基于电感特殊位置点的开关磁阻电机转子位置检测及误差补偿

doi:10.19595/j.cnki.1000-6753.tces.190041

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (71186 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要针对开关磁阻电机（SRM）电感特殊点无位置控制方法受磁饱和的影响,导致三相电感交点（即特殊点）偏移使位置估计不准确的问题,提出了带有误差补偿的电感特殊点无位置控制方法。该方法针对交点偏移提出了补偿策略,在不同负载转矩下分别测量了电感曲线交点所对应的角度,并采用傅里叶拟合建立了负载转矩与角度的函数关系,进而推算出要补偿的角度误差。在磁饱和的情况下,通过误差补偿来减小交点偏移导致的误差,使位置估计更加准确。为了验证所提算法的有效性和正确性,以一台三相12/8极SRM为控制对象,对新方案和传统方案分别进行了仿真和实验。结果表明,新方案有效地减小了交点偏移导致的误差,使转子位置估计更加准确。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	许爱德
	任萍
	陈加贵
	朱景伟

关键词 ：开关磁阻电机, 无位置控制, 转子位置, 磁饱和

Abstract：In sensorless control of the Switched Reluctance Motor (SRM) based on special position of inductance, inductance intersection point is affected by the magnetic saturation, which will cause inaccurate position estimation. To solve this problem, a control method with error compensation and an improved strategy for intersection offset are proposed. Under different load torques, angles of the intersections of inductance curves are measured. The function relationship between load torque and angle is established by Fourier fitting, then the angle error to be compensated is deduced. In the case of magnetic saturation, the error resulted from intersection offset can be reduced by error compensation to make position estimation more accurate. A three-phase 12/8 pole SRM was designed to verify the proposed method. The simulation and experimental results show that in the case of magnetic saturation, the new method can effectively reduce the error and estimate the rotor position more accurately.

Key words： Switched reluctance motors sensorless control rotor position magnetic saturation

收稿日期: 2019-01-16 出版日期: 2020-04-24

PACS:

TM352

基金资助:国家自然科学基金（51407021）和辽宁省科技创新基金（2018J12GX039）资助项目

通讯作者: 朱景伟男,1963年生,教授,博士生导师,研究方向为电机本体设计及其系统控制。E-mail: zjwdl@dlmu.edu.cn

作者简介: 许爱德女,1974年生,教授,硕士生导师,研究方向为电机统及其控制。E-mail: aidexu@dlmu.edu.cn

引用本文:

许爱德, 任萍, 陈加贵, 朱景伟. 基于电感特殊位置点的开关磁阻电机转子位置检测及误差补偿[J]. 电工技术学报, 2020, 35(8): 1613-1623. Xu Aide, Ren Ping, Chen Jiagui, Zhu Jingwei. Rotor Position Detection and Error Compensation of Switched Reluctance Motor Based on Special Inductance Position. Transactions of China Electrotechnical Society, 2020, 35(8): 1613-1623.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.190041 https://dgjsxb.ces-transaction.com/CN/Y2020/V35/I8/1613

[1] Hu Kaiwei, Chen Yenyang, Liaw Changming.A reversible position sensorless controlled switched- reluctance motor drive with adaptive and intuitive commutation tunings[J]. IEEE Transactions on Power Electronics, 2015, 30(7): 3781-3793.
[2] Song Shoujun, Ge Lefei, Zhang Zhihui.Accurate position estimation of SRM based on optimal interval selection and linear regression analysis[J]. IEEE Transactions on Industrial Electronics, 2016, 63(6): 3467-3478.
[3] Guo Haijiao, Takahashi M, Tadadaaki Watanabe J.A new sensorless drive method of switched reluctance motors based on motor's magnetic characteristics[J]. IEEE Transactions on Magnetics, 2001, 37(4): 2831-2833.
[4] Xu Longya, Wang Chuanyang.Accurate rotor position detection and sensorless control for SRM for super- high speed operation[J]. IEEE Transactions on Power Electronics, 2002, 17(5): 757-763.
[5] 夏长亮, 王明超, 史婷娜, 等. 基于神经网络的开关磁阻电机无位置传感器控制[J]. 中国电机工程学报, 2005, 25(13): 123-128.
Xia Changliang, Wang Mingchao, Shi Tingna, et al.Position sensorless control for switched recluctance motors using neural network[J]. Proceedings of the CESS, 2005, 25(13): 123-128.
[6] Cai Yan, Wang Yu, Xu Hainan, et al.Research on rotor position model for switched reluctance motor using neural network[J]. IEEE/ASME Transactions on Mechatronics, 2018, 23(6): 2762-2773.
[7] 曾辉, 杨向宇. 带位置误差校正的开关磁阻电机电流梯度法[J]. 电机与控制学报, 2019, 23(4): 83-89.
Zeng Hui, Yang Xiangyu.Position sensorless control of switched reluctance motor using wavelet neural networks[J]. Electric Machines and Control, 2019, 23(4): 83-89.
[8] Lyons J P, Macminn S R, Preston M.Flux-current methods for SRM rotor position estimation[C]// Industry Applications Society, Dearborn, MI, USA, 1991: 482-487.
[9] Koblara T, Sorandaru C, Musuroi S, et al.A low voltage sensorless switched reluctance motor drive using flux linkage method[C]//International Con- ference on Optimization of Electrical and Electronic Equipment, Basov, Romania, 2010: 665-672.
[10] 张磊, 刘闯, 韩守义. 基于一种新型磁链模型开关磁阻电机无位置传感器技术[J]. 电机与控制学报, 2018, 22(7): 27-34.
Zhang Lei, Liu Chuang, Hang Shouyi.Sensorless technology of switched reluctance motor based on a new flux model[J]. Electric Machines and Control, 2018, 22(7): 27-34.
[11] 李珍国, 李彩红, 阚志忠, 等. 基于改进型简化磁链法的开关磁阻电机无位置传感器速度控制[J]. 电工技术学报, 2011, 26(6): 62-66.
Li Zhenguo, Li Caihong, Kan Zhizhong, et al.Switched reluctance motor sensorless speed control based on the improved simplified flux method[J]. Transactions of China Electrotechnical Society, 2011, 26(6): 62-66.
[12] 蔡骏, 邓智泉. 基于电感线性区模型的开关磁阻电机无位置传感器技术[J]. 中国电机工程学报, 2012, 32(15): 114-123.
Cai Jun, Deng Zhiquan.Sensorless control of switched reluctance motors based on phase inductance model in linear regions[J]. Proceedings of the CESS, 2012, 32(15): 114-123.
[13] 邵杰, 邓智泉, 胡荣光, 等. 基于改进脉冲注入开关磁阻电机无位置传感器技术[J]. 电工技术学报, 2015, 30(21): 147-153.
Shao Jie, Deng Zhiquan, Hu Rongguang, et al.An improved sensorless driving method of switched reluctance motors using impressed voltage pulse[J]. Transactions of China Electrotechnical Society, 2015, 30(21): 147-153
[14] 李景男, 王旭东, 周永勤. 基于两相脉冲激励的开关磁阻电动机无位置传感器转子位置检测[J]. 电机与控制学报, 2002, 6(1): 6-9.
Li Jingnan, Wang Xudong, Zhou Yongqin.Sensor- less rotor position detection of SRM based on voltage pulses to two phase[J]. Electric Machines and Control, 2002, 6(1): 6-9.
[15] 蔡骏, 邓智泉. 基于全周期电感法的开关磁阻电机无位置传感器控制技术[J]. 电工技术学报, 2013, 28(2): 145-154.
Cai Jun, Deng Zhiquan.Sensorless control of switched reluctance motors based on full-cycle inductance method[J]. Transactions of China Electrotechnical Society, 2013, 28(2): 145-154.
[16] 周竟成, 王晓琳, 邓智泉, 等. 开关磁阻电机的电感分区式无位置传感器技术[J]. 电工技术学报, 2012, 27(7): 34-40.
Zhou Jingcheng, Wang Xiaolin, Deng Zhiquan, et al.The position sensorless technology of switched reluctance motor based on the regional comparison of three-phase inductance[J]. Transactions of China Electrotechnical Society, 2012, 27(7): 34-40.
[17] 刘勇智, 宋金龙, 周政, 等. 改进电感分区式SRM位置传感器研究[J]. 电力电子技术, 2016, 50(7): 66-69.
Liu Yongzhi, Song Jinlong, Zhou Zheng, et al.Sensor- less control of SRM based on improved regional comparison three-phase inductance[J]. Power Elec- tronics, 2016, 50(7): 66-69.
[18] 李孟秋, 陈欣, 任修勇, 等. 基于典型位置电感的开关磁阻电机无位置传感器控制策略[J]. 中国电机工程学报, 2017, 37(13): 3901-3908.
Li Mengqiu, Chen Xin, Ren Xiuyong, et al.Sensor- less control of switched reluctance motors based on typical position of three-phase inductances[J]. Pro- ceedings of the CSEE, 2017, 37(13): 3901-3908.
[19] 蔡辉, 王辉, 李孟秋, 等. 考虑饱和电感特性的开关磁阻电机的无位置传感器控制方法[J]. 电工技术学报, 2018, 33(12): 2723-2734.
Cai Hui, Wang Hui, Li Mengqiu, et al.Position sensorless control of switched reluctance motors con-20 sidering the magnetic saturation[J]. Transactions of China Electrotechnical Society, 2018, 33(12): 2723-2734.