Research on 3-Vector Model Predictive Control with Low Switching Frequency of Permanent Magnet Synchronous Motor
Yao Jun1, Liu Ruikuo1, Yin Xiao2
1. State Key Laboratory of Power Transmission Equipment & System Security and New Technology Chongqing University Chongqing 400044 China; 2. Chongqing Vehicle Test & Research Institute Co. Ltd Chongqing 401122 China;
Abstract：Aiming at the problem of current loop control performance would be deteriorated when permanent magnet synchronous motor (PMSM) drive system operates under low carrier modulation ratio condition, the principle of single vector model predictive control (MPC) of PMSM is analyzed. In addition, the strategy of 3-vector model predictive control of PMSM is obtained. Furthermore, as the MPC is capable of considering the multiple control objectives and system constraints, it could improve the system performance when considering the converter switching frequency in the strategy. As a consequence, a 3-vector model predictive control with low switching frequency is proposed in this paper, which can effectively reduce the converter switching frequency and improve the static and dynamic performance of the current loop. Finally, the simulations and experiments are conducted to make a comparison based on a PMSM drive system between the traditional vector control and 3-vector MPC with reduced switching frequency. The results are used to verify the feasibility and correctness of the proposed control strategy, which show that the investigated method is superior to the traditional vector control strategy.
姚骏, 刘瑞阔, 尹潇. 永磁同步电机三矢量低开关频率模型预测控制研究[J]. 电工技术学报, 2018, 33(13): 2935-2945.
Yao Jun, Liu Ruikuo, Yin Xiao. Research on 3-Vector Model Predictive Control with Low Switching Frequency of Permanent Magnet Synchronous Motor. Transactions of China Electrotechnical Society, 2018, 33(13): 2935-2945.
[1] 史婷娜, 张维, 肖萌, 等. 基于矢量作用时间的永磁同步电机预测电流控制[J]. 电工技术学报, 2017, 32(19): 1-10. Shi Tingna, Zhang Wei, Xiao Meng, et al.Predictive current control for permanent magnet synchronous motor based on operating time of vector[J]. Transactions of China Electrotechnical Society, 2017, 32(19): 1-10. [2] 王高林, 李卓敏, 詹瀚林, 等. 考虑逆变器非线性的内置式永磁同步电机转子位置锁相环观测器[J]. 电工技术学报, 2014, 29(3): 172-179. Wang Gaolin, Li Zhuomin, Zhan Hanlin, et al.Phase-locked-loop rotor position observer for IPMSM considering inverter nonlinearity[J]. Transactions of China Electrotechnical Society, 2014, 29(3): 172-179. [3] 易伯瑜, 康龙云, 冯自成, 等. 基于扰动观测器的永磁同步电机预测电流控制[J]. 电工技术学报, 2016, 31(18): 37-45. Yi Boyu, Kang Longyun, Feng Zicheng, et al.Predictive current control for permanent magnet synchronous motor based on disturbance observer[J]. Transactions of China Electrotechnical Society, 2016, 31(18): 37-45. [4] 陈思溢, 皮佑国. 基于滑模观测器与滑模控制器的永磁同步电机无位置传感器控制[J]. 电工技术学报, 2016, 31(12): 108-117. Chen Siyi, Pi Youguo.Position sensorless control for permanent magnet synchronous motor based on sliding mode observer and sliding mode controller[J]. Transactions of China Electrotechnical Society, 2016, 31(12): 108-117. [5] 王斌, 王跃, 郭伟, 等. 基于定子磁链降阶状态观测的永磁同步电机无差拍直接转矩控制系统[J]. 电工技术学报, 2014, 29(3): 160-171. Wang Bin, Wang Yue, Guo Wei, et al.Deadbeat direct torque control of permanent magnet synchronous motor based on reduced order stator flux observer[J]. Transactions of China Electrotechnical Society, 2014, 29(3): 160-171. [6] 王庆龙, 张兴, 张崇巍. 永磁同步电机矢量控制双滑模模型参考自适应系统转速辨识[J]. 中国电机工程学报, 2014, 34(6): 897-902. Wang Qinglong, Zhang Xing, Zhang Chongwei.Double sliding-mode model reference adaptive system speed identification for vector control of permanent magnet synchronous motors[J]. Proceedings of the CSEE, 2014, 34(6): 897-902. [7] 林茂, 李颖晖, 吴辰, 等. 基于滑模模型参考自适应系统观测器的永磁同步电机预测控制[J]. 电工技术学报, 2017, 32(6): 156-163. Lin Mao, Li Yinghui, Wu Chen, et al.A model reference adaptive system based sliding mode observer for model predictive controlled permanent magnet synchronous motor drive[J]. Transactions of China Electrotechnical Society, 2017, 32(6): 156-163. [8] Jung J W, Leu V Q, Do T D, et al.Adaptive PID speed control design for permanent magnet synchronous motor drivers[J]. IEEE Transactions on Power Electronics, 2015, 30(2): 900-908. [9] Xia Changliang, Zhao Jiaxin, Yan Yan, et al.A novel direct torque control of matrix converter-fed PMSM drives using duty cycle control for torque ripple reduction[J]. IEEE Transactions on Industrial Electronics, 2014, 61(6): 2700-2713. [10] 吕帅帅, 林辉, 李兵强. 开关频率恒定与占空比调制相结合的PMSM-DTC控制[J]. 电工技术学报, 2016, 31(3): 72-80. Lü Shuaishuai, Lin Hui, Li Bingqiang.Direct torque control based on simple duty ratio and fixed switching frequency for PMSM[J]. Transactions of China Electrotechnical Society, 2016, 31(3): 72-80. [11] 魏香龙. 基于模型预测控制的永磁同步电机控制研究[D]. 北京: 北方工业大学, 2014. [12] Zhang Yongchang, Yang Haitao.Two-vector-based model predictive torque control without weighting factors for induction motor drives[J]. IEEE Transactions on Power Electronics, 2016, 31(2): 1381-1390. [13] Zhang Yongchang, Yang Haitao.Model predictive torque control of induction motor drives with optimal duty cycle control[J]. IEEE Transactions on Power Electronics, 2014, 29(12): 6593-6603. [14] Zhang Yongchang, Zhu Jianguo, Xu Wei.Predictive torque control of permanent magnet synchronous motor drive with reduced switching frequency[C]//2010 International Conference on Electrical Machines and Systems (ICEMS), Incheon, South Korea, 2010: 798-803. [15] Kouro S, Cortes P, Vargas R, et al.Model predictive control-a simple and powerful method to control power converters[J]. IEEE Transactions on Industrial Electronics, 2009, 56(6): 1826-1838. [16] 邓知先, 宋文胜, 曹梦华. 单相PWM整流器模型预测电流控制算法[J]. 中国电机工程学报, 2016, 36(11): 2996-3004. Deng Zhixian, Song Wensheng, Cao Menghua.A model predictive current control scheme for single-phase PWM rectifiers[J]. Proceedings of the CSEE, 2016, 36(11): 2996-3004. [17] 宋文胜, 邓知先. 单相PWM整流器定频模型预测功率控制算法[J]. 电机与控制学报, 2016, 20(4): 93-100. Song Wensheng, Deng Zhixian.Model predictive power control scheme for single-phase PWM rectifiers with constant switching frequency[J]. Electric Machines and Control, 2016, 20(4): 93-100. [18] Vargas R, Rodriguez J, Ammann U, et al.Predictive current control of an induction machine fed by a matrix converter with reactive power control[J]. IEEE Transactions on Industrial Electronics, 2008, 55(12): 4362-4371. [19] 马俊鹏, 宋文胜, 冯晓云. 单相三电平脉冲整流器模型预测直接功率控制[J]. 中国电机工程学报, 2016, 36(4): 1098-1105. Ma Junpeng, Song Wensheng, Feng Xiaoyun.A model predictive direct power control of single-phase three-level PWM rectifiers[J]. Proceedings of the CSEE, 2016, 36(4): 1098-1105. [20] Miranda H, Cortes P, Yuz J I, et al.Predictive torque control of induction machines based on state-space models[J]. IEEE Transactions on Industrial Electronics, 2009, 56(6): 1916-1924.
2018, Vol. 33 
