Abstract：The MMC-H solid-state transformer (SST) uses one high-frequency transformer, greatly reducing the system volume and cost, which is suitable for high to low-voltage conversion scenarios such as distributed energy access and electric vehicle charging stations. However, SST, including MMC-H, typically uses symmetrical square wave modulation to improve transmission power capabilities, leading to the high content of current harmonics. Besides, considering the high voltage level on the MMC side, square wave modulation can make MMC-H experience extremely high dv/dt stress, posing a severe challenge to transformer insulation. Therefore, this paper proposes two asymmetric modulation methods based on MMC topology and studies the current and power variation characteristics of MMC-H SST. Firstly, this paper proposes the sine-square and triangle-square modulation for MMC-H SST. Based on the proposed SST circuit equivalent model, the power and current expressions for MMC-H under the proposed modulation are presented. The variation of transmission current with power is analyzed, and the reasons for the current difference between different modulations are elucidated. Finally, this paper proposes the overall closed-loop control scheme of MMC-H under asymmetric modulation. The control method includes output voltage closed-loop control, MMC high-frequency nearest level modulation method, and MMC submodules voltage balance control. The power characteristic curve and current waveform are verified on Matlab/Simulink. Simulation results show that the average errors of the transmission power model with the proposed two modulations are 2.8% and 3.4%, respectively. A hardware-in-the-loop (HIL) experimental platform based on the FPGA and DSP control board has been constructed. The experiment verifies the voltage, current waveform, current peak, and harmonic content of the system at different transmission power. The average error of the proposed modeling method is 5.71%. In addition, dynamic experiments are conducted on the SST system, and the MMC-H SST still has good dynamic stability and fast response ability at asymmetric modulation. Finally, a comparison is made between the proposed modulation and traditional square wave modulation. Meanwhile, the losses and efficiency of the 1 MW MMC-H SST system are calculated. The following conclusions are drawn from simulation and experimental results. (1) Compared with the traditional square wave modulation, the proposed two modulations reduce the MMC-H system dv/dt stress and current harmonics. (2) The proposed sine-square modulation achieves optimal overall system performance in terms of power variation, current waveform, peak value, and harmonic content. (3) Under steady state and dynamic conditions, the system is stable and consistent with the theoretical waveforms. Therefore, the proposed asymmetric method does not affect the system’s dynamic performance. This paper provides good theoretical support for the optimization and application promotion of the novel MMC-H SST.
潘建宇, 杜翊豪, 林文琦, 陈伟根. 非对称方波调制下模块化多电平固态变压器传输功率建模与特性分析[J]. 电工技术学报, 2024, 39(24): 7793-7806.
Pan Jianyu, Du Yihao, Lin Wenqi, Chen Weigen. Power Modeling and Operation Characteristics of Modular Multilevel Converter-H Solid State Transformer under Asymmetric Square Wave Modulation. Transactions of China Electrotechnical Society, 2024, 39(24): 7793-7806.
[1] 高范强, 李子欣, 李耀华, 等. 面向交直流混合配电应用的10kV-3MV·A四端口电力电子变压器[J]. 电工技术学报, 2021, 36(16): 3331-3341. Gao Fanqiang, Li Zixin, Li Yaohua, et al.10kV-3MV·A four-port power electronic transformer for AC-DC hybrid power distribution applications[J]. Transactions of China Electrotechnical Society, 2021, 36(16): 3331-3341. [2] 胡钰杰, 李子欣, 罗龙, 等. 串联谐振间接矩阵型电力电子变压器高频电流特性分析及开关频率设计[J]. 电工技术学报, 2022, 37(6): 1442-1454. Hu Yujie, Li Zixin, Luo Long, et al.Characteristic analysis of high-frequency-link current of series resonant indirect matrix type power electronics transformer and switching frequency design[J]. Transactions of China Electrotechnical Society, 2022, 37(6): 1442-1454. [3] 陈润田, 李楚杉, 姚文熙, 等. 基于等效励磁电感的SiC串联器件型中压双有源桥变换器的软开关技术[J]. 电工技术学报, 2024, 39(12): 3732-3745. Chen Runtian, Li Chushan, Yao Wenxi, et al.Soft-switching technique for medium voltage dual active bridge converter with series-connected sic devices based on equivalent magnetizing indu-ctance[J]. Transactions of China Electrotechnical Society, 2024, 39(12): 3732-3745. [4] 李福, 邓红雷, 张国驹, 等. 一种中间电容谐振型级联双向DC-DC变换器[J]. 电工技术学报, 2022, 37(20): 5253-5266. Li Fu, Deng Honglei, Zhang Guoju, et al.A cascaded bidirectional DC-DC converter with intermediate capacitor resonance[J]. Transactions of China Elec-trotechnical Society, 2022, 37(20): 5253-5266. [5] Shi Yuxiang, Li Hui.Isolated modular multilevel DC-DC converter with DC fault current control capability based on current-fed dual active bridge for MVDC application[J]. IEEE Transactions on Power Electronics, 2018, 33(3): 2145-2161. [6] 郑通, 王奎, 郑泽东, 等. 基于MMC拓扑的电力电子变压器研究综述[J]. 中国电机工程学报, 2022, 42(15): 5630-5648, 21. Zheng Tong, Wang Kui, Zheng Zedong, et al.Review of power electronic transformers based on modular multilevel converters[J]. Proceedings of the CSEE, 2022, 42(15): 5630-5648, 21. [7] Pan Jianyu, Ke Ziwei, Al Sabbagh M, et al.7-kV 1-MVA SiC-based modular multilevel converter prototype for medium-voltage electric machine drives[J]. IEEE Transactions on Power Electronics, 2020, 35(10): 10137-10149. [8] Kenzelmann S, Rufer A, Vasiladiotis M, et al.A versatile DC-DC converter for energy collection and distribution using the modular multilevel con-verter[C]//Proceedings of the 2011 14th European Conference on Power Electronics and Applications, Birmingham, UK, 2011: 1-10. [9] Zhao Biao, Song Qiang, Li Jianguo, et al.High-frequency-link modulation methodology of DC-DC transformer based on modular multilevel converter for HVDC application: comprehensive analysis and experimental verification[J]. IEEE Transactions on Power Electronics, 2017, 32(5): 3413-3424. [10] Zhao Biao, Song Qiang, Li Jianguo, et al.Modular multilevel high-frequency-link DC transformer based on dual active phase-shift principle for medium-voltage DC power distribution application[J]. IEEE Transactions on Power Electronics, 2017, 32(3): 1779-1791. [11] Sun Changjiang, Zhang Jianwen, Cai Xu, et al.Voltage balancing control of isolated modular multilevel DC-DC converter for use in DC grids with zero voltage switching[J]. IET Power Electronics, 2016, 9(2): 270-280. [12] Sun Changjiang, Zhang Jianwen, Cai Xu, et al.Analysis and arm voltage control of isolated modular multilevel DC-DC converter with asymmetric branch impedance[J]. IEEE Transactions on Power Elec-tronics, 2017, 32(8): 5978-5990. [13] Zhang Lei, Zhao Zhe, Qin Jiangchao.Efficiency optimization design of DC-DC solid state transformer based on modular multilevel converters[C]//2017 IEEE Energy Conversion Congress and Exposition (ECCE), Cincinnati, OH, USA, 2017: 3508-3513. [14] Zhang Lei, Qin Jiangchao, Duan Qing, et al.Component sizing and voltage balancing of MMC-based solid-state transformers under various AC-link excitation voltage waveforms[C]//2019 IEEE Applied Power Electronics Conference and Exposition (APEC), Anaheim, CA, USA, 2019: 371-375. [15] Zhang Lei, Qin Jiangchao, Zou Yuntao, et al.Analysis of capacitor charging characteristics and low-frequency ripple mitigation by two new voltage-balancing strategies for MMC-based solid-state transformers[J]. IEEE Transactions on Power Elec-tronics, 2021, 36(1): 1004-1017. [16] 王朝辉, 王天威, 张军明. 模块化多电平直流变压器研究[J]. 中国电机工程学报, 2016, 36(1): 31-39. Wang Chaohui, Wang Tianwei, Zhang Junming.Research on modular multilevel DC transformer[J]. Proceedings of the CSEE, 2016, 36(1): 31-39. [17] Zhang Junming, Wang Zhaohui, Shao Shuai.A three-phase modular multilevel DC-DC converter for power electronic transformer applications[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2017, 5(1): 140-150. [18] Shao Shuai, Jiang Mingming, Zhang Junming, et al.A capacitor voltage balancing method for a modular multilevel DC transformer for DC distribution system[J]. IEEE Transactions on Power Electronics, 2018, 33(4): 3002-3011. [19] Mo Ran, Li Hui, Shi Yanjun.A phase-shifted square wave modulation (PS-SWM) for modular multilevel converter (MMC) and DC transformer for medium voltage applications[J]. IEEE Transactions on Power Electronics, 2019, 34(7): 6004-6008. [20] Xing Diang, Li Xiao, Zhang Yue, et al.MMC-based high gain solid-state transformers for energy storage applications[C]//2021 IEEE Applied Power Elec-tronics Conference and Exposition (APEC), Phoenix, AZ, USA, 2021: 1996-2002. [21] 王新颖, 汤广福, 陈宇, 等. 一种模块化多电平DC/DC变换器的基频调制策略[J]. 中国电机工程学报, 2016, 36(7): 1987-1998. Wang Xinying, Tang Guangfu, Chen Yu, et al.A fundamental frequency modulation for module multilevel DC/DC converters[J]. Proceedings of the CSEE, 2016, 36(7): 1987-1998. [22] Chen Yu, Cui Yuqing, Tao Yupu, et al.High-fundamental-frequency modulation for the DC-DC modular multilevel converter (MMC) with low switching frequency and predicted-based voltage balance strategy[C]//2014 IEEE Conference and Expo Transportation Electrification Asia-Pacific (ITEC Asia-Pacific), Beijing, China, 2014: 1-6. [23] Zhao Biao, Yu Qingguang, Sun Weixin.Extended-phase-shift control of isolated bidirectional DC-DC converter for power distribution in microgrid[J]. IEEE Transactions on Power Electronics, 2012, 27(11): 4667-4680. [24] 管州, 梅军, 丁然, 等. 基于拓展移相控制的直流配电网模块化多电平直流变压器[J]. 电工技术学报, 2019, 34(13): 2770-2781. Guan Zhou, Mei Jun, Ding Ran, et al.Modular multilevel DC transformer for DC distribution application based on extended phase-shift control[J]. Transactions of China Electrotechnical Society, 2019, 34(13): 2770-2781. [25] 孙凯, 卢世蕾, 易哲嫄, 等. 面向电力电子变压器应用的大容量高频变压器技术综述[J]. 中国电机工程学报, 2021, 41(24): 8531-8545, 24. Sun Kai, Lu Shilei, Yi Zheyuan, et al.A review of high-power high-frequency transformer technology for power electronic transformer applications[J]. Pro-ceedings of the CSEE, 2021, 41(24): 8531-8545, 24. [26] Zhang Juanjuan, Du Yumei, Li Zixin, et al.Design of a medium frequency, high voltage transformer for power electronic transformer[C]//2014 IEEE Con-ference and Expo Transportation Electrification Asia-Pacific (ITEC Asia-Pacific), Beijing, China, 2014: 1-5.
2024, Vol. 39 
