Current Closed-Loop Control Strategy of Permanent Magnet Synchronous Motor Based on SHEPWM
Cai Zhanpeng1, Yang Shuying1, Wang Qishuai1, Wang Hui2
1. College of Electrical Engineering and Automation Hefei University of Technology Hefei 230009 China; 2. Sungrow Power Supply Co. Ltd Hefei 230088 China
Abstract：Regarding high-speed electric drives, the ratio of the switching to the fundamental frequency is low due to the limited switching frequency allowed. As a result, the low-order harmonics of conventional asynchronous pulse width modulation are relatively large. Selective harmonic elimination pulse width modulation (SHEPWM) can effectively eliminate low-order harmonics. Still, the actual output voltage deviation is relatively large during the dynamic process, which affects the dynamic performance of the field-oriented control system. To suppress the influence of deviation voltage on the system, this paper proposes a SHEPWM current closed-loop control scheme based on duty cycle adaptive compensation. Firstly, the current closed-loop implementation scheme of SHEPWM is introduced. This scheme achieves phase matching between field-oriented control and synchronous modulation by utilizing a phase-locked loop. Through the discretization modeling of the phase-locked loop, a theoretical basis is provided for parameter tuning. Subsequently, the influence of the control instructions of the SHEPWM algorithm and the actual output volt-second imbalance of the inverter on the control system is analyzed. This paper proposes a duty cycle compensation method based on current error and designs a dynamic weighting factor through a nonlinear error function for duty cycle compensation. This scheme eliminates the deviation voltage in the dynamic process, thereby improving dynamic performance. During the steady-state process, the deviation voltage is not compensated, thereby ensuring the steady-state harmonic performance of SHEPWM. Experiments were conducted on the 18 kW IPMSM hardware platform. At the rated rotational speed, compared with the traditional F-SHE modulation scheme, the dynamic regulation time of D-SHE is shortened from 45ms to 22 ms, and the current overshoot during the dynamic process is significantly reduced. During the steady-state process, the duty cycle compensation amount of D-SHE is approximately 0, thus ensuring the harmonic elimination performance. The fifth and seventh harmonics of the stator current are reduced to 2.4% and 2.8% respectively, and the total harmonic distortion is like that of the P-SHE modulation strategy without duty cycle compensation. The following conclusions can be drawn. (1) The complete SHE switching period is equivalent to being divided into 12 switch sequences. The current sampling points are fixed at the starting points of the ideal spatial vector, achieving phase synchronization and ensuring the stability of the switch sequence. (2) Optimizing the synchronous modulation strategy: Due to its fixed switching time, the actual output voltage deviation during the dynamic process affects the dynamic response performance of the control system. (3) The proposed strategy designs an adaptive dynamic weighting factor through a nonlinear error function. During the dynamic response process, the duty cycle deviation is adaptively compensated by correcting the switching time. However, when the system is in steady-state conditions, the duty cycle deviation of the switching Angle of SHEPWM is not corrected, thus not affecting the harmonic elimination characteristics in the steady-state conditions.
蔡展鹏, 杨淑英, 王奇帅, 王辉. 基于SHEPWM的永磁同步电机电流闭环控制策略[J]. 电工技术学报, 2025, 40(20): 6460-6473.
Cai Zhanpeng, Yang Shuying, Wang Qishuai, Wang Hui. Current Closed-Loop Control Strategy of Permanent Magnet Synchronous Motor Based on SHEPWM. Transactions of China Electrotechnical Society, 2025, 40(20): 6460-6473.
[1] 王祥松, 杨淑英, 谢震, 等. 基于多参数辨识的永磁同步电机磁链预测控制[J]. 电工技术学报, 2024, 39(22): 7084-7098. Wang Xiangsong, Yang Shuying, Xie Zhen, et al.Multi-parameter identification based flux predictive control for permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2024, 39(22): 7084-7098. [2] 东野亚兰, 杨淑英, 王奇帅, 等. 基于增强型扩张状态观测器的永磁同步电机低抖振高抗扰二阶终端滑模电流控制[J]. 电工技术学报, 2024, 39(8): 2434-2448. Dongye Yalan, Yang Shuying, Wang Qishuai, et al.Enhanced extended state observer based second order terminal sliding mode current control for permanent magnet synchronous machine with low chattering and improved disturbance rejection[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2434-2448. [3] 朱玉璞, 杨淑英, 王奇帅. 基于延迟校正扩张状态观测器的内置式永磁同步电机电流控制策略[J]. 电工技术学报, 2024, 39(6): 1698-1712. Zhu Yupu, Yang Shuying, Wang Qishuai.Current control strategy of interior permanent magnet synchronous motor based on delay corrected extended state observers[J]. Transactions of China Electro- technical Society, 2024, 39(6): 1698-1712. [4] 张钦培, 李健, 卢阳, 等. 低载波比牵引系统的感应电机特征根离散化模型研究[J]. 电工技术学报, 2024, 39(2): 434-444, 454. Zhang Qinpei, Li Jian, Lu Yang, et al.Research on discretization model of induction motor for low switching-to-fundamental frequency ratio traction system[J]. Transactions of China Electrotechnical Society, 2024, 39(2): 434-444, 454. [5] 王堃, 游小杰, 王琛琛, 等. 低开关频率下SHEPWM和SVPWM同步调制策略比较研究[J]. 电工技术学报, 2015, 30(14): 333-341. Wang Kun, You Xiaojie, Wang Chenchen, et al.Research on the comparison of synchronized modulation of SHEPWM and SVPWM under low switching frequency[J]. Transactions of China Elec- trotechnical Society, 2015, 30(14): 333-341. [6] Narayanan G, Ranganathan V T.Two novel syn- chronized bus-clamping PWM strategies based on space vector approach for high power drives[J]. IEEE Transactions on Power Electronics, 2002, 17(1): 84-93. [7] 谭新元. 牵引逆变器SHEPWM控制技术的研究[J]. 中国电机工程学报, 2001, 21(9): 47-52. Tan Xinyuan.Advanced shepwm technique for AC traction drives[J]. Proceedings of the CSEE, 2001, 21(9): 47-52. [8] Wells J R, Nee B M, Chapman P L, et al.Selective harmonic control: a general problem formulation and selected solutions[J]. IEEE Transactions on Power Electronics, 2005, 20(6): 1337-1345. [9] 马逊, 李耀华, 葛琼璇, 等. 谐波电流最小同步优化脉宽调制策略研究[J]. 中国电机工程学报, 2015, 35(5): 1211-1220. Ma Xun, Li Yaohua, Ge Qiongxuan, et al.Research on synchronous minimum harmonic current optimized pulse width modulation strategies[J]. Proceedings of the CSEE, 2015, 35(5): 1211-1220. [10] 周明磊, 游小杰, 王琛琛, 等. 电流谐波最小PWM开关角的计算及谐波特性分析[J]. 中国电机工程学报, 2014, 34(15): 2362-2370. Zhou Minglei, You Xiaojie, Wang Chenchen, et al.Switching angle calculation and harmonic analysis of current harmonic minimum PWM[J]. Proceedings of the CSEE, 2014, 34(15): 2362-2370. [11] Bowes S R, Holliday D.Optimal regular-sampled PWM inverter control techniques[J]. IEEE Transa- ctions on Industrial Electronics, 2007, 54(3): 1547-1559. [12] Holtz J, Qi Xin.Optimal control of medium-voltage drives: an overview[J]. IEEE Transactions on Industrial Electronics, 2013, 60(12): 5472-5481. [13] Wu Mingzhe, Ding Li, Xue Cheng, et al.Model-based closed-loop control for high-power current source rectifiers under selective harmonic elimination/ compensation PWM with fast dynamics[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2022, 10(5): 5921-5932. [14] Holtz J, Oikonomou N.Synchronous optimal pulse- width modulation and stator flux trajectory control for medium-voltage drives[J]. IEEE Transactions on Industry Applications, 2007, 43(2): 600-608. [15] Oikonomou N, Holtz J.Closed-loop control of medium-voltage drives operated with synchronous optimal pulse width modulation[J]. IEEE Transactions on Industry Applications, 2008, 44(1): 115-123. [16] Moeini A, Hui Zhao, Wang Shuo.High efficiency, hybrid selective harmonic elimination phase-shift PWM technique for cascaded H-bridge inverters to improve dynamic response and operate in complete normal modulation indices[C]//2016 IEEE Applied Power Electronics Conference and Exposition (APEC), Long Beach, CA, USA, 2016: 2019-2026. [17] 周国华, 王淇, 邓伦博. 宽增益高效率CLLLC变换器的变频双移相调制策略[J]. 电工技术学报, 2024, 39(8): 2511-2522. Zhou Guohua, Wang Qi, Deng Lunbo.Variable- frequency dual-phase-shift modulation strategy for CLLLC converter with wide voltage gain and high efficiency[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2511-2522. [18] Aguilera R P, Acuña P, Lezana P, et al.Selective harmonic elimination model predictive control for multilevel power converters[J]. IEEE Transactions on Power Electronics, 2017, 32(3): 2416-2426. [19] Gao Hang, Wu Bin, Xu Dewei, et al.Model predictive switching pattern control for current-source con- verters with space-vector-based selective harmonic elimination[J]. IEEE Transactions on Power Elec- tronics, 2017, 32(8): 6558-6569. [20] Cheng Jingling, Xu Tingting, Chen Dongdong, et al.Dynamic and steady state response analysis of selective harmonic elimination in high power inverters[J]. IEEE Access, 2021, 9: 75588-75598. [21] Yang Haitao, Zhang Yongchang, Yuan Guofeng, et al.Hybrid synchronized PWM schemes for closed-loop current control of high-power motor drives[J]. IEEE Transactions on Industrial Electronics, 2017, 64(9): 6920-6929. [22] Xiao Lifan, Li Jian, Xiong Yongqian, et al.Strategy and implementation of harmonic-reduced synchronized SVPWM for high-power traction machine drives[J]. IEEE Transactions on Power Electronics, 2020, 35(11): 12457-12471. [23] Chiasson J, Tolbert L M, McKenzie K, et al. A complete solution to the harmonic elimination problem[C]//Eighteenth Annual IEEE Applied Power Electronics Conference and Exposition, 2003, Miami Beach, FL, USA, 2003: 596-602. [24] 王琛琛, 李瑞夫, 周明磊. 基于TMS320F28335的SHEPWM数字实现[J]. 北京交通大学学报, 2011, 35(5): 89-93, 105. Wang Chenchen, Li Ruifu, Zhou Minglei.Digital realization of SHEPWM based on TMS320F28335[J]. Journal of Beijing Jiaotong University, 2011, 35(5): 89-93, 105. [25] 郭新华, 王永兴, 赵峰, 等. 基于SHEPWM的中压大功率牵引永磁同步电机两电平控制[J]. 电工技术学报, 2012, 27(11): 76-82. Guo Xinhua, Wang Yongxing, Zhao Feng, et al.Two level control technology of PMSM used in medium voltage high power traction system based on SHEPWM[J]. Transactions of China Electrotechnical Society, 2012, 27(11): 76-82. [26] Qishuai Wang, Shuying Yang, Zhen Xie, et al.Analysis and improvement of synchronous PWM based closed-loop current control for machine drive[J]. IEEE Transactions Power Electronics, 2024, 39(8): 10166-10176. [27] Wang Qishuai, Yang Shuying, Dongye Yalan, et al.Optimized discrete-time current control for IPMSM drives[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(5): 5222-5233. [28] Yang Shuying, Wang Qishuai, Xie Zhen, et al.Digital current controller with a novel active damping design for IPMSM[J]. IEEE Transactions on Energy Conversion, 2022, 37(1): 185-197. [29] 杨淑英, 王玉柱, 储昭晗, 等. 基于增益连续扩张状态观测器的永磁同步电机电流解耦控制[J]. 中国电机工程学报, 2020, 40(6): 1985-1997. Yang Shuying, Wang Yuzhu, Chu Zhaohan, et al.Current decoupling control of PMSM based on an extended state observer with continuous gains[J]. Proceedings of the CSEE, 2020, 40(6): 1985-1997.
2025, Vol. 40 
