基于保角变换与等效磁路法的永磁直驱发电机气隙磁场计算

doi:10.19595/j.cnki.1000-6753.tces.210769

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2705 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要该文开展了负载工况下永磁直驱发电机气隙磁场研究。基于精确域求解和保角变换,计算考虑齿槽效应的气隙磁场标量磁势;采用离散线电流元,定量模拟发电机定转子局部出现的磁饱和现象;基于考虑几何尺寸的定转子非线性磁阻计算方法,建立包含发电机定转子结构以及气隙长度的等效磁路,给出相应的迭代求解流程。以实际在役兆瓦级永磁直驱风力发电机为对象,计算考虑齿槽效应的气隙磁场分布,分析了空载和负载工况下磁饱和效应对气隙磁场分布曲线波形和谐波成分的影响,并与有限元计算结果对比,验证了所提出的分析模型和求解方法的有效性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张志弘
	韩勤锴
	徐学平
	颜益峰
	彭超

关键词 ：永磁直驱发电机, 气隙磁场, 等效磁路, 负载工况, 磁饱和, 齿槽效应, 非线性磁阻

Abstract：Owing to its outstanding advantages such as good low-speed performance, high power generation efficiency, low maintenance cost and reliable operation, megawatt permanent magnet direct drive wind turbine is an ideal choice for large-scale onshore and offshore wind power generation. In the performance analysis and optimal design of permanent magnet direct drive wind turbines, accurate and efficient air gap magnetic field distribution is an important premise.
In this paper, the air gap magnetic field of permanent magnet direct drive generator under load condition is studied. Based on the exact domain solution and conformal mapping, the scalar magnetic potential of the air gap magnetic field considering the cogging effect is calculated. Discrete line current element is used to quantitatively simulate the local magnetic saturation of generator stator and rotor. Based on the calculation method of the nonlinear reluctance of the stator and rotor considering the geometric size, the magnetic equivalent circuit model including the structure of the stator and rotor and the length of the air gap is established, and the corresponding iterative solution process is presented. Taking the actual megawatt permanent magnet direct drive generator in service as an example, the air gap magnetic field distribution considering the cogging effect is calculated, and the influence of magnetic saturation effect on the air gap magnetic field distribution curve waveform and harmonic components under no-load and load conditions is analyzed. The proposed analysis model and solution method are verified by comparing with the finite element results.
Under the no-load condition, the air gap magnetic field intensity is basically unchanged whether the saturation effect is considered or not. The harmonic component includes the fundamental frequency and its odd frequency multiples, and the combination of the tooth slot frequency and the fundamental frequency. Under the load condition, the relative difference between the magnetic field intensity with and without saturation effects can exceed 15%, indicating that the influence of magnetic saturation effect is significantly enhanced and cannot be ignored in the load condition. Compared with the result in the no-load condition, the variation amplitude of the air gap magnetic field intensity increases obviously. The harmonic component is basically the same as that in no-load condition, but the amplitude is higher than that in no-load condition, especially for the increase of the amplitude of fundamental wave frequency.
The analysis model and solution method proposed in this paper provide important preconditions for the magneto-solid coupling analysis and performance optimization design of megawatt permanent magnet direct drive wind turbines.

Key words： Permanent magnet direct drive generator air gap magnetic field magnetic equivalent circuit load condition magnetic saturation cogging effect nonlinear reluctance

收稿日期: 2021-05-27

PACS:

TM351

基金资助:国家自然科学基金资助项目（11872222）

通讯作者: 韩勤锴男,1982年生,博士,副教授,研究方向为旋转机械动力学、永磁直驱电机磁固耦合分析。E-mail：hanqinkai@mail.tsinghua.edu.cn

作者简介: 张志弘男,1982年生,工程师,研究方向为永磁直驱风电机组动力学、发电机磁固耦合分析。E-mail：zhangzhihong@goldwind.com.cn

引用本文:

张志弘, 韩勤锴, 徐学平, 颜益峰, 彭超. 基于保角变换与等效磁路法的永磁直驱发电机气隙磁场计算[J]. 电工技术学报, 2023, 38(3): 703-711. Zhang Zhihong, Han Qinkai, Xu Xueping, Yan Yifeng, Peng Chao. Air Gap Magnetic Field Calculation of Permanent Magnet Direct Drive Generator Based on Conformal Mapping and Magnetic Equivalent Circuit Method. Transactions of China Electrotechnical Society, 2023, 38(3): 703-711.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.210769 https://dgjsxb.ces-transaction.com/CN/Y2023/V38/I3/703

[1] 王凤翔. 永磁电机在风力发电系统中的应用及其发展趋向[J]. 电工技术学报, 2012, 27(3): 12-24.
Wang Fengxiang.Application and development tendency of PM machines in wind power generation system[J]. Transactions of China Electrotechnical Society, 2012, 27(3): 12-24.
[2] 高剑, 黄守道, 张文娟, 等. 基于变流器控制策略的直驱永磁风力发电机优化设计[J]. 电工技术学报, 2013, 28(7): 103-109.
Gao Jian, Huang Shoudao, Zhang Wenjuan, et al.Optimal design for permanent magnet wind power generators based on converter controlling algorithm[J]. Transactions of China Electrotechnical Society, 2013, 28(7): 103-109.
[3] 许水清, 陶松兵, 何怡刚, 等. 基于相电流瞬时频率估计的永磁直驱风电变流器开路故障诊断[J]. 电工技术学报, 2022, 37(2): 433-444.
Xu Shuiqing, Tao Songbing, He Yigang, et al.Open-circuit fault diagnosis for back-to-back converter of PMSG wind generation system based on estimated instantaneous frequency of phase current[J]. Transactions of China Electrotechnical Society, 2022, 37(2): 433-444.
[4] 何山, 王维庆, 张新燕, 等. 基于有限元方法的大型永磁直驱同步风力发电机电磁场计算[J]. 电网技术, 2010, 34(3): 157-161.
He Shan, Wang Weiqing, Zhang Xinyan, et al.Electromagnetic field calculation of high capacity direct-driven permanent magnet synchronous wind power generator based on finite element method[J]. Power System Technology, 2010, 34(3): 157-161.
[5] 唐任远. 现代永磁电机: 理论与设计[M]. 北京: 机械工业出版社, 2016.
[6] 庞古才, 邓智泉, 张忠明. 基于改进广义磁路法的表贴式永磁电机空载气隙磁场解析计算[J]. 电工技术学报, 2019, 34(22): 4623-4633.
Pang Gucai, Deng Zhiquan, Zhang Zhongming.Analytical calculation of no-load air gap magnetic field in surface-mounted permanent magnet motor based on improved generalized magnetic circuit method[J]. Transactions of China Electrotechnical Society, 2019, 34(22): 4623-4633.
[7] 范坚坚, 吴建华. 极间隔断Halbach型磁钢的永磁同步电机气隙磁场解析计算及参数分析[J]. 电工技术学报, 2010, 25(12): 40-47.
Fan Jianjian, Wu Jianhua.Analytical calculation and parameter analysis of air-gap magnetic field distribution in permanent magnet synchronous motor with partition-between-poles Halbach magnet[J]. Transactions of China Electrotechnical Society, 2010, 25(12): 40-47.
[8] 章跃进, 李春江, 屠关镇, 等. 面贴式永磁力矩电机气隙主磁场解析数值分析法[J]. 电工技术学报, 2011, 26(9): 13-17.
Zhang Yuejin, Li Chunjiang, Tu Guanzhen, et al.Analytical method for air-gap main magnetic field computation of surface mounted permanent magnet torque motors[J]. Transactions of China Electrotechnical Society, 2011, 26(9): 13-17.
[9] 李节宝, 井立兵, 周晓燕, 等. 表贴式永磁无刷电机直接解析计算方法[J]. 电工技术学报, 2012, 27(11): 83-88.
Li Jiebao, Jing Libing, Zhou Xiaoyan, et al.Exact analytical method for surface-mounted permanent-magnet brushless motors[J]. Transactions of China Electrotechnical Society, 2012, 27(11): 83-88.
[10] Zarko D, Ban D, Lipo T A.Analytical calculation of magnetic field distribution in the slotted air gap of a surface permanent-magnet motor using complex relative air-gap permeance[J]. IEEE Transactions on Magnetics, 2006, 42(7): 1828-1837.
[11] O'Connell T C, Krein P T. A schwarz-christoffel-based analytical method for electric machine field analysis[J]. IEEE Transactions on Energy Conversion, 2009, 24(3): 565-577.
[12] Alam F R, Abbaszadeh K.Magnetic field analysis in eccentric surface-mounted permanent-magnet motors using an improved conformal mapping method[J]. IEEE Transactions on Energy Conversion, 2016, 31(1): 333-344.
[13] Abbaszadeh K, Alam F R.On-load field component separation in surface-mounted permanent-magnet motors using an improved conformal mapping method[J]. IEEE Transactions on Magnetics, 2016, 52(2): 1-12.
[14] Ostović V.Dynamics of Saturated Electric Machines[M]. New York: Springer, 1989.
[15] Sudhoff S D, Kuhn B T, Corzine K A, et al.Magnetic equivalent circuit modeling of induction motors[J]. IEEE Transactions on Energy Conversion, 2007, 22(2): 259-270.
[16] Lim D K, Yi K P, Woo D K, et al.Analysis and design of a multi-layered and multi-segmented interior permanent magnet motor by using an analytic method[J]. IEEE Transactions on Magnetics, 2014, 50(6): 1-8.
[17] 程明, 文宏辉, 曾煜, 等. 电机气隙磁场调制行为及其转矩分析[J]. 电工技术学报, 2020, 35(5): 921-930.
Cheng Ming, Wen Honghui, Zeng Yu, et al.Analysis of airgap field modulation behavior and torque component in electric machines[J]. Transactions of China Electrotechnical Society, 2020, 35(5): 921-930.
[18] 戈宝军, 毛博, 林鹏, 等. 无刷双馈电机转子偏心对气隙磁场的影响[J]. 电工技术学报, 2020, 35(3): 502-508.
Ge Baojun, Mao Bo, Lin Peng, et al.Effect of rotor eccentricity fault on air gap magnetic field in brushless doubly-fed machine[J]. Transactions of China Electrotechnical Society, 2020, 35(3): 502-508.
[19] 尧磊, 秦雪飞, 蔡顺, 等. 内置式永磁电机转子硅钢片叠装错位对气隙磁场的影响[J]. 电工技术学报, 2021, 36(5): 1096-1100.
Yao Lei, Qin Xuefei, Cai Shun, et al.Influence of rotor lamination stacking misalignment on airgap field in interior permanent magnet motors[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 1096-1100.
[20] 高锋阳, 齐晓东, 李晓峰, 等. 不等宽不等厚Halbach部分分段永磁同步电机电磁性能解析计算与优化分析[J]. 电工技术学报, 2022, 37(6): 1398-1414.
Gao Fengyang, Qi Xiaodong, Li Xiaofeng, et al.Analytical calculation and optimization analysis of electromagnetic performance of Halbach partially-segmented permanent magnet synchronous motors with unequal width and thickness[J]. Transactions of China Electrotechnical Society, 2022, 37(6): 1398-1414.
[21] Hanic A, Zarko D, Hanic Z.A novel method for no-load magnetic field analysis of saturated surface permanent-magnet machines using conformal mapping and magnetic equivalent circuits[J]. IEEE Transactions on Energy Conversion, 2016, 31(2): 740-749.
[22] Hanic A, Zarko D, Kuhinek D, et al.On-load analysis of saturated surface permanent magnet machines using conformal mapping and magnetic equivalent circuits[J]. IEEE Transactions on Energy Conversion, 2018, 33(3): 915-924.
[23] Heida C, Regtien P.Estimation of permeability for magnetic flux leakage modeling[C]//10th IMEKO TC7 International Symposium on Advances of Measurement Science, Saint-Petersburg, 2004: 321-326.