Abstract：A two-level dual active bridge (DAB) converter cannot reach high efficiency in wide voltage transmission range occasions. Therefore, a multilevel structure is applied to DAB to optimize converter efficiency and reduce the voltage stress of power switching. A tracking control strategy for minimum inductance current RMS value based on three-level extended phase shift (3-EPS) control is proposed when a large mismatch exists between input and output voltages. Firstly, the relationship between the phase-shift ratios D0=f0(D2) and D1=f1(D2) at several optimal extreme points in different power regions is obtained by the Lagrange multiplier method. Different extreme points can achieve different power ranges. The inductance current RMS value of each optimal extreme point is compared in the power overlap range, and the global optimum extreme points in different power ranges are obtained. Secondly, the optimal boundary points are analyzed and compared with global optimum extreme points. Because the inductance current RMS values of global optimum extreme points are always smaller than those of boundary points in each power range, the global optimum extreme points are the final global optimal operating points. Finally, the positive PI controller or negative PI controller is chosen based on the partial derivative polarity of the power to D2 to track the global optimal operating points. Besides, based on the switching point current, the zero-voltage switch (ZVS) of most switches can be realized under ideal conditions. However, the ZVS range is compressed, considering that the inductance energy is enough to discharge the parasitic capacitance fully. Experimental results show that when voltage transmission ratio k equals 1.6 or 2.6, the efficiency of optimal 3-EPS control is higher than optimal two-level extended phase shift (2-EPS) control and single phase shift (SPS) control in low to medium power range. However, the efficiencies of the above three controls are very close when the per unit power reaches 0.8. When per unit power equals 0.5 and k is between 1.1 and 1.2, the advantage of 3-EPS is not apparent. When k is between 1.2 and 2, the advantage is evident again. Compared with 2-EPS, when k is larger than 2, the effect of 3-EPS decreases as k increases. When k equals 4, the efficiencies of 3-EPS and 2-EPS are very close. The efficiency of the minimum inductance current RMS value tracking control strategy is higher than the peak current optimal control. The following conclusions can be drawn from analysis and experiment results. (1) The optimal control strategy proposed achieves lower inductance current RMS value under a wide input voltage range, and the efficiency is higher than 90% in most power ranges. (2) When k is kept unchanged, compared with 2-EPS and SPS, the effect of 3-EPS decreases as the unitary power increases. (3) When power is kept unchanged, the effect of 3-EPS is not apparent if k is larger than 1 but close to 1 because the mismatch between input and output voltages is minor. When k is between 1 and 2 and away from 1, the effect of 3-EPS is obvious. (4) When k is larger than 2, compared with 2-EPS, the effect of 3-EPS decreases as k increases. When k reaches 4, the effect of 3-EPS is almost vanished.
邓丹阳, 陈艳慧. 双有源桥直流变换器三电平扩展移相控制下电感电流有效值最优跟踪控制策略[J]. 电工技术学报, 2024, 39(18): 5800-5815.
Deng Danyang, Chen Yanhui. Optimal Tracking Control Strategy of Inductive Current RMS for Dual-Active Bridge DC Converter with Three-Level Extended Phase-Shift Control. Transactions of China Electrotechnical Society, 2024, 39(18): 5800-5815.
[1] Esteban F D, Serra F M, De Angelo C H. Control of a DC-DC dual active bridge converter in DC microgrids applications[J]. IEEE Latin America Transactions, 2021, 19(8): 1261-1269. [2] 王攀攀, 徐泽涵, 王莉, 等. 基于三重移相的双有源桥DC-DC变换器效率与动态性能混合优化控制策略[J]. 电工技术学报, 2022, 37(18): 4720-4731. Wang Panpan, Xu Zehan, Wang Li, et al.A hybrid optimization control strategy of efficiency and dynamic performance of dual-active-bridge DC-DC converter based on triple-phase-shift[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4720-4731. [3] 樊启高, 卢禹卓, 毕恺韬, 等. 基于倍频采样的两相交错并联三电平双向直流变换器功率均衡解耦控制策略[J]. 电工技术学报, 2022, 37(14): 3654-3664. Fan Qigao, Lu Yuzhuo, Bi Kaitao, et al.Decoupled power-balancing control strategy for two-phase interleaved parallel bidirectional DC converter based on frequency-doubling sampling[J]. Transactions of China Electrotechnical Society, 2022, 37(14): 3654-3664. [4] 李林柘, 邹旻洋, 吴京驰, 等. 基于周期组合序列调制的三电平双有源桥均压策略[J]. 电工技术学报, 2024, 39(2): 514-524. Li Linzhe, Zou Minyang, Wu Jingchi, et al.The voltage balance scheme of three level-dual active bridge based on cycle combination sequence modulation[J]. Transactions of China Electrotechnical Society, 2024, 39(2): 514-524. [5] 蔡逢煌, 石安邦, 江加辉, 等. 结合电流应力优化与虚拟电压补偿的双有源桥DC-DC变换器三重移相优化控制[J]. 电工技术学报, 2022, 37(10): 2559-2571. Cai Fenghuang, Shi Anbang, Jiang Jiahui, et al.Triple-phase-shift optimal control of dual-active- bridge DC-DC converter with current stress optimization and virtual voltage compensation[J]. Transactions of China Electrotechnical Society, 2022, 37(10): 2559-2571. [6] Zhao Biao, Song Qiang, Li Jianguo, et al.Full- process operation, control, and experiments of modular high-frequency-link DC transformer based on dual active bridge for flexible MVDC distribution: a practical tutorial[J]. IEEE Transactions on Power Electronics, 2016, 32(9): 6751-6766. [7] 竺庆茸. 双有源桥DC-DC的调制方式的研究[J]. 电气技术, 2020, 21(7): 53-56, 68. Zhu Qingrong.A study of dual active bridge DC-DC modulation mode[J]. Electrical Engineering, 2020, 21(7): 53-56, 68. [8] 胡钰杰, 李子欣, 赵聪, 等. 基于MOSFET的串联谐振双有源桥死区振荡机理分析及抑制[J]. 电工技术学报, 2022, 37(10): 2549-2558. Hu Yujie, Li Zixin, Zhao Cong, et al.Mechanism analysis and suppression of oscillation in dead time of series resonant dual active bridge based on MOSFET[J]. Transactions of China Electrotechnical Society, 2022, 37(10): 2549-2558. [9] 汪涛, 骆仁松, 张茂强, 等. 考虑死区效应的双有源桥直流变压器损耗优化[J]. 电力系统自动化, 2023, 47(6): 197-205. Wang Tao, Luo Rensong, Zhang Maoqiang, et al.Loss optimization of DC transformer based on dual active bridge considering dead-zone effect[J]. Auto- mation of Electric Power Systems, 2023, 47(6): 197-205. [10] 杨向真, 王锦秀, 孔令浩, 等. 电压不匹配运行条件下双有源桥变换器的效率优化方法[J]. 电工技术学报, 2022, 37(24): 6239-6251. Yang Xiangzhen, Wang Jinxiu, Kong Linghao, et al.Efficiency optimization method of DAB converters under wide-voltage operating conditions[J]. Transa- ctions of China Electrotechnical Society, 2022, 37(24): 6239-6251. [11] 吴春华, 陈修淋, 李智华, 等. 全移相双有源全桥直流变换器的瞬态电流偏置抑制策略[J]. 电工技术学报, 2024, 39(4): 1116-1131. Wu Chunhua, Chen Xiulin, Li Zhihua, et al.Transient current bias suppression strategy of full phase shifting dual active full bridge DC converter[J]. Transactions of China Electrotechnical Society, 2024, 39(4): 1116-1131. [12] 刘子薇, 孙兆龙, 刘宝龙, 等. 基于直接功率控制的双有源桥暂态直流偏置抑制策略[J]. 电工技术学报, 2023, 38(12): 3234-3247 Liu Ziwei, Sun Zhaolong, Liu Baolong, et al.Transient DC bias suppression strategy of dual active bridge based on direct power control[J]. Transactions of China Electrotechnical Society, 2023, 38(12): 3234-3247. [13] Jin Li, Duan Shanxu.Optimised phase shift control to minimise current stress of three-level dual active bridge DC-DC converter[J]. IET Power Electronics, 2018, 11(15): 2427-2433. [14] Wang Yi, Wen Huiqing, Zhu Yinxiao, et al.Minimum-current-stress scheme of three-level dual- active-bridge DC-DC converters with the particle swarm optimization[J]. IEEE Transactions on Trans- portation Electrification, 2021, 7(4): 2067-2084. [15] 金莉, 刘邦银, 段善旭. 三电平双有源全桥DC-DC变换器回流功率最小的移相控制[J]. 电工技术学报, 2018, 33(24): 5864-5873. Jin Li, Liu Bangyin, Duan Shanxu.Minimum reflux power strategy of three-level dual active bridge DC- DC converter with phase shift control[J]. Transactions of China Electrotechnical Society, 2018, 33(24): 5864-5873. [16] Jin Li, Liu Bangyin, Duan Shanxu.ZVS soft switching operation range analysis of three-level dual-active bridge DC-DC converter under phase shift control strategy[J]. IEEE Transactions on Industry Applications, 2019, 55(2): 1963-1972. [17] Liu Peng, Chen Changsong, Duan Shanxu, et al.Dual phase-shifted modulation strategy for the three-level dual active bridge DC-DC converter[J]. IEEE Transactions on Industrial Electronics, 2017, 64(10): 7819-7830. [18] Guo Zhiqiang, Sun Kai.Three-level bidirectional DC-DC converter with an auxiliary inductor in adaptive working mode for full-operation zero- voltage switching[J]. IEEE Transactions on Power Electronics, 2018, 33(10): 8537-8552. [19] 高娜, 张宇, 关清心, 等. 基于有源中点钳位五电平电路的双有源桥DC/DC变换器[J]. 中国电机工程学报, 2023, 43(5): 1950-1961. Gao Na, Zhang Yu, Guan Qingxin, et al.Five-level active neutral point clamed dual active bridge DC/DC converter[J]. Proceedings of the CSEE, 2023, 43(5): 1950-1961. [20] Liu Peng, Chen Changsong, Duan Shanxu.An optimized modulation strategy for the three-level DAB converter with five control degrees of freedom[J]. IEEE Transactions on Industrial Elec- tronics, 2020,67(1): 254-264. [21] 刘朋, 陈昌松, 段善旭. 带飞跨电容的三电平全桥直流变换器输入中点电压的自平衡分析[J]. 电工技术学报, 2018, 33(18): 4335-4344. Liu Peng, Chen Changsong, Duan Shanxu.Self- balance mechanism analysis of the neutral point voltage in three-level full bridge DC-DC converter with flying capacitors[J]. Transactions of China Electrotechnical Society, 2018, 33(18): 4335-4344. [22] Song Chaochao, Sangwongwanich A, Yang Yongheng, et al.Capacitor voltage balancing control scheme for 2/3-level DAB converters[C]//IECON 2021-47th Annual Conference of the IEEE Industrial Electronics Society, Toronto, ON, Canada, 2021: 1-6. [23] Filba-Martinez A, Busquets-Monge S, Bordonau J.Modulation and capacitor voltage balancing control of multilevel NPC dual active bridge DC-DC con- verters[J]. IEEE Transactions on Industrial Elec- tronics, 2020, 67(4): 2499-2510. [24] Filbà-Martínez A, Busquets-Monge S, Bordonau J.Modulation and capacitor voltage balancing control of a three-level NPC dual-active-bridge DC-DC con- verter[C]//IECON 2013-39th Annual Conference of the IEEE Industrial Electronics Society, Vienna, Austria, 2014: 6251-6256.
2024, Vol. 39 
