Abstract：With the development of renewable energy power generation, electrified transportation, and energy storage systems, the power system is entering a new stage of coordinated and optimized operation of source-grid-load-storage. The energy router based on power electronic devices can flexibly access and efficiently use various renewable energy sources, which has become the core equipment of the new power grid. The dual active full-bridge (DAB) DC-DC converter has the advantages of high power density, bidirectional energy transmission, natural electrical isolation, and easy realization of soft switching. Therefore, it has gradually become one of the important topologies on the DC side of energy routers. In the new power grid, the increased integration of renewable energy sources presents challenges of complex operating conditions in power systems and frequent switching of various energy storage equipment. Therefore, energy routers must have good dynamic performance. The traditional PI control employed in DAB converter systems tends to prolong dynamic performance due to the limitation of the equivalent low-pass filtering characteristics of the controller, which has become a bottleneck for the dynamic improvement of the DAB converter. This paper proposes a whole process model predictive control strategy. Firstly, the prediction model of the DAB converter is established. For the start-up process of the DAB converter, the dynamic performance optimization problem, formulated as an equality constraint optimization problem, is solved by KKT conditions. For the transient process of the DAB converter, the optimal phase shift ratio is determined based on the mathematical analysis of the cost function. The above whole process model predictive control strategy can effectively improve the dynamic performance of the DAB converter system. However, when applying the MPC to the DAB converter system, the high requirements on model parameters and sampling accuracy need to be considered. Therefore, a current sensorless robust control strategy based on the Kalman filter algorithm is proposed. The DAB converter system’s discrete state space model and state estimation model are established. The system state variables are reconstructed, and the observation coefficients are improved to linearize the system. The optimal estimation value is obtained according to the Kalman filter principle, and the sensorless robust predictive control is realized. In summary, this paper proposes a whole process model predictive control strategy for the DAB converter system, providing a detailed analysis of model parameter sensitivity and sampling accuracy under the MPC strategy. A current sensorless robust predictive control strategy based on the Kalman filter is proposed. The theoretical analysis and experimental verification of the proposed method reveal the following advantages. (1) Compared with the classical two-stage start-up strategy and PI control strategy, the proposed full-process model predictive control strategy greatly improves the dynamic performance of the DAB converter system during start-up speed and transient processes. (2) The proposed current-sensorless robust predictive control strategy can maintain good dynamic performance without a current sensor, overcoming the parameter dependence of the MPC strategy. The proposed control strategy is robust to model parameter error and sampling noise.
孙孝哲, 张祯滨, 韩明昊, 李真, 刘晓哲. 双有源全桥变换器无电流传感器鲁棒预测控制[J]. 电工技术学报, 2024, 39(10): 3093-3104.
Sun Xiaozhe, Zhang Zhenbin, Han Minghao, Li Zhen, Liu Xiaozhe. An Enhanced Current Sensorless Predictive Control for Dual Active Bridge Converter. Transactions of China Electrotechnical Society, 2024, 39(10): 3093-3104.
[1] 安峰, 杨柯欣, 王嵩, 等. 基于模型前馈的双有源全桥DC-DC变换器电流应力优化方法[J]. 电工技术学报, 2019, 34(14): 2946-2956. An Feng, Yang Kexin, Wang Song, et al.Current stress optimized scheme with model-based feed- forward for dual-active-bridge DC-DC converters[J]. Transactions of China Electrotechnical Society, 2019, 34(14): 2946-2956. [2] 涂春鸣, 孟阳, 肖凡, 等. 一种交直流混合微网能量路由器及其运行模态分析[J]. 电工技术学报, 2017, 32(22): 176-188. Tu Chunming, Meng Yang, Xiao Fan, et al.An AC- DC hybrid microgrid energy router and operational modal analysis[J]. Transactions of China Electro- technical Society, 2017, 32(22): 176-188. [3] 王攀攀, 徐泽涵, 王莉, 等. 基于三重移相的双有源桥DC-DC变换器效率与动态性能混合优化控制策略[J]. 电工技术学报, 2022, 37(18): 4720-4731. Wang Panpan, Xu Zehan, Wang Li, et al.A hybrid optimization control strategy of efficiency and dynamic performance of dual-active-bridge DC-DC converter based on triple-phase-shift[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4720-4731. [4] 杨向真, 王锦秀, 孔令浩, 等. 电压不匹配运行条件下双有源桥变换器的效率优化方法[J]. 电工技术学报, 2022, 37(24): 6239-6251. Yang Xiangzhen, Wang Jinxiu, Kong Linghao, et al.Efficiency optimization method of DAB converters under wide-voltage operating conditions[J]. Transa- ctions of China Electrotechnical Society, 2022, 37(24): 6239-6251. [5] 高宇, 李若愚, 李林柘, 等. 三重移相调制模式下双有源变换器的直接功率控制[J]. 电工技术学报, 2022, 37(18): 4707-4719. Gao Yu, Li Ruoyu, Li Linzhe, et al.Triple phase shift modulation-based direct power control strategy for a dual active bridge converter[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4707-4719. [6] De Doncker R W A A, Divan D M, Kheraluwala M H. A three-phase soft-switched high-power-density DC/ DC converter for high-power applications[J]. IEEE Transactions on Industry Applications, 1991, 27(1): 63-73. [7] Zhao Biao, Song Qiang, Liu Wenhua.Power characte- rization of isolated bidirectional dual-active-bridge DC-DC converter with dual-phase-shift control[J]. IEEE Transactions on Power Electronics, 2012, 27(9): 4172-4176. [8] Tan N M L, Abe T, Akagi H. Design and performance of a bidirectional isolated DC-DC converter for a battery energy storage system[J]. IEEE Transactions on Power Electronics, 2012, 27(3): 1237-1248. [9] Inoue S, Akagi H.A bidirectional DC-DC converter for an energy storage system with galvanic iso- lation[J]. IEEE Transactions on Power Electronics, 2007, 22(6): 2299-2306. [10] Shi Yuxiang, Li Rui, Xue Yaosuo, et al.Optimized operation of current-fed dual active bridge DC-DC converter for PV applications[J]. IEEE Transactions on Industrial Electronics, 2015, 62(11): 6986-6995. [11] 冯高辉, 赵争鸣, 袁立强. 基于能量平衡的电能路由器综合控制技术[J]. 电工技术学报, 2017, 32(14): 34-44. Feng Gaohui, Zhao Zhengming, Yuan Liqiang.Synthetical control technology of electric energy router based on energy balance relationship[J]. Transactions of China Electrotechnical Society, 2017, 32(14): 34-44. [12] 兰征, 涂春鸣, 肖凡, 等. 电力电子变压器对交直流混合微网功率控制的研究[J]. 电工技术学报, 2015, 30(23): 50-57. Lan Zheng, Tu Chunming, Xiao Fan, et al.The power control of power electronic transformer in hybrid AC-DC microgrid[J]. Transactions of China Electro- technical Society, 2015, 30(23): 50-57. [13] Segaran D, Holmes D G, McGrath B P. Enhanced load step response for a bidirectional DC-DC converter[J]. IEEE Transactions on Power Electronics, 2013, 28(1): 371-379. [14] 侯聂, 宋文胜, 武明义. 双向全桥DC-DC变换器的负载电流前馈控制方法[J]. 中国电机工程学报, 2016, 36(9): 2478-2485. Hou Nie, Song Wensheng, Wu Mingyi.A load current feedforward control scheme of dual active bridge DC/DC converters[J]. Proceedings of the CSEE, 2016, 36(9): 2478-2485. [15] Demetriades G D, Nee H P.Dynamic modeling of the dual-active bridge topology for high-power appli- cations[C]//2008 IEEE Power Electronics Specialists Conference, Rhodes, Greece, 2008: 457-464. [16] Dinh N D, Fujita G.Design of a reduced-order observer for sensorless control of dual-active-bridge converter[C]//2018 International Power Electronics Conference (IPEC-Niigata 2018-ECCE Asia), Niigata, Japan, 2018: 363-369. [17] Zheng Changming, Dragičević T, Blaabjerg F.Current-sensorless finite-set model predictive control for LC-filtered voltage source inverters[J]. IEEE Transactions on Power Electronics, 2020, 35(1): 1086-1095. [18] Ge Junjie, Zhao Zhengming, Yuan Liqiang, et al.Energy feed-forward and direct feed-forward control for solid-state transformer[J]. IEEE Transactions on Power Electronics, 2015, 30(8): 4042-4047. [19] Xiong Fei, Wu Junyong, Liu Zicheng, et al.Current sensorless control for dual active bridge DC-DC converter with estimated load-current feedforward[J]. IEEE Transactions on Power Electronics, 2018, 33(4): 3552-3566. [20] 曾进辉, 孙志峰, 雷敏, 等. 独立输入并联输出双有源全桥DC-DC变换器无电流传感器均流控制[J]. 中国电机工程学报, 2019, 39(7): 2144-2155. Zeng Jinhui, Sun Zhifeng, Lei Min, et al.Sensorless current sharing control strategy of independent-input- parallel-output dual-active-bridge converters[J]. Pro- ceedings of the CSEE, 2019, 39(7): 2144-2155. [21] Liu Xiaohu, Li Hui, Wang Zhan.A start-up scheme for a three-stage solid-state transformer with mini- mized transformer current response[J]. IEEE Transa- ctions on Power Electronics, 2012, 27(12): 4832-4836. [22] Zhao Biao, Song Qiang, Li Jianguo, et al.Full- process operation, control, and experiments of modular high-frequency-link DC transformer based on dual active bridge for flexible MVDC distribution: a practical tutorial[J]. IEEE Transactions on Power Electronics, 2016, 32(9): 6751-6766. [23] Pugliese S, Buticchi G, Mastromauro R A, et al.Soft-start procedure for a three-stage smart trans- former based on dual-active bridge and cascaded H-bridge converters[J]. IEEE Transactions on Power Electronics, 2020, 35(10): 11039-11052. [24] Gao Guoqing, Lei Wanjun, Cui Yao, et al.Model predictive control of dual active bridge converter based on the lookup table method[C]//2019 IEEE 10th International Symposium on Power Electronics for Distributed Generation Systems (PEDG), Xi’an, China, 2019: 183-186. [25] Qin Dehao, Sun Qiuye, Ma Dazhong, et al.Model predictive control of dual-active-bridge based fast battery charger for plug-in hybrid electric vehicle in the future grid[C]//2019 IEEE Innovative Smart Grid Technologies-Asia (ISGT Asia), Chengdu, China, 2019: 2162-2166. [26] 安峰, 宋文胜, 杨柯欣. 基于扩展相移的双有源全桥DC-DC变换器多目标优化控制方法[J]. 中国电机工程学报, 2019, 39(3): 822-831, 961. An Feng, Song Wensheng, Yang Kexin.Multi- objective optimization control scheme based on extended phase-shift of dual-active-bridge DC-DC converters[J]. Proceedings of the CSEE, 2019, 39(3): 822-831, 961. [27] 韩明昊. 燃料电池车用双有源桥变换器高性能鲁棒预测控制[D]. 济南: 山东大学, 2022. Han Minghao.High performance predictive control of dual active bridge converters for fuel cell vehicles[D]. Jinan: Shandong University, 2022. [28] Kalman R E.A new approach to linear filtering and prediction problems[J]. Journal of Basic Engineering, 1960, 82(1): 35-45.
2024, Vol. 39 
