柔直换流阀用相变冷却工质击穿特性研究

doi:10.19595/j.cnki.1000-6753.tces.221967

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2532 KB)
输出: BibTeX | EndNote (RIS)

摘要

相变冷却技术冷却效率高、安全可靠,有望攻克柔直换流阀散热瓶颈,实现其高压、大容量发展,在换流阀冷却领域具有良好的应用前景。为实现相变冷却换流阀绝缘系统可靠设计,该文设计研制了三相态相变冷却工质可调频绝缘特性测试专用平台,并以换流阀用相变冷却工质为研究对象,依据换流阀典型运行工况,利用专用测试平台开展了相变冷却工质三相态、50~300 Hz频率范围的绝缘击穿特性研究。得到了相变冷却工质击穿特性随工质相态及电压频率的变化规律,分析了相变冷却工质不同相态的击穿机理,揭示了工质相态和电压频率变化对冷却工质击穿特性的影响机制。研究工作不仅解决了高频下相变冷却工质的三相态耐压测试方法问题,且所得研究成果为相变冷却柔直换流阀的绝缘设计奠定了基础,同时可指导相变冷却技术在其他电力电子装备上的应用。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	温英科
	阮琳

关键词 ：换流阀, 柔性直流输电, 相变冷却, 击穿特性, 高频绝缘

Abstract：

High voltage and large capacity is the development trend of flexible HVDC transmission technology. The reliability problem caused by overheating of IGBT converter valve limits the improvement of system capacity. The cooling capacity of the water cooling system is limited, and there are also hidden dangers such as blockage and leakage. It is of great significance to develop a safe and efficient new cooling technology for the converter valve. Phase change cooling technology has high cooling efficiency and reliability. It is expected to overcome the heat dissipation bottleneck of flexible HVDC converter valve and has a good application prospect in the field of converter valve cooling.
In order to design the insulation system of the phase change cooling converter valve, it is necessary to study the insulation breakdown characteristics of phase change coolant. The existing researches on the breakdown characteristics of phase change coolant are almost carried out at power frequency, but the operation frequencies of converter valves are usually higher than power frequency, so the existing researches are not enough to guide the practical engineering application. In order to solve this problem, this paper firstly developed a frequency-adjustable insulation characteristics test platform for phase change coolant. The platform could realize the adjustment of the output voltage frequency, at the same time, the test chamber has sealing and visualization characteristics, which can meet the triphase state test requirements of phase change coolant. Considering the typical operating conditions of the converter valve, the insulation breakdown characteristics of the phase change coolant at different phase states, within 50Hz~300Hz were tested by using the platform. The change rules of the breakdown characteristics of phase change coolant with different phase states and voltage frequencies were obtained, the breakdown mechanism of phase change coolant at different phase states was analyzed, and the influence mechanism of phase state and frequency on the breakdown characteristics of phase change coolant was revealed.
The following conclusions can be drawn from the study: (1)Under different frequencies, the change rule of the breakdown characteristics of the coolant with phase state is consistent: The average breakdown voltage of the liquid coolant is basically stable. The average breakdown voltage of gas-liquid coolant gradually decreases with the increase of heat flux, and finally approaches the value of gas coolant. The average value and data dispersion of gas phase breakdown voltage are the minimum. The breakdown voltage of liquid coolant and gas coolant obeys the Weibull distribution, while the breakdown voltage of gas-liquid coolant doesn’t. (2)With the increase of frequency, the average value and dispersion of breakdown voltages of liquid coolant and gas coolant decrease, and the gas phase breakdown voltage is more affected by frequency. The breakdown voltage of gas-liquid coolant shows different frequency dependence under different heat flux. When the heat flux is small or large, the average breakdown voltage of gas-liquid coolant decreases with the increase of frequency, however when the heat flux is during the middle transition zone, the average breakdown voltage of gas-liquid coolant increases first and then decreases with the increase of frequency. (3)The breakdown of coolant is caused by the collision ionization between charged particles and neutral molecules. The breakdown probability can be improved by increasing the number of charged particles, the free path of charged particles and the electric field strength. (4)The gas phase insulation performance of the phase change coolant studied in this paper is superior to SF₆ and equivalent to transformer oil. In order to ensure the reliability of the phase change cooling converter valve, the main basis for the selection of coolant and the insulation design shall be the dielectric strength of gas coolant at the high operation frequency point of the converter valve.
The research not only solves the problem of triphase state insulation test method of phase change coolant at high frequency, but also lays a foundation for the insulation design of phase change cooling flexible HVDC converter valve.

Key words： Converter valve flexible HVDC transmission phase change cooling breakdown characteristics high frequency insulation

收稿日期: 2022-10-14

PACS:	TM46
	TM85

基金资助:

国家自然科学基金资助项目（51777201）

通讯作者: 阮琳女,1976年生,研究员,博士生导师,研究方向为电气装备与电子信息设备相变冷却技术的研究与装备研制。E-mail：rosaline@mail.iee.ac.cn

作者简介: 温英科女,1988年生,助理研究员,研究方向为相变冷却技术在电力电子装备领域的基础及应用研究。E-mail：wenyingke@mail.iee.ac.cn

引用本文:

温英科, 阮琳. 柔直换流阀用相变冷却工质击穿特性研究[J]. 电工技术学报, 0, (): 239602-239602. Wen Yingke, Ruan Lin. Breakdown Characteristics of Phase Change Coolant for Flexible HVDC Converter Valves. Transactions of China Electrotechnical Society, 0, (): 239602-239602.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.221967 https://dgjsxb.ces-transaction.com/CN/Y0/V/I/239602

[1] 马为民, 吴方劼, 杨一鸣, 等. 柔性直流输电技术的现状及应用前景分析[J]. 高电压技术, 2014, 40(8): 2429-2439.
Ma Weimin, Wu Fangjie, Yang Yiming, et al.Flexible HVDC transmission technology’s today and tomorrow[J]. High Voltage Engineering, 2014, 40(8): 2429-2439.
[2] 曾建兴. 柔性直流输电换流阀冷却系统研究[J]. 自动化应用, 2014(12): 89-91.
Zeng Jianxing.Study on cooling system of converter valve of HVDC-flexible[J]. Automation Application, 2014(12): 89-91.
[3] 魏云海, 陈民铀, 赖伟, 等. 基于IGBT结温波动平滑控制的主动热管理方法综述[J]. 电工技术学报, 2022, 37(6): 1415-1430.
Wei Yunhai, Chen Minyou, Lai Wei, et al.Review on active thermal control methods based on junction temperature swing smooth control of IGBTs[J]. Transactions of China Electrotechnical Society, 2022, 37(6): 1415-1430.
[4] 中国南方电网公司超高压输电公司. 高压直流输电换流阀冷却系统[M]. 北京: 中国电力出版社, 2017.
[5] 刘德庆, 何潇, 郭新良, 等. 换流阀水冷系统故障统计及原因分析[J]. 山东化工, 2019, 48(6): 139-141, 144.
Liu Deqing, He Xiao, Guo Xinliang, et al.Failure statistics and cause analysis of water-cooling system of converter valve[J]. Shandong Chemical Industry, 2019, 48(6): 139-141, 144.
[6] 顾国彪, 阮琳, 刘斐辉, 等. 蒸发冷却技术的发展、应用和展望[J]. 电工技术学报, 2015, 30(11): 1-6.
Gu Guobiao, Ruan Lin, Liu Feihui, et al.Developments, applications and prospects of evaporative cooling technology[J]. Transactions of China Electrotechnical Society, 2015, 30(11): 1-6.
[7] 顾国彪, 阮琳. 蒸发冷却技术在水轮发电机领域的应用和发展[J]. 中国电机工程学报, 2014, 34(29): 5112-5119.
Gu Guobiao, Ruan Lin.Applications and developments of the evaporative cooling technology in the field of hydrogenerators[J]. Proceedings of the CSEE, 2014, 34(29): 5112-5119.
[8] 国建鸿, 顾国彪, 傅德平, 等. 330MW蒸发冷却汽轮发电机冷却技术的特点及性能[J]. 电工技术学报, 2013, 28(3): 134-139.
Guo Jianhong, Gu Guobiao, Fu Deping, et al.Cooling characteristics and performance of the 330MW evaporative cooling turbo generator[J]. Transactions of China Electrotechnical Society, 2013, 28(3): 134-139.
[9] 郭卉, 宋福川, 袁佳毅, 等. 蒸发冷却电磁除铁器的研究[J]. 中国电机工程学报, 2006, 26(11): 60-64.
Guo Hui, Song Fuchuan, Yuan Jiayi, et al.The research of the evaporative cooling electromagnetic iron-separator[J]. Proceedings of the CSEE, 2006, 26(11): 60-64.
[10] Xiong Bin, Ruan Lin, Gu Guobiao, et al. Application of evaporative cooling technology in super-high power density magnet[J]. Review of Scientific Instruments, 2014, 85(2): 02A913.
[11] 阮琳, 曹瑞, 闫静. 高性能计算机多支路并联表贴自循环蒸发冷却系统运行特性分析[J]. 工程热物理学报, 2021, 42(8): 2040-2047.
Ruan Lin, Cao Rui, Yan Jing.Analysis on the operation characteristics of multi-branch parallel surface mounted self-circulation evaporative cooling system for high performance computer[J]. Journal of Engineering Thermophysics, 2021, 42(8): 2040-2047.
[12] 温英科, 阮琳. 全浸式蒸发冷却开关电源热分析及实验[J]. 电工技术学报, 2018, 33(18): 4295-4304.
Wen Yingke, Ruan Lin.Thermal analysis and experimental study of fully-immersed evaporative cooling switching mode power supply[J]. Transactions of China Electrotechnical Society, 2018, 33(18): 4295-4304.
[13] 温英科, 阮琳. 全浸式液汽相变冷却方式贴片电阻失效机理[J]. 电工技术学报, 2019, 34(24): 5144-5150.
Wen Yingke, Ruan Lin.Failure mechanism of film resistors under fully-immersed liquid-vapor phase change cooling technology[J]. Transactions of China Electrotechnical Society, 2019, 34(24): 5144-5150.
[14] 曹瑞, 阮琳, 闫静, 等. 换流阀蒸发冷却系统关键部件的设计研究[J]. 工程热物理学报, 2019, 40(10): 2373-2376.
Cao Rui, Ruan Lin, Yan Jing, et al.Study on key components of evaporative cooling system of converter valve[J]. Journal of Engineering Thermophysics, 2019, 40(10): 2373-2376.
[15] 张玉斌, 温英科, 阮琳. 全浸式蒸发冷却IGBT电热耦合模型研究[J]. 电工技术学报, 2022, 37(15): 3845-3856.
Zhang Yubin, Wen Yingke, Ruan Lin.Research on electrothermal coupling model of fully-immersed evaporative cooling IGBT[J]. Transactions of China Electrotechnical Society, 2022, 37(15): 3845-3856.
[16] 史一涛, 曹瑞, 阮琳. 方形肋阵参数变化对流动沸腾换热影响的实验研究[J]. 电工技术学报, 2022, 37(5): 1275-1284.
Shi Yitao, Cao Rui, Ruan Lin.Experimental study on the influence of parameter change of square rib on flow boiling heat transfer[J]. Transactions of China Electrotechnical Society, 2022, 37(5): 1275-1284.
[17] 唐炬. 高电压工程基础[M]. 2版. 北京: 中国电力出版社, 2018.
[18] 牛文豪, 张国强, 王新, 等. 蒸发冷却介质两相流状态下工频击穿特性的实验研究[J]. 电工电能新技术, 2009, 28(1): 66-70, 80.
Niu Wenhao, Zhang Guoqiang, Wang Xin, et al.Experimental research of AC breakdown voltage of evaporative coolant under boiled two-phase-flow condition[J]. Advanced Technology of Electrical Engineering and Energy, 2009, 28(1): 66-70, 80.
[19] 牛文豪, 张国强, 林涛, 等. 氟碳介质热致气液两相流的工频击穿特性及其在GIL中的应用展望[J]. 高电压技术, 2017, 43(3): 743-753.
Niu Wenhao, Zhang Guoqiang, Lin Tao, et al.AC breakdown initiated by thermally induced bubble of nonflammable fluorocarbon and its application prospect in GIL[J]. High Voltage Engineering, 2017, 43(3): 743-753.
[20] Niu Wenhao, Zhang Guoqiang, Lin Tao, et al.AC insulation property of fluorocarbon in thermal induced two-phase flow by self-heating electrode[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(1): 61-72.
[21] Mo Shenyang, Li Xuebao, Zhao Zhibin, et al.Effect of bubble flow on partial discharge under non-uniform AC electric fields in FC-72[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2020, 27(4): 1059-1067.
[22] Mo Shenyang, Zhao Zhibin, Li Xuebao, et al.Partial discharge characteristics of bubble flow under AC non-uniform electric field in FC-72[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2020, 27(4): 1119-1127.
[23] 莫申扬, 张金强, 李学宝, 等. FC-72介质液态、气态及两相态工频击穿特性研究[J]. 高压电器, 2021, 57(5): 77-83, 92.
Mo Shenyang, Zhang Jinqiang, Li Xuebao, et al.Study on power frequency breakdown characteristic of FC-72 medium in liquid, gaseous and two-phase state[J]. High Voltage Apparatus, 2021, 57(5): 77-83, 92.
[24] 赵聪. 采用不同子模块拓扑的柔性高压直流输电换流器特性分析与控制策略研究[D]. 北京: 中国科学院大学, 2017.
[25] 国家质量监督检验检疫总局, 中国国家标准化管理委员会. 电气绝缘击穿数据统计分析导则: GB/T 29310—2012[S]. 北京: 中国标准出版社, 2013.