电工技术学报  2023, Vol. 38 Issue (17): 4551-4563    DOI: 10.19595/j.cnki.1000-6753.tces.221092
电工理论与新技术 |
基于锂电池模型和分数阶理论的SOC-SOH联合估计
赵靖英1, 胡劲1, 张雪辉1, 张文煜2
1.省部共建电工装备可靠性与智能化国家重点实验室(河北工业大学) 天津 300130;
2.国网冀北张家口风光储输新能源有限公司 张家口 075000
Joint Estimation of the SOC-SOH Based on Lithium Battery Model and Fractional Order Theory
Zhao Jingying1, Hu Jin1, Zhang Xuehui1, Zhang Wenyu2
1. State Key Laboratory for Reliability and Intelligence of Electrical Equipment Hebei University of Technology Tianjin 300130 China;
2. State Grid Hebei Zhangjiakou Scenery Storage and Transportation New Energy Co. Ltd Zhangjiakou 075000 China
全文: PDF (2710 KB)   HTML
输出: BibTeX | EndNote (RIS)      
摘要 基于锂电池荷电状态(SOC)和健康状态(SOH)的耦合关系,设计了SOC-SOH联合估计系统。首先,构建锂电池等效电路模型和自适应扩展卡尔曼滤波(AEKF)算法,进行锂电池SOC估计;其次,建立锂电池分数阶模型,设计模糊控制器辨识分数阶模型参数,基于分数阶模型参数和电池充电工况确立健康因子,引入麻雀搜索算法(SSA)改进反向传播神经网络(BPNN),进行锂电池SOH估计;然后,集成SOC与SOH估计方法,设计联合估计系统;最后,设计锂电池老化实验、动态应力测试(DST)和US06动态实验方案,对比分析不同工况下不同算法的SOC-SOH联合估计效果。结果表明,基于提出的SOC-SOH联合估计方法,估计误差小于1%,具有良好的估计特性。
服务
把本文推荐给朋友
加入我的书架
加入引用管理器
E-mail Alert
RSS
作者相关文章
赵靖英
胡劲
张雪辉
张文煜
关键词 锂电池分数阶模型健康因子荷电状态健康状态    
Abstract:Traditional state of charge (SOC) estimation algorithm of lithium battery is often based on equivalent circuit model, which has low accuracy and too many parameters. And the application of equivalent circuit model in state of health (SOH) estimation is limited because of the disadvantages. In addition, the capacity attenuation of lithium battery is often ignored to result in poor timeliness of SOC estimation. There is a coupling relationship between SOC and SOH of lithium battery. SOC-SOH joint estimation is an effective means during life cycle, but joint estimation model is relatively complex and imperfect, which doesn't support the estimation requirements. This paper presented a joint SOC-SOH estimation model with equivalent circuit model and fractional order theory. By adaptive extended Kalman filter (AEKF) algorithm and capacity parameter modification method, the accuracy and the timeliness of the state estimation were improved.
Firstly, based on the second order RC model of lithium battery, the state equation was established. Considering the time-varying characteristics of noise covariance, dynamic noise covariance parameter was obtained by calculating the cumulative error, and AEKF algorithm was proposed to estimate the SOC of lithium battery. Secondly, aiming at the of excessive parameters in integer order model, the RC series module was simplified by fractional calculus theory to acquire a fractional order model with high precision and few parameters. The parameters were identified by fuzzy controller. Based on the charging conditions and the polarization characteristics of lithium battery, the interval constant current charging time and the fractional-order model parameters were determined as health factors. Thirdly,by use of SSA to optimize BP neural network for the global optimal solution of the weight, nonlinear relationship between health factors and SOH was analyzed to design SOH estimation model. Finally,considering the capacity attenuation of lithium battery and the measurement accuracy of health factors, SOH estimation value was used to modify the capacity parameters and SOC estimation value was used to determine the initial sampling point of health factor to develop a SOC-SOH joint estimation model.
Aging tests, dynamic condition tests of US06 and DST of lithium battery are designed to verify the joint SOC-SOH estimation model. In dynamic tests of US06 and DST, the results show that maximum error of SOC estimation accuracy based on AEKF algorithm and EKF algorithm is less than 1% and more than 3% respectively, which verified the effectiveness of SOC estimation model with AEKF algorithm. In aging tests, the effectiveness of health factors was verified and the influence of accuracy between SOC and SOH estimates was analyzed. The results show that the correlation coefficient between interval constant current charging time and SOH is greater than 0.96, the correlation coefficient between fractional order model parameters and SOH is greater than 0.95, which expressed the strong correlation of the health factors. The maximum errors of SOH estimation based on health factors acquired by AEKF and EKF were less than 1% and more than 2%, respectively, which showed the SOH estimation improvement with health factors acquired by AEKF. By capacity parameter modification, the maximum error of SOC estimation could decrease at less than 1%, while the maximum error of SOC estimation is more than 22% without modification. Meanwhile, with different capacity modification accuracies, the maximum errors of SOC estimation could be ensured to be less than 1.5%, which reduced the estimation errors and improved the timelines with the joint SOC-SOH estimation model.
The following conclusions can be drawn from the analysis: (1) Compared with EKF, the actual dynamic noise covariance is considered in AEKF algorithm proposed. It is more appropriate to establish SOC model to effectively improve SOC estimation accuracy. (2) Fractional order model can better reflect the polarization characteristics of lithium battery. With the health factors extracted based on charging conditions and fractional order model parameters, SOH estimation model established can reduce the estimation error. (3) AEKF algorithm is used to adaptively monitor the charging and discharging state of lithium battery to acquire accurate health factors. SOH estimation value is used to modify capacity parameters instead of fixed capacity parameters because of actual capacity attenuation. The joint estimation model designed is more suitable for the actual change. It has stronger timeliness and robustness.
Key wordsLithium battery    fractional order model    health factor    state of charge    state of health   
收稿日期: 2022-06-10     
PACS: TM912  
基金资助:国家自然科学基金项目(51077097)和天津市科技支撑计划重点项目(10ZCKFGX02800)资助
通讯作者: 赵靖英 女,1974年生,教授,硕士生导师,研究方向为电工装备可靠性理论及应用。E-mail:zhao_team@163.com   
作者简介: 胡 劲 男,1997年生,硕士研究生,研究方向为电工装备可靠性理论及应用。E-mail:Hjin_hebut@163.com
引用本文:   
赵靖英, 胡劲, 张雪辉, 张文煜. 基于锂电池模型和分数阶理论的SOC-SOH联合估计[J]. 电工技术学报, 2023, 38(17): 4551-4563. Zhao Jingying, Hu Jin, Zhang Xuehui, Zhang Wenyu. Joint Estimation of the SOC-SOH Based on Lithium Battery Model and Fractional Order Theory. Transactions of China Electrotechnical Society, 2023, 38(17): 4551-4563.
链接本文:  
https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.221092          https://dgjsxb.ces-transaction.com/CN/Y2023/V38/I17/4551