1. State Key Laboratory of Alternate Electrical Power System with Renewable Energy Sources North China Electric Power University Beijing 102206 China; 2. Beijing Key Laboratory of High Voltage & EMC North China Electric Power University Beijing 102206 China; 3. State Grid Qingdao Power Supply Company of Shandong Power Company Qingdao 266002 China
Abstract：Surface discharge in oil-paper insulation is a common defect in converter transformer. Because of the complex operation conditions in converter transformer, the occurrence likelihood of surface discharge increases. It is important to understand the phenomena and characteristics of surface discharge in oil-paper insulation for fault diagnosis of converter transformer. But the electric field in converter transformer is AC-DC combined electric field, which is quite different from AC voltage. So this article built an oil-paper insulation surface partial discharge detection platform under AC-DC combined voltage, and then analyzed the trend of partial discharge characteristics, at last divided the severity classification according to the characteristics of discharge and dissolved gas analysis (DGA). The diagnosis method under AC voltage has certain applicability under AC-DC combined voltage. These characteristics on partial discharge and DGA could be the foundations of fault diagnosis for converter transformer.
齐波, 魏振, 李成榕, 苑清, 高怡, 张晓涵. 交直流复合电场中油纸绝缘沿面放电现象及特征[J]. 电工技术学报, 2016, 31(10): 59-67.
Qi Bo, Wei Zhen, Li Chengrong, Yuan Qing, Gao Yi, Zhang Xiaohan. The Phenomena and Characteristics of Oil-Paper Insulation Surface Discharge Under AC and DC Voltage. Transactions of China Electrotechnical Society, 2016, 31(10): 59-67.
[1] 王瑞珍, 文凯成, 罗维. 葛洲坝换流变压器事故分析[J]. 变压器, 2000, 37(6): 33-35. Wang Ruizhen, Wen Kaicheng, Luo Wei. Analysis of failure occurring on a Gezhouba HVDC convertor transformer[J]. Transformer, 2000, 37(6): 33-35. [2] Wechesler K, Riccitiello M. Electric breakdown of a parallel solid and liquid dielectric system[J]. Transa- ctions on AIEE, 1961, 80(3): 365-369. [3] 中国南方电网超高压输电公司. 高压直流设备基础[M]. 北京: 中国电力出版社, 2011. [4] 周远翔, 孙清华, 李光范, 等. 空间电荷对油纸绝缘击穿和沿面闪络的影响[J]. 电工技术学报, 2011, 26(2): 27-33. Zhou Yuanxiang, Sun Qinghua, Li Guangfan, et al. Effects of space charge on breakdown and creeping discharge of oil-paper insulation[J]. Transactions of China Electrotechnical Society, 2011, 26(2): 27-33. [5] 中国南方电网超高压输电公司. 高压直流输电系统设备典型故障分析[M]. 北京: 中国电力出版社, 2009. [6] 周远翔, 姜鑫鑫, 陈维江, 等. 交直流复合电压下变压器油中电弧放电及产气特性[J]. 高电压技术, 2011, 37(7): 1584-1589. Zhou Yuanxiang, Jiang Xinxin, Chen Weijiang, et al. Arcing discharge and gas generation characteristics of transformer oil under combined AC and DC voltage[J]. High Voltage Engineering, 2011, 37(7): 1584-1589. [7] Yamada H, Sato T, Cooke C M. Measurement of time to flashover along dielectric surfaces in transformer oil using electro-optic coupling method[J]. IEEE Transactions on Electrical Insulation, 1988, 23(4): 757-764. [8] Ebisawa Y, Yamada S, Mori S, et al. DC creepage breakdown characteristics of oil-immersed insu- lation[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2009, 16(6): 1686-1692. [9] Kelley E F, Hebner R E. Electrical breakdown in composite insulating systems: liquid-solid interface parallel to the field[J]. IEEE Transactions on Electrical Insulation, 1981, 16(4): 297-303. [10] 司文荣, 李军浩, 袁鹏, 等. 直流下局部放电序列信号检测与特性分析[J]. 电工技术学报, 2010, 25(3): 164-171. Si Wenrong, Li Junhao, Yuan Peng, et al. Measure- ment and analysis for pulse sequence of partial discharge signals under DC voltage[J]. Transactions of China Electrotechnical Society, 2010, 25(3): 164- 171. [11] 孙振权, 赵学风, 李继胜, 等. 直流电压下油纸绝缘结构气隙模型的局部放电特性[J]. 电工技术学报, 2010, 25(9): 20-27. Sun Zhenquan, Zhao Xuefeng, Li Jisheng, et al. Characteristic of partial discharge in air gap model of oil-paper insulation under DC voltage[J]. Transactions of China Electrotechnical Society, 2010, 25(9): 20- 27. [12] 冉汉政, 吴广宁, 张血琴, 等. 膜纸复合储能电容器的直流局部放电信号分析方法[J]. 电工技术学报, 2006, 21(4): 46-49. Ran Hanzheng, Wu Guangning, Zhang Xueqin, et al. Study of DCPD analyzing method of energy-storage capacitors[J]. Transactions of China Electrotechnical Society, 2006, 21(4): 46-49. [13] 陈伟根, 蔚超, 凌云, 等. 油纸绝缘气隙放电特征信息提取及其过程划分[J]. 电工技术学报, 2011, 26(4): 7-12. Chen Weigen, Wei Chao, Ling Yun, et al. Feature information extraction of air-gap discharge in oil-paper insulation and its process partition[J]. Transactions of China Electrotechnical Society, 2011, 26(4): 7-12. [14] Raghuveer M R, Kolaczkowski Z. Surface electric strength of process board under AC and DC and conventional stresses[J]. IEEE Transactions on Elec- trical Insulation, 1990, 25(2): 341-350. [15] Ram S S T, Kamaraju V, Singh B P. Flashover behavior of converter transformer insulation sub- jected to superimposed AC and DC voltages[C]// Proceedings of IEEE Conference on Electrical Insulation and Dielectric Phenomena, Arlington, USA, 1994: 810-815. [16] 李博, 程涣超, 孙倩, 等. 交直流电压分量对变压器油中典型模型击穿特性影响[J]. 电工技术学报, 2011, 26(6): 34-38. Li Bo, Cheng Huanchao, Sun Qian, et al. Influences of AC and DC voltage component on typical insulation model breakdown characteristics in transformer oil[J]. Transactions of China Electro- technical Society, 2011, 26(6): 34-38. [17] 沙彦超, 周远翔, 孙清华, 等. 直流电压分量对交直流叠加电压下油纸绝缘沿面闪络的影响[J]. 高电压技术, 2013, 39(6): 1337-1343. Sha Yanchao, Zhou Yuanxiang, Sun Qinghua, et al. Influence of DC voltage on creepage flashover of oil-paper insulation under composite AC and DC voltage[J]. High Voltage Engineering, 2013, 39(6): 1337-1343. [18] 齐波, 魏振, 李成榕, 等. 交流与直流电压比例对油纸绝缘内部气隙放电特性影响分析[J]. 中国电机工程学报, 2015, 35(1): 247-254. Qi Bo, Wei Zhen, Li Chengrong, et al. Influences of ratios of AC and DC voltages on partial discharge characteristics of gas cavity in oil-pressboard insul- ation[J]. Proceedings of the CSEE, 2015, 35(1): 247-254. [19] IEC 60641 Specification for pressboard and press- paper for electrical purposes[S]. 2008. [20] IEC 60243 Electrical strength of insulating materials test methods[S]. 1998. [21] IEC 60270 High voltage test technique-partial dis- charge measurement[S]. 2000. [22] IEEE Work Group. Recommended dielectric tests and test procedures for converter transformers and smoothing[J]. IEEE Transactions on Power Delivery, 1986, 3(1): 161-166. [23] IEEE Std C57.129 ™ IEEE standard for general requirements and test code for oil-Immersed HVDC converter transformers[S]. 2008. [24] 齐波, 李成榕, 耿弼博, 等. GIS设备绝缘子高压电极故障局部放电严重程度的诊断与评估[J]. 高电压技术, 2011, 37(7): 1719-1727. Qi Bo, Li Chengrong, Geng Bibo, et al. Severity diagnosis and assessment of the partial discharge provoked by high-voltage electrode defect on gas insulator surface[J]. High Voltage Engineering, 2011, 37(7): 1719-1727. [25] Tang L C. Analysis of step-stress accelerated-life-test data: a new approach[J]. IEEE Transaction on Reliabi- lity, 1996, 45(1): 69-74. [26] 葛景涝, 邱昌容, 谢恒塑. 局部放电测量[M]. 北京:机械工业出版社, 1984. [27] 钱旭耀. 变压器油及相关故障诊断处理技术[M]. 北京: 中国电力出版社, 2006.
2016, Vol. 31 
