基于迭代算法的功能梯度绝缘子介电常数分布优化

doi:10.19595/j.cnki.1000-6753.tces.191033

摘要
图/表
参考文献
相关文章 (13)

全文: PDF (2864 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要为了改善气体绝缘输电管道绝缘子沿面电场分布,提出一种基于迭代算法的功能梯度绝缘子介电常数分布优化方法,该方法具有策略简单、迭代次数少、效率高等优点。通过对圆台绝缘子和盆式绝缘子的介电常数分布进行优化,得到主要结论如下：圆台绝缘子的沿面电场分布呈现出由高压电极三结合点向地电极递减的趋势。优化后,圆台绝缘子沿面电场强度最大值由2.3 kV/mm降至1.1 kV/mm,下降幅度超过50%。对盆式绝缘子的介电常数分布进行优化时,需要兼顾绝缘子凹面和凸面的沿面电场分布。经过优化的盆式绝缘子的相对介电常数分布在径向坐标上呈现出“中间低,两侧高”的趋势,绝缘子的凹面电场强度最大值下降幅度超过60%。考虑到实际应用中构造连续梯度非常困难,该文提出“等厚梯度”和“等差梯度”两种离散化方案,对最优的连续介电常数分布进行离散化处理。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	梁虎成
	杜伯学
	陈允
	郝留成
	田浩
	李进

关键词 ：气体绝缘输电管道, 电场畸变, 功能梯度绝缘子, 介电常数分布优化, 离散化

Abstract：To improve the electric field (E-field) distribution on insulator surfaces of gas insulated transmission lines, an iterative method is proposed in this paper to optimize the permittivity distribution in functionally graded insulators, which has the advantages of simple strategy, less iteration and high efficiency. Based on the cone-type and the basin-type insulators, some conclusions can be drawn: the E-field strength declines from the HV triple junction to the GND electrode on the cone-type insulator surface. After optimization, the maximum E-field strength of the cone-type insulator is reduced by over 50%, from 2.3 to 1.1 kV/ mm. For the basin-type insulator, the E-field distributions along both convex and concave surfaces must be taken into consideration in the optimization process. The optimum permittivity distribution presents the “U” type to quality, low in the middle and high at each end. The maximum E-field strength on the concave surface of the basin-type insulator is reduced by over 60%. At last, two discretization methods are employed to discretize the optimum permittivity distribution considering that the gradient layer number of insulators is limited in practical application.

Key words： Gas insulated transmission line E-field distortion functionally graded insulator permittivity distribution optimization discretization

收稿日期: 2019-08-13

PACS:

TM211

基金资助:国家自然科学基金（51807136, 51537008）和天津市自然科学基金（18JCQNJC07300）资助项目

通讯作者: 李进,男,1988 年生,博士,副教授,研究方向为大容量电缆与气体绝缘输电管道绝缘设计与缺陷检测。E-mail：lijin@tju.edu.cn

作者简介: 梁虎成,男,1992年生,博士研究生,研究方向为直流气体绝缘输电管道电场调控。E-mail：hcliang@tju.edu.com

引用本文:

梁虎成, 杜伯学, 陈允, 郝留成, 田浩, 李进. 基于迭代算法的功能梯度绝缘子介电常数分布优化[J]. 电工技术学报, 2020, 35(17): 3758-3764. Liang Hucheng, Du Boxue, Chen Yun, Hao Liucheng, Tian Hao, Li Jin. Permittivity Distribution Optimization of Functionally Graded Insulator Based on Iterative Method. Transactions of China Electrotechnical Society, 2020, 35(17): 3758-3764.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.191033 https://dgjsxb.ces-transaction.com/CN/Y2020/V35/I17/3758

[1] 韩智云, 邹亮, 辛喆, 等. 直流GIL绝缘子环氧树脂/碳纳米管复合涂层关键物理性能的分子动力学模拟[J]. 电工技术学报, 2018, 33(20): 4692-4703.
Han Zhiyun, Zou Liang, Xin Zhe, et al.Molecular dynamics simulation of vital physical properties of epoxy/carbon nanotube composite coatings on DC GIL insulators[J]. Transactions of China Electrotechnical Society, 2018, 33(20): 4692-4703.
[2] 张博雅, 张贵新. 直流GIL中固-气界面电荷特性研究综述Ⅰ: 测量技术及积聚机理[J]. 电工技术学报, 2018, 33(20): 7-20.
Zhang Boya, Zhang Guixin.Review of charge accumulation characteristics at gas-solid interface in DC GIL, part I: measurement and mechanisms[J]. Transactions of China Electrotechnical Society, 2018, 33(20): 7-20.
[3] 张连根, 路士杰, 李成榕, 等. GIS中线形和球形金属微粒的运动行为和危害性[J]. 电工技术学报, 2019, 34(20): 4217-4225.
Zhang Liangen, Lu Shijie, Li Chengrong, et al.Motor behavior and hazard of spherical and linear particle in gas insulated switchgear[J]. Transactions of China Electrotechnical Society, 2019, 34(20): 4217-4225.
[4] 程显, 徐晖, 王瑞雪, 等. 等离子体复合薄膜沉积抑制金属微粒启举[J]. 电工技术学报, 2018, 33(20): 30-39.
Cheng Xian, Xu Hui, Wang Ruixue, et al.Composite thin film deposited by plasma to inhibit the lifting of metal particles[J]. Transactions of China Electrotechnical Society, 2018, 33(20): 30-39.
[5] 乔胜亚, 周文俊, 王勇, 等. 典型吸附剂对GIS固体绝缘介质放电特征气体变化规律影响[J]. 电工技术学报, 2018, 33(19): 213-221.
Qiao Shengya, Zhou Wenjun, Wang Yong, et al.Effect of typical adsorbents on gas change characteristics of gas insulated switchgear solid insulation dielectric[J]. Transactions of China Electrotechnical Society, 2018, 33(19): 213-221.
[6] 杜进桥, 张施令, 李乃一, 等. 特高压交流盆式绝缘子电场分布计算及屏蔽罩结构优化[J]. 高电压技术, 2013, 39(12): 3037-3043.
Du Jinqiao, Zhang Shiling, Li Naiyi, et al.Electric field distribution calculation and shielding electrode structure optimization of UHVAC basin-type insulator[J]. High Voltage Engineering, 2013, 39(12): 3037-3043.
[7] Kurimoto M, Kato K, Hanai M, et al.Application of functionally graded material for reducing electric field on electrode and spacer interface[J]. IEEE Transactions on Dielectrics & Electrical Insulation, 2010, 17(1): 256-263.
[8] Kato K, Kurimoto M, Shumiya H, et al.Application of functionally graded material for solid insulator in gaseous insulation system[J]. IEEE Transactions on Dielectrics & Electrical Insulation, 2006, 13(2): 362-372.
[9] 张冠军, 李文栋, 刘哲, 等. 介电功能梯度材料在电气绝缘领域的研究进展[J]. 中国电机工程学报, 2017, 37(14): 4232-4245.
Zhang Guanjun, Li Wendong, Liu Zhe, et al.Research progress on dielectric functionally graded materials for electrical insulation[J]. Proceedings of the CSEE, 2017, 37(14): 4232-4245.
[10] 李信, 刘海昌, 滕元成, 等. 功能梯度材料的研究现状及展望[J]. 材料导报, 2012, 26(增刊1): 370-373.
Li Xin, Liu Haichang, Teng Yuancheng, et al.Research status and future directions on functionally gradient materials[J]. Materials Review, 2012, 26(S1): 370-373.
[11] Li Chuanyang, Lin Chuanjie, Hu Jun, et al.Novel HVDC spacers by adaptively controlling surface charges-part I: charge transport and control strategy[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(4): 1238-1247.
[12] 李进, 张程, 杜伯学, 等. 直流GIL用非线性电导环氧绝缘子电场仿真[J]. 高电压技术, 2019, 45(4): 1056-1063.
Li Jin, Zhang Cheng, Du Boxue, et al.Electrical field simulation of epoxy spacer with nonlinear conductivity for DC GIL[J]. High Voltage Engineering, 2019, 45(4): 1056-1063.
[13] Tu Youping, Chen Geng, Li Chuanyang, et al.±100kV HVDC SF₆/N₂ gas-insulated transmission line[J]. IEEE Transactions on Power Delivery, 2020, 35(2): 735-744.
[14] Okubo H, Shumiya H, Ito M, et al.Optimization techniques on permittivity distribution in permittivity graded solid insulators[C]//Conference Record of the 2006 IEEE International Symposium on Electrical Insulation, Toronto, 2006: 519-522.
[15] 李文栋, 刘哲, 有晓宇, 等. 叠层式介电功能梯度绝缘子的介电常数分布优化[J]. 西安交通大学学报, 2016, 50(10): 19-26.
Li Wendong, Liu Zhe, You Xiaoyu, et al.Permittivity distribution optimization for multi-layer dielectric FGM insulator[J]. Journal of Xi’an Jiaotong University, 2016, 50(10): 19-26.
[16] Liu Zhe, Li Wendong, Wang Yibo, et al.Topology optimization and 3D-printing fabrication feasibility of high voltage FGM insulator[C]//2016 IEEE International Conference on High-Voltage Engineering and Applications (ICHVE), Chengdu, 2016: 1-4.
[17] Qasim S A, Gupta N.Use of particle swarm optimization in the computation of an optimal permittivity distribution in functionally graded material insulators[C]//2015 International Conference on Condition Assessment Techniques in Electrical Systems (CATCON), Bangalore, India, 2015: 184-188.
[18] 孙秋芹, 郭晓和, 张永涛, 等. 基于介电功能梯度材料的盆式绝缘子电场分布优化[J]. 湖南大学学报, 2018, 45(8): 99-106.
Sun Qiuqin, Guo Xiaohe, Zhang Yongtao, et al.Optimization of electric field distribution for spacer based on dielectric functionally graded material[J]. Journal of Hunan University, 2018, 45(8): 99-106.