改性石墨烯基传感器对SF<sub>6</sub>分解组分H<sub>2</sub>S的吸附机理及检测特性研究

doi:10.19595/j.cnki.1000-6753.tces.220842

摘要
图/表
参考文献
相关文章 (2)

全文: PDF (4380 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要

作为SF₆的重要分解组分,H₂S能够有效反映SF₆气体绝缘电气设备内部绝缘故障类型及程度。该文以H₂S为目标检测气体,探究了改性石墨烯基传感器对H₂S的吸附机理及检测特性。基于第一性原理建立了环氧基化石墨烯（G-O）、钯掺杂石墨烯（Pd-G）和环氧基与钯共掺杂石墨烯（Pd-G-O）改性模型和H₂S吸附模型,从吸附能、态密度、轨道、脱吸附时间等多方面计算分析了G-O、Pd-G、Pd-G-O的改性机理与吸附机理,结果表明Pd-G-O对H₂S表现出优异的吸附性能,吸附能达到-1.015 eV,为较强的化学吸附,且对应着强烈的电荷转移值0.281 e;制备了G-O、Pd-G、Pd-G-O传感材料及器件,基于微量气敏测试平台测试了改性石墨烯基传感器检测H₂S的温度、体积分数、响应恢复及稳定特性,其中Pd-G-O传感器对H₂S表现出低工作温度（175 ℃）及快速响应优势。该文的仿真计算与气敏测试分析为研制检测SF₆分解组分的低功耗、高灵敏度及快速响应传感器提供了理论基础与实验支撑。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	高新
	李志慧
	刘宇鹏
	陈伟根
	周渠

关键词 ：改性石墨烯, SF₆分解组分, H₂S检测, 吸附机理, 检测特性

Abstract：

H₂S is one of the important decomposition products of SF₆. It is the characteristic component in the event of high energy partial discharge or strong overheating fault, and can reflect the severity of the fault.The gas sensor method is a method using gas sensitive materials to detect the gas composition and concentration, and is often used to detect SF₆ decomposed components.The gas sensing materials based on intrinsic graphene only show weak physical adsorption for most gases. Therefore, the sensing performance of graphene gas sensing materials and graphene gas sensors can be improved through various optimization methods such as doping, functionalization of functional groups, and composite.However, there are few studies on the properties of metal and functional group functionalized co-modified graphene in gas sensing detection at present.Based on this, three different modification methods including metal doping, functional group functionalization, doping and functional group functionalization co-modification were selected to improve the gas sensitivity of intrinsic graphene to H₂S.
Firstly, the modification models of epoxy graphene (G-O), palladium doped graphene (Pd-G) and epoxy and palladium Co-doped graphene (Pd-G-O) are established, and the modification mechanism is analyzed. Secondly, the adsorption models of modified graphene for H₂S are built, and the adsorption effect of H₂S is analyzed from adsorption energy, density of state, orbitand desorption time.Thirdly, G-O, Pd-G and Pd-G-O sensing materials and planar gas sensors are prepared based on the oxidation-reduction method and drop coating method. The gas sensing performance for H₂S are tested based on the micro gas sensing test platform.Finally, the response ability of the modified graphene sensors to H₂S is evaluated from temperature characteristics, concentration characteristics, response-recovery characteristics and stability.
The simulation results of the modified models show that, the epoxy group effectively increases the energy gap of intrinsic graphene, from 0.049 eV to 0.218 eV. The doping of Pd introduces a new impurity level at the Fermi level, which effectively improves the charge transfer of intrinsic graphene. Through the co-doping of epoxy group and Pd, the energy gap reaches 0.214 eV, and the graphene system is more stable and the charge transfer ability is enhanced. In G-O adsorbing H₂S system, the adsorption energy and charge transfer are -1.326 eV and 0.003 e, respectively. The adsorption energy is the largest, but the charge transfer capacity is extremely weak.In the system of H₂S adsorbed on Pd-G, the charge transfer is 0.254 e, and the minimum adsorption energy is -0.897 eV. In Pd-G-O adsorbing H₂S system, the co-modified graphene system shows the best adsorption performance, with the adsorption energy of -1.015 eV, which corresponds to a strong charge transfer value of 0.281 e. The results of gas sensitivity test show that, the optimum working temperature of G-O, Pd-G and Pd-G-O sensors is 225, 175 and 175 ℃ respectively. The lower detection limits for H₂S are 6.9, 2.3, 0.5 μL/L. The response recovery time of Pd-G-O to 50 μL/L of H₂S is 23/18 s. The response value is 10.02, which is the 1.818 and 1.538 times of that of G-O and Pd-G.
The following conclusions can be drawn from the analysis: (1) The stability and charge transfer ability of Pd-G-O system have been improved. The energy gap of intrinsic graphene is increased and metal energy level appears at Fermi energy level through the co-doping of epoxy group and Pd. (2) G-O, Pd-G, Pd-G-O improved the adsorption performance of intrinsic graphene for H₂S. The Absolute value of adsorption energy is G-O>Pd-G-O>Pd-G; The charge transfer value is Pd-G-O>Pd-G>G-O. Among them, Pd-G-O shows great adsorption effect and charge transfer ability, attributing to the strong hybridization between the S 3p orbital and the Pd 4d orbital. (3) Pd-G-O sensor shows excellent gas sensing performance, and can be used as a promising gas sensor material for detecting H₂S. Pd-G-O gas sensor shows the advantages of low operating temperature, low detection limit and high response value, suitable for the detection of trace H₂S.

Key words： Modified graphene SF₆ decomposed component H₂S detection adsorption mechanism detection characteristics

收稿日期: 2022-05-17

PACS:

TM855

基金资助:

国家自然科学基金资助项目（52077177）

通讯作者: 周渠男,1983年生,教授,博士生导师,研究方向为电力设备在线监测与故障诊断。E-mail：zhouqu@swu.edu.cn

作者简介: 高新女,1998年生,硕士研究生,研究方向为电力设备在线监测与故障诊断。E-mail：1289547142@qq.com.

引用本文:

高新, 李志慧, 刘宇鹏, 陈伟根, 周渠. 改性石墨烯基传感器对SF₆分解组分H₂S的吸附机理及检测特性研究[J]. 电工技术学报, 2023, 38(13): 3606-3618. Gao Xin, Li Zhihui, Liu Yupeng, Chen Weigen, Zhou Qu. Study on Adsorption Mechanism and Detection Characteristics of Modified Graphene Sensors for SF₆ Decomposed Component H₂S. Transactions of China Electrotechnical Society, 2023, 38(13): 3606-3618.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.220842 https://dgjsxb.ces-transaction.com/CN/Y2023/V38/I13/3606

[1] 桂银刚, 陈盈, 唐超, 等. 锇掺杂单层SnS₂对SOF₂和SO₂F₂吸附特性[J]. 电工技术学报, 2022, 37(15): 3923-3931.
Gui Yingang, Chen Ying, Tang Chao, et al.Adsorption properties of Os doped SnS₂ monolayer to SOF₂ and SO₂F₂[J]. Transactions of China Electrotechnical Society, 2022, 37(15): 3923-3931.
[2] 王邸博, 陈达畅, 皮守苗, 等. 基于密度泛函理论的SF₆分解组分在ZnO(0001)吸附及传感性能研究[J]. 电工技术学报, 2020, 35(7): 1592-1602.
Wang Dibo, Chen Dachang, Pi Shoumiao, et al.Density functional theory study of SF₆ decomposed products over ZnO(0001) with gas sensing properties[J]. Transactions of China Electrotechnical Society, 2020, 35(7): 1592-1602.
[3] 何彦良, 丁未, 孙安邦, 等. 电场不均匀系数对SF₆/N₂混合气体负直流电晕电流脉冲特性的影响[J]. 电工技术学报, 2021, 36(15): 3124-3134.
He Yanliang, Ding Wei, Sun Anbang, et al.Effect of electric field non-uniformity coefficient on current pulse characteristics of negative DC corona in SF₆/N₂ gas mixtures[J]. Transactions of China Electrotechnical Society, 2021, 36(15): 3124-3134.
[4] 汲胜昌, 钟理鹏, 刘凯, 等. SF₆放电分解组分分析及其应用的研究现状与发展[J]. 中国电机工程学报, 2015, 35(9): 2318-2332.
Ji Shengchang, Zhong Lipeng, Liu Kai, et al.Research status and development of SF₆ decomposition components analysis under discharge and its application[J]. Proceedings of the CSEE, 2015, 35(9): 2318-2332.
[5] 张晓星, 王宇非, 崔兆仑, 等. 不同填充材料对介质阻挡放电降解SF₆的实验研究[J]. 电工技术学报, 2021, 36(2): 397-406.
Zhang Xiaoxing, Wang Yufei, Cui Zhaolun, et al.Experimental study on the degradation of SF₆ by dielectric barrier discharge with different packing materials[J]. Transactions of China Electrotechnical Society, 2021, 36(2): 397-406.
[6] 桂银刚, 许文龙, 张晓星, 等. TiO₂掺杂石墨烯对SO₂气体的气敏特性研究[J]. 电工技术学报, 2021, 36(21): 4590-4597.
Gui Yingang, Xu Wenlong, Zhang Xiaoxing, et al.Adsorption property of SO₂ gas on TiO₂-doped graphene[J]. Transactions of China Electrotechnical Society, 2021, 36(21): 4590-4597.
[7] Gao Xin, Zhou Qu, Wang Jingxuan, et al.Adsorption of SO₂ molecule on Ni-doped and Pd-doped graphene based on first-principle study[J]. Applied Surface Science, 2020, 517: 146180.
[8] 张施令, 姚强, 苗玉龙, 等. 高压组合电器中SF₆分解产物SO₂F₂红外吸收特性及其检测传感装置研究[J]. 高压电器, 2021, 57(10): 25-35.
Zhang Shiling, Yao Qiang, Miao Yulong, et al.Study on infrared absorption properties of SF₆ gas-decomposition product SO₂F₂ in GIS and its detection and sensing device[J]. High Voltage Apparatus, 2021, 57(10): 25-35.
[9] Cao Zhengmao, Wang Wu, Ma Hao, et al.Porous Mn-doped Co₃O₄ nanosheets: gas sensing performance and interfacial mechanism investigation with in situ DRIFTS[J]. Sensors and Actuators B: Chemical, 2022, 353: 131155.
[10] 庞思远, 刘希喆. 石墨烯在电气领域的研究与应用综述[J]. 电工技术学报, 2018, 33(8): 1705-1722.
Pang Siyuan, Liu Xizhe.Review on research and application of graphene in electrical field[J]. Transactions of China Electrotechnical Society, 2018, 33(8): 1705-1722.
[11] Hsu S Y. Lee C L, Kuo C H, et al.Defective graphene nanosheets with heteroatom doping as hydrogen peroxide reduction catalysts and sensors[J]. Sensors and Actuators B: Chemical, 2021, 328: 129015.
[12] 皮守苗, 张晓星, 方佳妮, 等. 不同PtNPs掺杂量石墨烯传感器检测SF₆分解组分的气敏特性[J]. 高压电器, 2022, 58(2): 67-72, 81.
Pi Shoumiao, Zhang Xiaoxing, Fang Jiani, et al.Different PtNPs doped graphene sensor for detecting gas sensitive property of SF₆ decomposition components[J]. High Voltage Apparatus, 2022, 58(2): 67-72, 81.
[13] Gecim G, Ozekmekci M, Fellah M F.Ga and Ge-doped graphene structures: a DFT study of sensor applications for methanol[J]. Computational and Theoretical Chemistry, 2020, 1180: 112828.
[14] Rafiee Z, Roshan H, Sheikhi M H.Low concentration ethanol sensor based on graphene/ZnO nanowires[J]. Ceramics International, 2021, 47(4): 5311-5317.
[15] Niu Fang, Shao Zhenwu, Gao Hong, et al.Si-doped graphene nanosheets for NO_x gas sensing[J]. Sensors and Actuators: B. Chemical, 2021, 328: 129005.
[16] Khodadadi Z.Evaluation of H₂S sensing characteristics of metals-doped graphene and metals-decorated graphene: insights from DFT study[J]. Physica E: Low-Dimensional Systems and Nanostructures, 2018, 99: 261-268.
[17] Zhang Xiaoxing, Cui Hao, Dong Xingchen, et al.Adsorption performance of Rh decorated SWCNT upon SF₆ decomposed components based on DFT method[J]. Applied Surface Science, 2017, 420: 825-832.
[18] 王婧璇, 周渠, 桂银刚, 等. 掺杂硫化钼对油中特征气体C₂H₂的吸附性能[J]. 高电压技术, 2020, 46(6): 1962-1969.
Wang Jingxuan, Zhou Qu, Gui Yingang, et al.Adsorption properties of the C₂H₂ characteristic gas in oil by doped MoS₂[J]. High Voltage Engineering, 2020, 46(6): 1962-1969.
[19] Jia Xiaotong, Zhang Hong, Zhan Zhiming, et al.First-principles investigation of vacancy-defected graphene and Mn-doped graphene towards adsorption of H₂S[J]. Superlattices and Microstructures, 2019, 134: 106235.
[20] 姚利花. Na在B掺杂的空位石墨烯上吸附性能的第一性原理研究[J]. 原子与分子物理学报, 2018, 35(6): 953-957.
Yao Lihua.Adsorption of Na on B-doped vacancy graphene: a first-principles study[J]. Journal of Atomic and Molecular Physics, 2018, 35(6): 953-957.
[21] Ni Jiaming.Adsorption of small gas molecules on transition metal (Fe, Ni and Co, Cu) doped graphene: a systematic DFT study[J]. Physica E: Low-Dimensional Systems and Nanostructures, 2020, 116: 113768.
[22] Gui Yingang, Quintana Mildred, Song Shaoxian.Gas sensing of graphene and graphene oxide nanoplatelets to ClO₂ and its decomposed species[J]. Superlattices and Microstructures, 2019, 135: 106248.
[23] Huang Yanli, Wei Qiuli, Wang Yuanyuan, et al.Three-dimensional amine-terminated ionic liquid functionalized graphene/Pd composite aerogel as highly efficient and recyclable catalyst for the Suzuki cross-coupling reactions[J]. Carbon, 2018, 136: 150-159.
[24] Chen Dachang, Zhang Xiaoxing, Tang Ju, et al.Pristine and Cu decorated hexagonal InN monolayer, a promising candidate to detect and scavenge SF₆ decompositions based on first-principle study[J]. Journal of Hazardous Materials, 2019, 363: 346-357.
[25] 郭茜, 富佳龙, 张成燕, 等. 还原氧化石墨烯@泡沫镍载CoO纳米花电极制备及催化CO₂性能[J]. 电化学, 2021, 27(4): 449-455.
Guo Nguo, Fu Jialong, Zhang Chengyan, et al.Preparation of CoO/RGO@Ni foam electrode and its electrocatalytic reduction of CO₂[J]. Journal of Electrochemistry, 2021, 27(4): 449-455.
[26] 刘丽来, 李勇, 殷秀珍, 等. 纳米Fe₃O₄/石墨烯制备及其对水中甲基橙吸附[J]. 非金属矿, 2018, 41(6): 92-94.
Liu Lilai, Li Yong, Yin Xiuzhen, et al.Preparation of nano Fe₃O₄/graphene and its adsorption for methly orange[J]. Non-Metallic Mines, 2018, 41(6): 92-94.
[27] 张胜利, 宋延华, 司丹亚. 水热法制备还原氧化石墨烯-硫复合材料的性能[J]. 电池, 2016, 46(3): 129-132.
Zhang Shengli, Song Yanhua, Si Danya.Performance of reduced graphene oxide-sulfur composite prepared by hydrothermal method[J]. Battery Bimonthly, 2016, 46(3): 129-132.
[28] Zhou Qingxiao, Ju Weiwei, Su Xiangying, et al.Adsorption behavior of SO₂ on vacancy-defected graphene: a DFT study[J]. Journal of Physics and Chemistry of Solids, 2017, 109: 40-45.