Abstract：In new energy resource and electric vehicle fields, DC-DC converters are required to have more advantages, such as wide gain range, isolation, and high efficiency. Therefore, a cascaded four-switch Buck- Boost LLC converter with power switch integration is selected by discussing the advantages and disadvantages of various DC-DC converters. The cascaded converter has a four-switch Buck-Boost converter in the pre-stage and a half-bridge LLC resonant converter in the post-stage. Since designing and optimizing the magnetic components of the cascaded converter controlled by variable frequency is difficult, a special full bridge rectifier structure on the transformer’s secondary side is proposed. The cascaded converter with a special full bridge rectifier structure can widen the input voltage range under fixed frequency control and realize the wide gain range, isolation, high efficiency, and parameter optimization. The low-side switching devices of the special full bridge rectifier structure on the transformer’s secondary side are switches. The simultaneous on-time of the low-side switches is called the overlapping turn-on time. The gain of the cascaded converter can be improved by controlling the overlapping turn-on time. Therefore, the gain range can be widened, and the efficiency is optimized under fixed frequency control. The gain of the converter that the parameters are unchanged is increased significantly so that the cascaded converter could be adapted to a wider input voltage range and maintain higher efficiency simultaneously. When the input voltage is less than or equal to the threshold input voltage, the cascaded converter adjusts the overlapping turn-on time to stabilize the output voltage. This mode is called overlapping mode. When the input voltage exceeds the threshold input voltage, the overlapping turn-on time is zero, and the cascaded converter performs pulse width modulation on the input leg on the primary side to stabilize the output voltage. This mode is called rectification mode. Based on the two modes, the phase shift control technique is applied to the two-leg on the primary side of the cascaded converter. The waveform shape of the middle inductor current of the pre-stage four-switch Buck-Boost converter is changed by the phase shift control technique, which can achieve zero voltage switching (ZVS) of switches and zero current switching (ZCS) of diodes. The modal analysis of the cascaded four-switch Buck-Boost LLC converter with fixed frequency control was carried out using the state plane trajectory analysis method, and the input-output expressions and the soft switching conditions of the switches in two modes were derived. In order to verify the correctness of the theoretical analysis, an experimental prototype with 70~280 V input voltage and 240 W/28 V output was designed. The experimental tests included the wide input range, operating mode, phase shift control technique, soft switching, and efficiency of the converter. The peak efficiency was 93.6% in overlapping mode and 94.4% in rectification mode. In addition, it was experimentally verified that both operating modes could achieve soft switching, and there was a large soft switching time margin in the overlapping mode. The cascaded four-switch Buck-Boost LLC converter with a special full bridge rectifier structure on the secondary side had wide gain and high efficiency compared with the same type of converter. The following conclusions can be drawn from the theoretical analysis and experiments. The proposed cascaded converter works under fixed frequency control, solving the difficulty of designing and optimizing the magnetic components controlled by variable frequency. The cascaded converter has a wide gain range and high efficiency, and can realize soft switching of all switches and diodes. In addition, the converter can be designed for more than four times of input voltage multiplier. In future work, the phase shift control technique of the converter will be optimized to make it smoother and simpler.
周国华, 邱森林, 张小兵. 宽增益高效率级联式四开关Buck-Boost LLC变换器[J]. 电工技术学报, 2024, 39(4): 1103-1115.
Zhou Guohua, Qiu Senlin, Zhang Xiaobing. Cascaded Four-Switch Buck-Boost LLC Converter with Wide Gain Range and High Efficiency. Transactions of China Electrotechnical Society, 2024, 39(4): 1103-1115.
[1] Mazumder S K, Burra R K, Huang Rongjun, et al.A universal grid-connected fuel-cell inverter for resi- dential application[J]. IEEE Transactions on Indu- strial Electronics, 2010, 57(10): 3431-3447. [2] 王义军, 左雪. 锂离子电池荷电状态估算方法及其应用场景综述[J]. 电力系统自动化, 2022, 46(14): 193-207. Wang Yijun, Zuo Xue.Review on estimation methods for state of charge of Lithium-ion battery and their application scenarios[J]. Automation of Electric Power Systems, 2022, 46(14): 193-207. [3] 丁超, 李勇, 姜利, 等. 电动汽车直流充电系统LLC谐振变换器软开关电压边界分析[J]. 电工技术学报, 2022, 37(1): 3-11. Ding Chao, Li Yong, Jiang Li, et al.Analysis of soft switching voltage boundary of LLC resonant con- verter for EV DC charging system[J]. Transactions of China Electrotechnical Society, 2022, 37(1): 3-11. [4] 焦健, 郭希铮, 游小杰, 等. LLC谐振变换器的改进型电流解析方法[J]. 电工技术学报, 2021, 36(23): 5002-5013. Jiao Jian, Guo Xizheng, You Xiaojie, et al.An improved current analytical method for LLC resonant converter[J]. Transactions of China Electrotechnical Society, 2021, 36(23): 5002-5013. [5] 童军, 吴伟东, 李发成, 等. 基于GaN器件的高频高效LLC谐振变换器[J]. 电工技术学报, 2021, 36(增刊2): 635-643. Tong Jun, Wu Weidong, Li Facheng, et al.High frequency and high efficiency LLC resonant converter based on GaN device[J]. Transactions of China Electrotechnical Society, 2021, 36(S2): 635-643. [6] 沙德尚, 李斌, 袁文琦, 等. 基于负载自适应的辅助LC网络宽范围零电压开通的输入串联输出并联移相全桥DC-DC变换器[J]. 中国电机工程学报, 2016, 36(13): 3558-3564, 3374. Sha Deshang, Li Bin, Yuan Wenqi, et al.Loads adaptive input-series-output-parallel phase shift full bridge derived DC-DC converters with auxiliary LC networks to achieve wide zero voltage switching range[J]. Proceedings of the CSEE, 2016, 36(13): 3558-3564, 3374. [7] Shi Yong, Gui Xuwei, Xi Ji, et al.Large power hybrid soft switching mode PWM full bridge DC-DC con- verter with minimized turn-on and turn-off switching loss[J]. IEEE Transactions on Power Electronics, 2019, 34(12): 11629-11644. [8] 周国华, 范先焱, 许多, 等. 具有宽范围输入和高效率的改进型LLC谐振变换器[J]. 电机与控制学报, 2020, 24(10): 9-18. Zhou Guohua, Fan Xianyan, Xu Duo, et al.Improved LLC resonant converter with wide range input and high efficiency[J]. Electric Machines and Control, 2020, 24(10): 9-18. [9] 郭兵, 张一鸣, 张加林, 等. 基于直接移相角控制的移相全桥LLC变换器混合控制策略[J]. 电工技术学报, 2018, 33(19): 4583-4593. Guo Bing, Zhang Yiming, Zhang Jialin, et al.Hybrid control strategy of phase-shifted full-bridge LLC converter based on digital direct phase-shift control[J]. Transactions of China Electrotechnical Society, 2018, 33(19): 4583-4593. [10] 李辉, 黄樟坚, 廖兴林, 等. 一种抑制SiC MOSFET桥臂串扰的改进门极驱动设计[J]. 电工技术学报, 2019, 34(2): 275-285. Li Hui, Huang Zhangjian, Liao Xinglin, et al.An improved SiC MOSFET gate driver design for crosstalk suppression in a phase-leg configuration[J]. Transactions of China Electrotechnical Society, 2019, 34(2): 275-285. [11] Kim B C, Park K B, Kim C E, et al.LLC resonant converter with adaptive link-voltage variation for a high- power-density adapter[J]. IEEE Transactions on Power Electronics, 2010, 25(9): 2248-2252. [12] Musavi F, Craciun M, Gautam D S, et al.An LLC resonant DC-DC converter for wide output voltage range battery charging applications[J]. IEEE Transa- ctions on Power Electronics, 2013, 28(12): 5437-5445. [13] Musavi F, Craciun M, Gautam D S, et al.Control strategies for wide output voltage range LLC resonant DC-DC converters in battery chargers[J]. IEEE Transactions on Vehicular Technology, 2014, 63(3): 1117-1125. [14] Kim E S, Yoon K H, Phum S, et al.Operation characteristics of two-stage DC/DC converter for photovoltaic system[C]//Twenty-Seventh Annual IEEE Applied Power Electronics Conference and Expo- sition, Orlando, FL, USA, 2012: 681-685. [15] 孙孝峰, 仇江峰, 栗晓华, 等. 一种具有宽输入电压范围的集成Buck-Boost LLC级联变换器[J]. 中国电机工程学报, 2016, 36(6): 1667-1673. Sun Xiaofeng, Qiu Jiangfeng, Li Xiaohua, et al.An integrated Buck-Boost LLC cascaded converter with wide input voltage range[J]. Proceedings of the CSEE, 2016, 36(6): 1667-1673. [16] Zhao Xiaonan, Zhang Lanhua, Bron R, et al.A high-efficiency hybrid resonant converter with wide- input regulation for photovoltaic applications[J]. IEEE Transactions on Industrial Electronics, 2017, 64(5): 3684-3695. [17] LaBella T, Yu Wensong, Lai J S, et al. A bi- directional-switch-based wide-input range high effici- ency isolated resonant converter for photovoltaic applications[J]. IEEE Transactions on Power Elec- tronics, 2014, 29(7): 3473-3484. [18] Kim J W, Moon G W.A new LLC series resonant converter with a narrow switching frequency variation and reduced conduction losses[J]. IEEE Transactions on Power Electronics, 2014, 29(8): 4278-4287. [19] Liu Qi, Qian Qinsong, Ren Bowen, et al.A two-stage Buck-Boost integrated LLC converter with extended ZVS range and reduced conduction loss for high- frequency and high-efficiency applications[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2021, 9(1): 727-743. [20] Hu Zhiyuan, Liu Yanfei, Sen P C.Cycle-by-cycle average input current sensing method for LLC resonant topologies[C]//IEEE Energy Conversion Congress and Exposition, Denver, CO, USA, 2013: 167-174. [21] Waffler S, Kolar J W.A novel low-loss modulation strategy for high-power bidirectional Buck + Boost converter[J]. IEEE Transactions on Power Electronics, 2009, 24(6): 1589-1599. [22] 孙明波, 马运东, 温海涛. 应用于超宽输入的LLC谐振变换器设计[J]. 电源学报, 2019, 17(1): 1-9. Sun Mingbo, Ma Yundong, Wen Haitao.Design of LLC resonant converter used in ultra-wide input applications[J]. Journal of Power Supply, 2019, 17(1): 1-9.
2024, Vol. 39 
