A Method for Stray Capacitance Measuring and Refined Modeling of Potential Transformer Based on Low Frequency and Narrow Band Scanning
Shen Zeliang1, Wang Jingang1, Wang Qian2, Zhao Pengcheng1, Yan Xiaojun1
1. State Key Laboratory of Power Transmission Equipment & System Security and New Technology Chongqing University Chongqing 400044 China; 2. Chongqing Electric Power Research Institute Chongqing 401123 China
Abstract：The low-frequency responses of potential transformers (PT) are essential in power system protection. Due to the complex winding structure and large transformation ratio, the stray capacitance will significantly impact the dynamic performance of the PT. Many studies have analyzed the distribution of the electric field and magnetic field energy of the PT at low frequencies to determine its modeling method of it. However, it is difficult to obtain the stray capacitance value of a PT without its detailed internal structure parameters, which makes it challenging to build an accurate low-frequency simulation model. Firstly, the electric field energy distribution for two typical winding structures was analyzed, and the corresponding stray capacitance values could be calculated. The capacitance calculation method explained the generation mechanism of the PT and could provide references for the design progress. However, most users of the PT are not involved in the design progress and need help understanding its detailed internal structure parameters. Therefore, a non-destructive experiment method is necessary for the stray capacitance evaluation. Secondly, the equivalent model of PT stray capacitance distribution at low frequency was built, and the low-frequency dynamic responses under electromagnetic field coupling of the core and coil were analyzed. The obtained model can provide support for the experimental designs. Finally, a series of tests were carried out to obtain the specific value of PT stray capacitance. By connecting the inductance in series between the PT and the frequency conversion power supply port, the resonance point of the sweep frequency test was reduced to the low-frequency range, and the value of the stray capacitance was accurately calculated. Since this method requires a narrow scanning frequency band and a low scanning frequency, the hardware requirements for power supply and measuring equipment are reduced, and the loss problem caused by high-frequency testing is avoided. Furthermore, the capacitive and excitation current components in the PT port current could be separated, and the hysteresis curve could be accurately drawn. Based on the problem that it is difficult to measure the PT stray capacitance and hysteresis curve in engineering, this paper reduced the resonant frequency point of the sweep frequency test using series inductance and calculated the stray capacitance. Furthermore, the capacitive component in the current of the PT port could be excluded, and the accurate drawing of the hysteresis curve of the iron core could be realized. Combined with the short-circuit test and DC resistance measurement results, the π-type equivalent circuit of PT was constructed. The simulation results had good frequency response characteristics. The Pearson correlation coefficient was introduced to study the accuracy of the simulation model, and the correlation coefficient with the test results remained above 95 %. Due to the accurate description of the inductive and capacitive coupling, the model can be applied to the ferromagnetic resonance simulation of a power system to obtain more accurate simulation results and provide a reference for the design of the anti-resonance scheme.
沈泽亮, 汪金刚, 王谦, 赵鹏程, 颜晓军. 一种基于低频窄带扫描的电磁式电压互感器杂散电容测量与精确建模方法[J]. 电工技术学报, 2023, 38(8): 2211-2221.
Shen Zeliang, Wang Jingang, Wang Qian, Zhao Pengcheng, Yan Xiaojun. A Method for Stray Capacitance Measuring and Refined Modeling of Potential Transformer Based on Low Frequency and Narrow Band Scanning. Transactions of China Electrotechnical Society, 2023, 38(8): 2211-2221.
[1] 朱学成. 220kV GIS电磁式电压互感器现场变频感应耐压试验[J]. 黑龙江科技信息, 2016(8): 115. Zhu Xuecheng.Field frequency conversion induction withstand voltage test of 220kV GIS electromagnetic voltage transformer[J]. Heilongjiang Science and Technology Information, 2016(8): 115. [2] Dalessandro L, da Silveira C F, Kolar J W. Self- capacitance of high-voltage transformers[J]. IEEE Transactions on Power Electronics, 2007, 22(5): 2081-2092. [3] de Grève Z, Deblecker O, Lobry J. Numerical modeling of capacitive effects in HF multiwinding transformers—part I: a rigorous formalism based on the electrostatic equations[J]. IEEE Transactions on Magnetics, 2013, 49(5): 2017-2020. [4] de Grève Z, Deblecker O, Lobry J. Numerical modeling of capacitive effects in HF multiwinding transformers—part II: identification using the finite- element method[J]. IEEE Transactions on Magnetics, 2013, 49(5): 2021-2024. [5] Liu Xiaojing, Wang Youhua, Zhu Jianguo, et al.Calculation of capacitance in high-frequency trans- former windings[J]. IEEE Transactions on Magnetics, 2016, 52(7): 1-4. [6] Liu Chen, Qi Lei, Cui Xiang, et al.Wideband mechanism model and parameter extracting for high- power high-voltage high-frequency transformers[J]. IEEE Transactions on Power Electronics, 2016, 31(5): 3444-3455. [7] 宋晓婷. 高频高压变压器分布参数测量和绕组结构设计[D]. 大连: 大连理工大学, 2013. [8] 赵翠. 换流变压器阀侧线端杂散电容的计算[D]. 北京: 华北电力大学, 2015. [9] Eslamian M.Combined analytical and FEM methods for parameters calculation of detailed model for dry- type transformer[J]. Simulation Modelling Practice and Theory, 2010, 18(3): 390-403. [10] Blache F, Keradec J P, Cogitore B.Stray capacitances of two winding transformers: equivalent circuit, measurements, calculation and lowering[C]//Pro- ceedings of 1994 IEEE Industry Applications Society Annual Meeting, Denver, CO, USA, 2002: 1211-1217. [11] Cogitore B, Keradec J P, Barbaroux J.The two- winding transformer: an experimental method to obtain a wide frequency range equivalent circuit[J]. IEEE Transactions on Instrumentation and Measure- ment, 1994, 43(2): 364-371. [12] 刘晨, 齐磊, 崔翔, 等. 高压高频变压器寄生电容实验提取方法[J]. 华北电力大学学报(自然科学版), 2017, 44(1): 1-8. Liu Chen, Qi Lei, Cui Xiang, et al.An experimental method for extracting parasitic capacitances of high- voltage high-frequency transformers[J]. Journal of North China Electric Power University (Natural Science Edition), 2017, 44(1): 1-8. [13] Zhou Yuan, Yang Cuiru, Sima Wenxia, et al.A model considering deep saturation of the iron core for 10kV potential transformers[C]//2018 IEEE International Conference on High Voltage Engineering and Appli- cation (ICHVE), Athens, Greece, 2019: 1-4. [14] Wang Yang, Liu Zhizhen.Establishment of core dynamic hysteresis model under DC flux[C]//2015 IEEE International Conference on Applied Super- conductivity and Electromagnetic Devices (ASEMD), Shanghai, China, 2016: 334-335. [15] Almeida A A, Perassa L S, Rodrigues D L, et al.Excess loss localization on the hysteresis curve[J]. IEEE Transactions on Magnetics, 2014, 50(4): 1-4. [16] Németh Z.Analysis of Epstein frame by finite element method[J]. Przegląd Elektrotechniczny, 2019, 1(6): 25-28. [17] 杨北超, 范学鑫, 王瑞田, 等. 考虑铁心非线性的三相立体卷铁心变压器建模及空载特性分析[J]. 电工技术学报, 2022, 37(9): 2263-2274. Yang Beichao, Fan Xuexin, Wang Ruitian, et al.Modeling and no-load characteristics analysis of 3D wound core transformer considering core nonlinear- rity[J]. Transactions of China Electrotechnical Society, 2022, 37(9): 2263-2274. [18] 刘永来. 考虑铁心渐变饱和特性的单相双绕组变压器模型研究[D]. 重庆: 重庆大学, 2019. [19] 司马文霞, 刘永来, 杨鸣, 等. 考虑铁心深度饱和的单相双绕组变压器改进π 模型[J]. 中国电机工程学报, 2018, 38(24): 7131-7140, 7439. Sima Wenxia, Liu Yonglai, Yang Ming, et al.An improved π model for single-phase two winding transformers considering deep saturation of the iron core[J]. Proceedings of the CSEE, 2018, 38(24): 7131-7140, 7439. [20] Sima Wenxia.Low-frequency model for single-phase transformers based on the three-component Preisach model considering deep saturation[J]. International Journal of Electrical Power & Energy Systems, 2019, 110: 107-117. [21] 杨鸣, 熊钊, 司马文霞, 等. 电磁式电压互感器“低频过电压激励-响应”逆问题求解[J]. 电工技术学报, 2021, 36(17): 3605-3613. Yang Ming, Xiong Zhao, Sima Wenxia, et al.Solution of the inverse problem of “low-frequency overvoltage excitation to response” for electromagnetic potential transformers[J]. Transactions of China Electro- technical Society, 2021, 36(17): 3605-3613. [22] Shen Zeliang, Wang Jingang, Yan Xiaojun, et al.A method for extracting stray capacitance and hysteresis curves of potential transformers based on frequency referring[J]. IEEE Transactions on Power Delivery, 2022, 37(3): 1897-1905. [23] Biela J, Kolar J W.Using transformer parasitics for resonant converters—a review of the calculation of the stray capacitance of transformers[J]. IEEE Transa- ctions on Industry Applications, 2008, 44(1): 223-233. [24] 庞天宇. 分布电容对高频变压器特性影响的研究[D]. 天津: 河北工业大学, 2017. [25] 孟涛, 安彦桦, 贲洪奇. 输入串联型变换器集成变压器的分布电容影响机制与绕组布局方法[J]. 电工技术学报, 2021, 36(24): 5272-5282. Meng Tao, An Yanhua, Ben Hongqi.Stray capa- citances influences and windings layout of the integrated-transformer in the input-series converter[J]. Transactions of China Electrotechnical Society, 2021, 36(24): 5272-5282. [26] 司马文霞, 刘永来, 杨鸣, 等. 考虑铁心深度饱和的单相双绕组变压器改进π 模型[J]. 中国电机工程学报, 2018, 38(24): 7131-7140, 7439. Sima Wenxia, Liu Yonglai, Yang Ming, et al.An improved π model for single-phase two winding transformers considering deep saturation of the iron core[J]. Proceedings of the CSEE, 2018, 38(24): 7131-7140, 7439. [27] 刘永来. 考虑铁心渐变饱和特性的单相双绕组变压器模型研究[D]. 重庆: 重庆大学, 2019. [28] Sima Wenxia.Saturable reactor hysteresis model based on Jiles-Atherton formulation for ferrore- sonance studies[J]. International Journal of Electrical Power & Energy Systems, 2018, 101: 482-490. [29] 汪伟, 汲胜昌, 李彦明. 用非线性电阻模拟变压器损耗进行铁磁谐振过电压研究[J]. 西安交通大学学报, 2009, 43(10): 109-113. Wang Wei, Ji Shengchang, Li Yanming.Ferrore- sonance simulation with nonlinear resistance mode- ling for transformer power losses[J]. Journal of Xi'an Jiaotong University, 2009, 43(10): 109-113. [30] 纪德洋, 金锋, 冬雷, 等. 基于皮尔逊相关系数的光伏电站数据修复[J]. 中国电机工程学报, 2022, 42(4): 1514-1523. Ji Deyang, Jin Feng, Dong Lei, et al.Data repairing of photovoltaic power plant based on Pearson correlation coefficient[J]. Proceedings of the CSEE, 2022, 42(4): 1514-1523. [31] 任明, 夏昌杰, 余家赫, 等. 绝缘子沿面放电多光谱脉冲演化特性及诊断方法研究[J]. 电工技术学报, 2023, 38(3): 806-817. Ren Ming, Xia Changjie, Yu Jiahe, et al.Multi- spectral pulse evolution of insulator surface dis- charges and its diagnosis approach[J]. Transactions of China Electrotechnical Society, 2023, 38(3): 806-817. [32] 张骞, 边晓燕, 徐鑫裕, 等. 基于SVD-Prony及主成分回归的次同步振荡阻尼特性影响因素研究[J]. 电工技术学报, 2022, 37(17): 4364-4376. Zhang Qian, Bian Xiaoyan, Xu Xinyu, et al.Analysis of influencing factors on damping characteristics of subsynchronous oscillation based on singular value decomposition Prony and principal component regression[J]. Transactions of China Electrotechnical Society, 2022, 37(17): 4364-4376.
2023, Vol. 38 
