, USA, 2011: 1425-1432. [23] Huang H.Designing an LLC resonant half-bridge power converter[Z]. TI Literature, 2010. [24] 桂涵东. 锂电池主动均衡管理与效率优化[D]. 南京: 南京航空航天大学, 2016.
2024, Vol. 39 
