基于预测算法的自由活塞内燃直线发电机高效控制策略

doi:10.19595/j.cnki.1000-6753.tces.L90412

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1550 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要自由活塞内燃直线发电机具有燃料适应范围广、机械摩擦损耗小、压缩比可调等多种优势。但由于活塞运动轨迹受多重因素影响,运行工况极其复杂,系统输出功率和发电效率难以有效提升。该文以自由活塞内燃直线发电机为研究对象,提出一种基于预测算法的高效控制策略。通过预测算法计算系统预期的瞬时功率,利用空间矢量脉宽调制施加准确的电压矢量,进而减少系统的功率损耗,提高发电效率。相较于传统的直接功率控制,该策略针对自由活塞内燃直线发电机高频时变的发电特性,一方面克服了因脉宽调制开关信号延迟问题导致的效率损失,另一方面减少了因开关频率不固定而产生的噪声和损耗。搭建了基于Matlab/Simulink的控制系统模型,并在自由活塞内燃直线发电机的工况下对两种算法进行仿真对比,结果显示,该策略提升了系统的输出功率和效率,验证了控制策略的先进性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李征
	邱书恒
	陈飞雪
	张驰
	肖世德

关键词 ：自由活塞, 直线发电机, 预测算法, 功率控制

Abstract：The free piston linear generator(FPLG) has many advantages, such as wide fuel range, less mechanical friction loss and adjustable compression ratio. However, due to the influence of multiple factors on the piston trajectory, the operating conditions are extremely complex, so the output power and generation efficiency are difficult to improve. In this paper, an efficient control strategy based on predictive algorithm is proposed for FPLG: Through the prediction algorithm, the expected instantaneous power is calculated, and the accurate voltage vector is applied by SVPWM, so as to reduce the power loss and improve the generation efficiency. Compared with the traditional direct power control, this strategy aims at the high frequency and time-varying generation characteristics of the FPLG. On the one hand, it overcomes the efficiency loss caused by the PWM switch signal delay, on the other hand, it reduces the noise and loss caused by the switch frequency which is not fixed. The control system model based on Matlab / Simulink is built, and the two algorithms are simulated and compared under the real condition of the FPLG. The results show that the proposed strategy improves the output power and efficiency of the system, and verifies the correctness of the proposed strategy.

Key words： Free piston linear generator prediction algorithm power control

收稿日期: 2020-07-09

PACS:

TM314

基金资助:国家重点研发计划（2018YFF01011502）、宁波市国际科技合作计划（2018D10010）、宁波市创新团队（2016B10016）和中科院STS项目（KFJ-STS-ZDTP-066）资助

通讯作者: 张驰男,1978年生,研究员,博士生导师,研究方向为电机及其系统、精密运动控制。E-mail：zhangchi@nimte.ac.cn

作者简介: 李征男,1996年生,硕士研究生,研究方向为内燃直线发电机驱动与控制。E-mail：liz@nimte.ac.cn

引用本文:

李征, 邱书恒, 陈飞雪, 张驰, 肖世德. 基于预测算法的自由活塞内燃直线发电机高效控制策略[J]. 电工技术学报, 2022, 37(zk1): 43-49. Li Zheng, Qiu Shuheng, Chen Feixue, Zhang Chi, Xiao Shide. Efficient Control Strategy Based on Predictive Algorithm for Free Piston Linear Generator. Transactions of China Electrotechnical Society, 2022, 37(zk1): 43-49.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.L90412 https://dgjsxb.ces-transaction.com/CN/Y2022/V37/Izk1/43

[1] Wang Xuezhen, Chen Feixue, Zhu Renfeng, et al.A review of the design and control of free-piston linear generator[J]. Energies, 2018, 11(8): 2179.
[2] Xiao Jin, Li Qingfeng, Huang Zhen.Motion characteristic of a free piston linear engine[J]. Applied Energy, 2010, 87(4): 1288-1294.
[3] Mao Lianlian, Zhang Chi, Gao Yanxia, et al.DC bus voltage control of a free-piston linear generator[C]//IEEE Eleventh International Conference on Ecological Vehicles & Renewable Energies, Monte Carlo, 2016: 1-7.
[4] Lu Yimin, Huang Xianfeng, Zhu Z Q, et al.Direct power control of a permanent magnet linear generator in a free piston energy converter[C]//International Conference on Electrical Machines and Systems, Wuhan, 2008: 3636-3639.
[5] 李昆鹏, 万健如, 朱琳. 永磁同步电机瞬时功率预测控制[J]. 电工技术学报, 2015, 30(1): 38-44.
Li Kunpeng, Wan Jianru, Zhu Lin.Predictive instantaneous power control for permanent magnet synchronous motors[J]. Transactions of China Electrotechnical Society, 2015, 30(1): 38-44.
[6] Bao Guangqing, Wen Jingyi, Wang Xiaolan, et al.Predictive direct power control for permanent magnet linear generator side converter[C]//International Conference on Electrical Machines and Systems, Hangzhou, 2014: 442-446.
[7] Shehata E G.A comparative study of current control schemes for a direct-driven PMSG wind energy generation system[J]. Electric Power Systems Research, 2017, 143: 197-205.
[8] 尚磊, 孙丹, 胡家兵, 等. 三相电压型并网逆变器预测直接功率控制[J]. 电工技术学报, 2011, 26(7): 216-222, 229.
Shang Lei, Sun Dan, Hu Jiabing, et al.Predictive direct power control of three-phase grid-connected voltage-sourced inverters[J]. Transactions of China Electrotechnical Society, 2011, 26(7): 216-222, 229.
[9] Zhang Yongchang, Qu Changqi.Model predictive direct power control of PWM rectifiers under unbalanced network conditions[J]. IEEE Transactions on Industrial Electronics, 2015, 62(7): 4011-4022.
[10] Zhang Chi, Chen Feixue, Li Long, et al.A free-piston linear generator control strategy for improving output power[J]. Energies, 2018, 11(1): 135.
[11] 赵方平, 杨勇, 阮毅, 等. 三相并网逆变器直接功率控制和直接功率预测控制的对比[J]. 电工技术学报, 2012, 27(7): 218-226.
Zhao Fangping, Yang Yong, Ruan Yi, et al.Comparative study for direct power control and direct power predictive control in three-phase grid-connected inverters[J]. Transactions of China Electrotechnical Society, 2012, 27(7): 218-226.
[12] 文景懿. 斯特林直线发电机建模与直接功率控制[D]. 兰州: 兰州理工大学, 2015.
[13] Bouafia A, Gaubert J, Krim F, et al.Predictive direct power control of three-phase pulse width modulation (PWM) rectifier using space-vector modulation (SVM)[J]. IEEE Transactions on Power Electronics, 2010, 25(1): 228-236.
[14] 叶虹志, 姜燕, 黄守道, 等. 电压型PWM整流器无差拍预测直接功率控制[J]. 电工技术学报, 2015, 30(4): 121-128.
Ye Hongzhi, Jiang Yan, Huang Shoudao, et al.Deadbeat predictive direct power control for three-phase voltage source PWM rectifiers[J]. Transactions of China Electrotechnical Society, 2015, 30(4): 121-128.
[15] 李宁, 王跃, 雷万钧, 等. 电力电子变流器中的直接功率控制策略研究综述[J]. 电源学报, 2013, 11(1): 51-58.
Li Ning, Wang Yue, Lei Wanjun, et al.Reviews of direct power control strategy in power electronic converters[J]. Journal of Power Supply, 2013, 11(1): 51-58.
[16] 王久和, 李华德, 王立明. 电压型PWM整流器直接功率控制系统[J]. 中国电机工程学报, 2006, 26(18): 54-60.
Wang Jiuhe, Li Huade, Wang Liming.Direct power control system of voltage source PWM rectifier[J]. Proceedings of the CSEE, 2006, 26(18): 54-60.