|
|
|
| A Buck-Flyback Single-Stage Power Factor Correction Converter for LED Driving Circuit with Primary-Side Control |
| Yan Tiesheng1, Li Minghong1, Zhou Guohua2, Tao Quanbao1, Cao Taiqiang1 |
1. School of Electrical Engineering and Electronic InformationXihua University Chengdu 610039 China;
2. School of Electrical Engineering Southwest Jiaotong University Chengdu 610031 China |
|
|
|
|
Abstract A Buck-Flyback single-stage power factor correction (PFC) converter for LED driving circuit with primary-side control is proposed in this paper. The operation principle of the main circuit and the principle of the primary-side constant current control strategy are analyzed. It consists of input Buck converter and output Flyback converter with single switch. The input Buck converter achieves PFC, and output Flyback converter controls LED current. Without the photocoupler and secondary current sensing circuit, the LED driving circuit with single switch and single controller can realize high power factor, high efficiency, low cost and flicker-free. Finally, a 36W experimental prototype was designed to verify the correctness of the theoretical analysis.
|
|
Received: 22 June 2018
Published: 02 September 2019
|
|
|
|
|
|
[1] 廖志凌, 阮新波. 半导体照明工程的现状与发展趋势[J]. 电工技术学报, 2006, 21(9): 106-111.
Liao Zhiling, Ruan Xinbo.Present status and developing trend of the semiconductor lighting[J]. Transactions of China Electrotechnical Society, 2006, 21(9): 106-111.
[2] 汪飞, 钟元旭, 阮毅. AC-DC LED驱动电源消除电解电容技术综述[J]. 电工技术学报, 2015, 30(8): 176-185.
Wang Fei, Zhong Yuanxu, Ruan Yi.A review of eliminating electrolytic capacitor in AC-DC light emitting diode drivers[J]. Transactions of China Electrotechnical Society, 2015, 30(8): 176-185.
[3] 汪飞, 钟元旭, 李林, 等. 基于集成三端口变换器的无电解电容LED驱动[J]. 电工技术学报, 2016, 31(23): 189-198.
Wang Fei, Zhong Yuanxu, Li Lin, et al.An electrolytic capacitor-less LED driver based on an integrated three-port converter[J]. Transactions of China Electrotechnical Society, 2016, 31(23): 189-198.
[4] Azevedo I L, Morgan M G, Morgan F.The transition to solid-state lighting[J]. Proceedings of the IEEE, 2009, 97(3): 481-510.
[5] International electrotechnical commission. IEC 61000-3-2 Electromagnetic compatibility, Part 3, Section 2. Limits for harmonic current emissions (equipment input current ≤16A per phase)[S]. Geneva, Switzerland: IEC, 2009-04.
[6] 张斐, 许建平, 阎铁生, 等. 具有宽负载范围和低电压应力的三态反激PFC变换器[J]. 电工技术学报, 2015, 30(3): 123-130.
Zhang Fei, Xu Jianping, Yan Tiesheng, et al.Tri-state PFC converter with wide load range and low voltage stress[J]. Transactions of China Electrotechnical Society, 2015, 30(3): 123-130.
[7] 王楠, 许建平, 刘雪山. 单开关Buck-Flyback功率因数校正变换器[J]. 中国电机工程学报, 2015, 35(3): 679-687.
Wang Nan, Xu Jianping, Liu Xueshan.A single- switch Buck-Flyback power factor correction converter[J]. Proceedings of the CSEE, 2015, 35(3): 679-687.
[8] Garcia O, Cobos J A, Prieto R, et al.Single phase power factor correction: a survey[J]. IEEE Transa- ctions on Power Electronics, 2003, 18(3): 749-755.
[9] Zhang Fei, Xu Jianping, Yang Ping, et al.Single- phase two-switch PCCM Buck-Boost PFC converter with fast dynamic response for universal input voltage[C]//IEEE International Conference on Power Electronics and Ecce Asia, Jeju, South Korea, 2011: 205-209.
[10] Zhang Junming, Zeng Hulong, Jiang Ting.A primary-side control scheme for high-power-factor LED driver with TRIAC dimming capability[J]. IEEE Transactions on Power Electronics, 2012, 27(11): 4619-4629.
[11] Singh B, Shrivastava A, Chandra A, et al.A single stage optocoupler-less Buck-Boost PFC driver for LED lamp at universal AC mains[C]//Industry Applications Society Meeting, Lake Buena Vista, FL, 2013: 1-6.
[12] Xu Yuzhen, Lin Weiming, Xu Yingchun, et al.Inductor optimize design for BCM Buck-PFC in LED driver[C]//International Conference on Electric Information and Control Engineering, Wuhan, China, 2011: 2264-2267.
[13] Diego G Lamar, Marcos Fernandez, Manuel Arias, et al.Tapped-inductor Buck HB-LED AC-DC driver operating in boundary conduction mode for replacing incandescent bulb lamps[J]. IEEE Transactions on Power Electronics, 2012, 27(10): 4329-4337.
[14] Xu Dehong, Zhang Jindong, Chen Weiyun, et al.Evaluation of output filter capacitor current ripples in single phase PFC converters[C]//Proceedings of the Power Conversion Conference, Osaka, Japan, 2002: 1226-1231.
[15] 阎铁生, 许建平, 曹太强, 等. 基于二次型Buck PFC变换器的无频闪无变压器LED驱动电源[J].电工技术学报, 2015, 30(12): 512-519.
Yan Tiesheng, Xu Jianping, Cao Taiqiang, et al.A flicker-free transformerless LED driving circuit based on quadratic Buck PFC converter[J]. Transa- ctions of China Electrotechnical Society, 2015, 30(12): 512-519.
[16] Luz P C V, Cosetin M R, Bolzan P E, et al. An integrated insulated Buck-Flyback converter to feed LED's lamps to street lighting with reduced capacitances[C]//IEEE International Conference on Industrial Technology, Seville, Spcun, 2015: 908-913.
[17] Zhang Bong, Xu Yang, Xu Ming, et al.Design of Boost-Flyback single-stage PFC converter for LED power supply without electrolytic capacitor for energy-storage[C]//Power Electronics and Motion Control Conference, Wuhan, China, 2009: 1668-1671.
[18] Gacio D, Alonso J M, Calleja A J, et al.A universal-input single-stage high-power-factor power supply for HB-LEDs based on integrated Buck- Flyback converter[J]. IEEE Transactions on Power Electronics, 2011, 58(2): 589-599.
[19] Wang Yuanyuan, Li Duo, Zhang Ya, et al.Square component injection to improve current distortion of CRM Flyback APFCs with wide input voltage and variable load[C]//Applied Power Electronics Con- ference and Exposition, Tort Worth, TX, 2011: 1362-1366.
[20] He Junpeng, Xu Jianping, Yan Tiesheng.Peak current-controlled CRM flyback PFC converter with square of line voltage-compensated primary current envelope[J]. Electronics Letters, 2015, 51(9): 684-686. |
|
|
|
2019, Vol. 34 
