3×3相永磁辅助同步磁阻电机两相开路故障容错控制策略

doi:10.19595/j.cnki.1000-6753.tces.210166

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2691 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要

单逆变器驱动的3×3相永磁辅助同步磁阻电机系统具有低成本、高可靠性的优点。该文针对此系统的两相开路故障,提出一种各模块转矩重新分配的容错控制策略。当同一模块发生两相开路故障时,将该故障模块完全切除,通过增加非故障模块的电流来实现容错运行。对于不同模块同相位两相开路,通过分析故障后各模块的等效电路,获得两相静止坐标系下电流之间的关系,然后构造拉格朗日函数,以铜耗最小为目标,求解电流幅值的最优解,最终实现转矩的重新分配。当发生不同相位两相开路时,以故障模块输出最大平均转矩以及总的转矩脉动最小为目标,对各模块转矩进行重新分配。该方法通过增加正常模块转矩脉动来部分抵消故障模块产生的脉动,达到抑制输出转矩脉动的目的。实验结果验证了所提容错控制策略能有效降低故障后电机的转矩脉动,提高了控制系统的可靠性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	赵美玲
	刘国海
	陈前
	赵文祥
	朱旭辉

关键词 ： 3×3相永磁辅助同步磁阻电机, 单逆变器, 容错控制, 开路故障, 转矩分配

Abstract：

The 3×3-phase permanent magnet assisted synchronous reluctance motor (PMa- SynRM) driven by the mono-inverter has the advantages of low cost and high reliability. Besides, a fault-tolerant control strategy for torque redistribution of each module is proposed for the two-phase open-circuit fault of the control system. When the two-phase open-circuit fault occurs in the same module, the faulty module is completely removed, and the fault-tolerant operation is realized by increasing the current amplitude of the non-fault module. For the phase-aligned two-phase open circuit of different modules, the relationship between the currents in the static coordinate system can be obtained by analyzing the equivalent circuit of each module after the fault. Then, the Lagrange function is constructed to solve the optimal solution of the current amplitude with the minimum copper loss as the objective, and finally the torque redistribution is realized. When two-phase open circuit occurs in different phases, it is necessary to take the maximum average torque output of the faulty module and the minimum output torque pulsation as targets to redistribute the torque of each module. By this method, the torque ripple of the non-fault module will be increased to partially offset the ripple generated by the fault module, so as to suppress the output torque ripple. The experimental results verify that the proposed fault-tolerant control strategy can effectively reduce the torque ripple and improve the reliability of the control system.

Key words： 3×3 phase permanent magnet assisted synchronous reluctance motor mono-inverter fault-tolerant control open-circuit fault torque redistribution

收稿日期: 2021-02-01

PACS:

TM351

基金资助:

国家自然科学基金（51877098, 52077097）和江苏省高校优势学科项目资助

通讯作者: 刘国海男,1964年生,教授,博士生导师,研究方向为电动机系统及其控制,包括电气传动自动化、复杂过程的智能控制等。E-mail: ghliu@ujs.edu.cn

作者简介: 赵美玲女,1992年生,博士研究生,研究方向为多相电机控制。E-mail: 2111907003@stmail.ujs.edu.cn

引用本文:

赵美玲, 刘国海, 陈前, 赵文祥, 朱旭辉. 3×3相永磁辅助同步磁阻电机两相开路故障容错控制策略[J]. 电工技术学报, 2022, 37(14): 3566-3575. Zhao Meiling, Liu Guohai, Chen Qian, Zhao Wenxiang, Zhu Xuhui. Fault-Tolerant Control Strategy for 3×3 Phase Permanent Magnet Assisted Synchronous Reluctance Motor with Two-Phase Failure. Transactions of China Electrotechnical Society, 2022, 37(14): 3566-3575.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.210166 https://dgjsxb.ces-transaction.com/CN/Y2022/V37/I14/3566

[1] 杨晨, 白保东, 陈德志, 等. 可变磁通永磁辅助同步磁阻电机设计与性能分析[J]. 电工技术学报, 2019, 34(3): 489-496.
Yang Chen, Bai Baodong, Chen Dezhi, et al.Design and analysis of a variable flux permanent magnet assisted synchronous motor[J]. Transactions of China Electrotechnical Society, 2019, 34(3): 489-496.
[2] Arafat K M, Choi S.Active current harmonic suppression for torque ripple minimization at open-phase faults in a five-phase PMa-SynRM[J]. IEEE Transactions on Industrial Electronics, 2019, 66(2): 922-931.
[3] Tap A, Xheladini L, Yilmaz M, et al.Comprehensive design and analysis of a PMaSynRM for washing machine applications[J]. IET Electric Power Appli-cations, 2018, 12(9): 1311-1319.
[4] Gradev S, Herzog H.Integration of iron-loss resistance into dynamic models of 2×3-phase hybrid-excited synchronous machine[J]. IEEE Transactions on Energy Conversion, 2018, 33(4): 1700-1711.
[5] Janous S, Talla J, Smidl V, et al.Constrained LQR control of dual induction motor single inverter drive[J]. IEEE Transactions on Industrial Electronics, 2021, 68(7): 5548-5558.
[6] Liu Tianyi, Maurice F.An efficiency-optimal control method for mono-inverter dual-PMSM systems[J]. IEEE Transactions on Industry Applications, 2018, 54(2): 1737-1745.
[7] 孙德博, 胡艳芳, 牛峰, 等. 开关磁阻电机调速系统故障诊断和容错控制方法研究现状及展望[J]. 电工技术学报, 2022, 37(9): 2211-2229.
Sun Debo, Hu Yanfang, Niu Feng, et al.Status and prospect of fault diagnosis and tolerant control methods[J]. Transactions of China Electrotechnical Society, 2022, 37(9): 2211-2229.
[8] 张业成, 刘国海, 陈前. 基于电流波动特征的永磁同步电机匝间短路与局部退磁故障分类诊断研究[J]. 电工技术学报, 2022, 37(7): 1634-1643, 1653.
Zhang Yecheng, Liu Guohai, Chen Qian.Dis-crimination of interturn short-circuit and local demag-netization in permanent magnet synchronous motor based on current fluctuation characteristics[J]. Transactions of China Electrotechnical Society, 2022, 37(7): 1634-1643, 1653.
[9] 谢颖, 胡圣明, 陈鹏, 等. 永磁同步电机匝间短路故障温度场分析[J]. 电工技术学报, 2022, 37(2): 322-331.
Xie Ying, Hu Shengming, Chen Peng, et al.Thermal field analysis on inter-turn short circuit fault of permanent magnet synchronous motor[J]. Transa-ctions of China Electrotechnical Society, 2022, 37(2): 322-331.
[10] 王栋悦, 谷怀广, 魏书荣, 等. 基于机电信号融合的DFIG定子绕组匝间短路故障诊断[J]. 电力系统自动化, 2020, 44(9): 171-178.
Wang Dongyue, Gu Huaiguang, Wei Shurong, et al.Diagnosis of inter-turn short-circuit fault in stator windings of DFIG based on mechanical and electrical signal fusion[J]. Automation of Electric Power System, 2020, 44(9): 171-178.
[11] Zhang Zeliang, Luo Guangzhao, Zhang Zhengbin, et al.A hybrid diagnosis method for inverter open-circuit faults in PMSM drives[J]. CES Transactions on Electrical Machines and Systems, 2020, 4(3): 180-189.
[12] Welchko B A, Jahns T M, Hiti S.IPM synchronous machine drive response to a single-phase open circuit fault[J]. IEEE Transactions on Power Electronics, 2002, 17(5): 764-771.
[13] Cheng Ming, Jun Hang, Zhang Jianzhong.Overview of fault diagnosis theory and method for permanent magnet machine[J]. Chinese Journal of Electrical Engineering, 2015, 1(1): 21-36.
[14] 范舒婷, 孟大伟, 艾萌萌. 不同定子绕组结构五相感应电机开路故障时性能对比分析[J]. 电工技术学报, 2022, 37(7): 1679-1688.
Fan Shuting, Meng Dawei, Ai Mengmeng.Com-parison and analysis of the performance of five-phase induction motors with different stator winding connections under open-circuit conditions[J]. Transa-ctions of China Electrotechnical Society, 2022, 37(7): 1679-1688.
[15] 赵文祥, 张步峰, 吉敬华, 等. 降低铜耗的容错式磁通切换永磁电机容错控制算法[J]. 农业工程学报, 2015, 31(17): 228-234.
Zhao Wenxiang, Zhang Bufeng, Ji Jinghua, et al.Copper loss-minimized remedial control algorithm of fault-tolerant flux-switching permanent-magnet motor[J]. Transactions of the Chinese Society of Agricultural Engineering, 2015, 31(17): 228-234.
[16] 吴一丰, 邓智泉, 王宇, 等. 六相永磁容错磁通切换电机及其单相故障的容错控制[J]. 电工技术学报, 2013, 28(3): 71-79, 106.
Wu Yifeng, Deng Zhiquan, Wang Yu, et al.Six-phase fault-tolerant flux switching permanent magnet motor and control strategy for single-phase fault con-dition[J]. Transactions of China Electrotechnical Society, 2013, 28(3): 71-79, 106.
[17] 王永兴, 温旭辉, 赵峰. 六相永磁同步电机缺相容错控制[J]. 电工技术学报, 2015, 30(5): 49-58.
Wang Yongxing, Wen Xuhui, Zhao Feng.The fault-tolerant control for six-phase permanent magnet synchronous machines with one phase failure[J]. Transactions of China Electrotechnical Society, 2015, 30(5): 49-58.
[18] 刘国海, 宋成炎, 徐亮, 等. 基于SVPWM的五相永磁同步电机两相开路故障容错控制策略[J]. 电工技术学报, 2019, 34(1): 23-32.
Liu Guohai, Song Chengyan, Xu Liang, et al.SVPWM-based fault-tolerant control strategy under two-phase open-circuit fault of five-phase permanent-magnet synchronous motor[J]. Proceedings of the CSEE, 2019, 34(1): 23-32.
[19] Wang Bo, Wang Jiabin, Griffo A, et al.Experi-mental assessments of a triple redundant nine-phase fault-tolerant PMA SynRM drive[J]. IEEE Transa-ctions on Industrial Electronics, 2019, 66(1): 772-783.
[20] Shamsi-Nejad M, Nahid-Mobarakeh B, Pierfederici S, et al.Fault tolerant and minimum loss control of double-star synchronous machines under open phase conditions[J]. IEEE Transactions on Industrial Elec-tronics, 2008, 55(5): 1956-1965.
[21] Zheng Wang, Chen Jian, Cheng Ming, et al.Fault-tolerant control of paralleled-voltage-source-inverter-fed PMSM drives[J]. IEEE Transactions on Industrial Electronics, 2015, 62(8): 4749-4760.
[22] 徐媚媚, 刘国海, 陈前, 等. 永磁辅助同步磁阻电机设计及其关键技术发展综述[J]. 中国电机工程学报, 2019, 39(23): 7033-7043, 7116.
Xu Meimei, Liu Guohai, Chen Qian, et al.Design and key technology development of permanent magnet assisted synchronous reluctance motor[J]. Proceedings of the CSEE, 2019, 39(23): 7033-7043, 7116.
[23] Xu Meimei, Liu Guohai, Chen Qian, et al.Design and optimization of a fault tolerant modular PMaSynRM with torque ripple minimization[J]. IEEE Transa-ctions on Industrial Electronics, 2021, 68(9): 8519-8530.
[24] Gradev S, Reuss J, Herzog H.A general voltage-behind-reactance formulation of a multivoltage n×3-phase hybrid-excited synchronous machine[J]. IEEE Transactions on Energy Conversion, 2016, 31(4): 1452-1461.