带耦合电容型桥式ZVS直流-直流变换器

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (44839 KB)
输出: BibTeX | EndNote (RIS)

摘要提出一种零电压开通（ZVS）的直流-直流变换器。在一种桥式开关管结构的基础上,通过在串接的两个变压器一次绕组两端并联一个耦合电容C_b,为电路的正常工作构造两个一次绕组共同导通的条件,使得两个绕组能够实现均流。变流器采用移相控制技术,不含输出侧滤波电感,而是利用变压器漏感传递能量,使得四个开关管都能获得宽负载范围的ZVS。二次侧采用开关电容倍压技术,提高了输出电压增益。详细分析了变换器各阶段工作原理、电压增益特性、ZVS实现条件以及C_b的设计。制作了一台开关频率50kHz、负载600W、42V输入/250V输出的实验样机,该样机在轻载下就能达到92%以上的效率,实验波形验证了理论分析的正确性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：直流-直流变换器, 零电压开通, 移相控制, 倍压技术

Abstract：A zero-voltage-switching (ZVS) DC-DC converter is proposed. Based on a bridge-type constructer, a coupling capacitance C_b is added in parallel with two series-connecting primary windings. Thus the synchronous operation of the two primary windings and current-sharing can be realized. The phase-shifting PWM method is adopted in this converter, and four power switches can achieve ZVS in a wide load range. This converter neglects the output filter inductor, and only utilizes the leakage inductance of the transformer to transfer energy. The switching-capacitor voltage-double technique is adopted at the secondary side, to improve the voltage gain. The operation theory in each stage is analyzed in detail. Some key characteristics, including voltage gain, ZVS condition and C_b selection, are also explained. One prototype is tested, with 50kHz switching frequency, 600W rated load, 42V input voltage and 250V output voltage. The efficiency can reach to 92.5% under 70W, and the test waveforms verify the theory analysis.

Key words： DC-DC converter zero voltage switching phase-shifting control voltage-doubling technique

收稿日期: 2013-08-05 出版日期: 2015-11-30

PACS:

TM46

基金资助:国家自然科学基金（51467005）和江西省自然科学基金（20142BAB206025）资助项目

作者简介: 袁义生男,1974年生,博士,副教授,研究方向为电力电子系统及控制技术。胡盼安男,1989年生,硕士研究生,研究方向为电力电子及电力传动。

引用本文:

袁义生, 胡盼安, 罗峰. 带耦合电容型桥式ZVS直流-直流变换器[J]. 电工技术学报, 2015, 30(22): 80-88. Yuan Yisheng, Hu Pan’an, Luo Feng. A Zero Voltage Switching Bridge-Type DC-DC Converter with a Coupling-Capacitance. Transactions of China Electrotechnical Society, 2015, 30(22): 80-88.

链接本文:

https://dgjsxb.ces-transaction.com/CN/Y2015/V30/I22/80

[1] Boonyaroonate, Mori S. A new ZVCS resonant push-
pull DC/DC converter topology[C]. IEEE Annual Applied Power Electronics Conference and Exposition, Dallas, USA, 2002: 1097-1100.
[2] Ryan M J, Brumsickle W E, Divan D M, et al. A new ZVS LCL-resonant push-pull DC-DC converter topology[J]. IEEE Transactions on Industry Applications, 1998, 34(5): 1164-1174.
[3] 马皓, 俞宏霞, 严颖怡. 电流源型LCL谐振式变换器的研究[J]. 中国电机工程学报, 2009, 29(9): 28-34.
Ma Hao, Yu Hongxia, Yan Yingyi. Investigation on LCL resonant converter as current source[J]. Proceedings of the CSEE, 2009, 29(9): 28-34.
[4] 袁义生, 龚昌为. 一种谐振型推挽式直流变换器的研究[J]. 电力自动化设备, 2012, 32(10): 83-87.
Yuan Yisheng, Gong Changwei. Resonant push-pull DC-DC converter[J]. Electric Power Automation Equipment, 2012, 32(10): 83-87.
[5] Yuan Yisheng, Chen Ming, Qian Zhaoming. A parallel front-end LCL resonant push-pull converter with a coupled inductor for automotive applications[C]. IEEE Annual Applied Power Electronics Conference and Exposition, USA, 2010: 1460-1463.
[6] 陈威, 吕征宇. 新颖软开关推挽LLC谐振变流器及其拓扑延拓[J]. 浙江大学学报(工学版), 2012, 44(8): 1540-1547.
Chen Wei, Lü Zhengyu. Novel soft-switching push-pull type LLC resonant converter and its topology investigation[J]. Journal of Zhejiang University (Engineering Science), 2012, 44(8): 1540-1547.
[7] Wu T F, Hung J C, Tsai J T, et al. An active-clamp push-pull converter for battery sourcing applications[J]. IEEE Transactions on Industrial Applications, 2008, 44(1): 196-204.
[8] Patwardhan A A, Deo M S, Mangal M. 18 kW DC-DC converter using push-pull inverter with lossless snubber circuits[C]. Proceedings of International Conference on Power Electronics, Drives and Energy Systems for Industrial Growth, New Delhi, India, 1996: 789-793.
[9] Lim T C, Williams B W, Finney S J, et al. Energy recovery snubber circuit for a DC/DC push-pull converter[J]. IET Power Electronics, 2012, 5(6): 863-
872.
[10] 马运东, 周林泉, 阮新波, 等. 零电压开关脉宽调制推挽三电平变换器[J]. 中国电机工程学报, 2006, 26(23): 36-41.
Ma Yundong, Zhou Linquan, Ruan Xingbo, et al. Zero-voltage-switching PWM push-pull three-level converter[J]. Proceedings of the CSEE, 2006, 26(23): 36-41.
[11] 袁义生, 伍群芳. ZVS三管推挽直流变换器[J]. 中国电机工程学报, 2012, 32(33): 23-30.
Yuan Yisheng, Wu Qunfang. ZVS three-transistor push-pull DC/DC converter[J]. Proceedings of the CSEE, 32(33): 23-30.
[12] 袁义生, 伍群芳. 并联LC网络的软开关三管推挽式直流变换器[J]. 中国电机工程学报, 2013, 33(24): 42-51.
Yuan Yisheng, Wu Qunfang. A soft-switching three-
13 transistor push-pull DC/DC converter with LC net in parallel[J]. Proceedings of the CSEE, 2013, 33(24): 42-51.
[13] Yuan Yisheng, Wu Qunfang. One zero-voltage-
switching three-transistor push-pull converter[J]. IET Power Electronics, 2013, (7): 1270-1278.
[14] Chen W, Lee F C, Jowanovic M M, et al. A comparative study of a class of full bridge zero-
voltage-switched PWM converter[C]. IEEE Annual Applied Power Electronics Conference and Exposition, 1995: 893-895.
[15] 胡育文, 丁志刚, 游志青. 变压器副边电流钳位DC/DC ZVS全桥变换器[J]. 中国电机工程学报, 2003, 23(12): 153-159.
Hu Yuwen, Ding Zhigang, You Zhiqing. A novel ZVS full-bridge DC/DC converter employing current clamping in the secondary side of transformer[J]. Proceedings of the CSEE, 2003, 23(12): 153-159.
[16] 朱选才, 徐德鸿, Hidetoshi Umida, 等. 应用逆阻型IGBT的移相控制电流型全桥零电流开关DC/DC变换器[J]. 中国电机工程学报, 2006, 26(12): 45-49.
Zhu Xuancai, Xu Dehong, Hidetoshi Umida, et al. Current-fed phase shift controlled full bridge ZCS DC/DC converter with reverse block IGBT[J]. Pro-
17 ceedings of the CSEE, 2006, 26(12): 45-49.
[17] 陈仲, 张鑫, 季飚, 等. 一种基于变压器串联和新型辅助网络的ZVS移相全桥变换器[J]. 电工技术学报, 2009, 24(12): 95-101.
Chen Zhong, Zhang Xin, Ji Biao, et al. A ZVS phase-shifted full-bridge converter with series-
18 connection of transformer and auxiliary network[J]. Transactions of China Electrotechnical Society, 2009, 24(12): 95-101.
[18] 陈仲, 石磊, 季飚, 等. 带辅助网络的倍流整流方式全桥ZVS变换器[J]. 中国电机工程学报, 2010, 30(30): 32-37.
Chen Zhong, Shi Lei, Ji Biao, et al. Current double rectifier zero voltage switching full bridge converter with auxiliary network[J]. Proceedings of the CSEE, 2010, 30(30): 32-37.
[19] 石磊, 朱忠尼, 鞠志忠, 等. 一种新型能量交换式移相全桥电路[J]. 中国电机工程学报, 2008, 28(12): 112-118.
Shi Lei, Zhu Zhongni, Ju Zhizhong, et al. A novel topology of energy exchanging pattern PS-FB circuit[J]. Proceedings of the CSEE, 2008, 28(12): 112-118.
[20] 欧阳茜, 吴国良, 钱照明. LLC谐振全桥DC/DC变流器的优化设计[J]. 电力电子技术, 2007, 41(1): 15-17.
Ouyang Qian, Wu Guoliang, Qian Zhaoming. Optimal design considerations of the LLC resonant full-bridge DC/DC converter[J]. Power Electrionics, 2007, 41(1): 15-17.
[21] 赵晨, 石洋, 吴新科, 等. 三元件串联LLC谐振变流器的优化设计策略[J]. 电工技术学报, 2008, 23(1): 65-71.
Zhao Chen, Shi Yang, Wu Xinke, et al. Optimal design strategy for three components series LLC resonant converter[J]. Transactions of China Electro-
22 technical Society, 2008, 23(1): 65-71.
[22] 金科, 阮新波. 复合式全桥三电平LLC谐振变换器[J]. 中国电机工程学报, 2006, 26(3): 53-58.
Jin Ke, Ruan Xinbo. Hybrid full-bridge three-level LLC resonant converter[J]. Proceedings of the CSEE, 2006, 26(3): 53-58.
[23] 伍家驹, 刘桂英, 陈琼, 等. 推挽变压器的一种外特性模型[J]. 电工技术学报, 2011, 26(3): 123-128.
Wu Jiaju, Liu Guiying, Chen Qiong, et al. External characteristics model of push-pull transformer[J]. Transactions of China Electrotechnical Society, 2011, 26(3): 123-128.