Abstract：Output-floating DC-DC converters are widely studied in new energy fields such as photovoltaics, fuel cells, and energy storage systems due to their high voltage gain. Taking the output-floating Boost DC-DC converter as the research object, this paper deeply analyzed the mechanism of common mode conducted noises and derived an equivalent model considering circuit parasitic parameters. Under the premise of adding a linear impedance stable network on the input side, the working mode analysis of four boost circuit topologies shows that the output-floating topology structure has three more high dv/dt nodes in the circuit compared to the input-output static point connection structure. With the switching state of the converter, the common mode noise current corresponding to these high dv/dt nodes can generate the common mode noise current flowing towards the ground on the flow path. A model of an output-floating Boost circuit topology was established, taking into account the equivalent series resistance and equivalent series inductance of the input and output capacitors of the converter, as well as the parasitic capacitance of the switching transistor. Based on the substitution theorem and Kirchhoff voltage law, a common mode noise model for an output-floating Boost converter was derived by equivalently replacing a normally operating device containing parasitic parameters with voltage and current sources of the same waveform. At the same time, using the superposition theorem, the common mode noise model was simplified by considering a single noise voltage or current source. Based on Kirchhoff's current law, the common mode noise acoustic current flowing through the parasitic capacitance of each converter node under the action of a single noise source and the total mode noise current on the linear impedance stable network sampling resistor were derived. Four experimental prototypes with a rated power of 48 W were built. The output voltage, inductance current, and driving voltage were tested under 24 V input voltage working conditions. In a testing environment where common mode interference was conducted, four prototypes were tested. The common mode noise spectra were obtained through EMI receivers. It was found that the common mode noise of Boost topologies A and B is consistent in the low-frequency range and differs by 5 dBμV to 10 dBμV in the high-frequency range. The common mode noise spectra of boost topologies C and D are consistent in the 0.15 MHz to 0.5 MHz range. In the range of 0.5 MHz to 5 MHz, the common mode noise spectrum of Boost topology C is slightly higher than that of Boost topology D. The average value of the common mode noise spectra of Boost topologies C and D remains at the same level in the test frequency range of 5 MHz to 30 MHz. The common mode noise of Boost topology D is increased by approximately 12 dBμV compared to Boost topology A. Therefore, traditional input and output stationary point connected Boost converters have better common mode noise characteristics, while output- floating Boost DC-DC converters have high common mode noise limitations.
王一帆, 刘雪山, 奉榆杰. 浮动式Boost DC-DC变换器共模噪声分析[J]. 电工技术学报, 2025, 40(2): 477-487.
Wang Yifan, Liu Xueshan, Feng Yujie. Analysis of Common Mode Noise in Floating Boost DC-DC Converters. Transactions of China Electrotechnical Society, 2025, 40(2): 477-487.
[1] 桑汐坤, 王懿杰, 徐殿国. 基于输入并联输出串联的高效高升压比DC-DC变换器[J]. 电工技术学报, 2023, 38(20): 5488-5502. Sang Xikun, Wang Yijie, Xu Dianguo.High- efficiency high voltage gain DC-DC converter based on input parallel and output series connection[J]. Transaction of China Electrotechnical Society, 2023, 38(20): 5488-5502. [2] Ansari S A, Moghani J S.A novel high voltage gain noncoupled inductor Sepic converter[J]. IEEE Transactions on Industrial Electronics, 2019, 66(9): 7099-7108. [3] 黄何伟, 曹太强, 潘光绪, 等. 考虑回流功率因素的全桥CLL谐振变换器参数优化设计[J]. 电工技术学报, 2023, 38(20): 5503-5514. Huang Hewei, Cao Taiqiang, Pan Guangxu, et al.Parameter optimal design of full-bridge CLL resonant converter considering backflow power factor[J]. Transaction of China Electrotechnical Society, 2023, 38(20): 5503-5514. [4] Zhang Zhe, Bazzi A M.A virtual impedance enhancement based transformer-less active EMI filter for conducted EMI suppression in power converters[J]. IEEE Transactions on Power Electronics, 2022, 37(10): 11962-11973. [5] 郭昊, 李岩, 侯冰冰, 等. 基于正交频分复用-多进制正交幅度调制的DC-DC变换器能量信息一体化技术[J]. 电工技术学报, 2023, 38(16): 4353-4365. Guo Hao, Li Yan, Hou Bingbing, et al.Power information integration technology of DC-DC converters based on orthogonal frequency division multiplexing-multiple quadrature amplitude modulation[J]. Transaction of China Electrotechnical Society, 2023, 38(16): 4353-4365. [6] Pahlevaninezhad M, Hamza D, Jain P K.An improved layout strategy for common-mode EMI suppression applicable to high-frequency planar transformers in high-power DC/DC converters used for electric vehicles[J]. IEEE Transactions on Power Electronics, 2014, 29(3): 1211-1228. [7] Jin Meng, Ma Weiming, Pan Qijun, et al.Identification of essential coupling path models for conducted EMI prediction in switching power converters[J]. IEEE Transactions on Power Electro- nics, 2006, 21(6): 1795-1803. [8] Ji Qing, Ruan Xinbo, Ye Zhihong.The worst conducted EMI spectrum of critical conduction mode Boost PFC converter[J]. IEEE Transactions on Power Electronics, 2015, 30(3): 1230-1241. [9] 胡雪峰, 戴国瑞, 龚春英, 等. 一种高增益低开关应力改进交错型Boost变换器[J]. 电工技术学报, 2014, 29(12): 80-87. Hu Xuefeng, Dai Guorui, Gong Chunying, et al.An improved interleaved Boost converter with high gain and low switch voltage stress[J]. Transaction of China Electrotechnical Society, 2014, 29(12): 80-87. [10] 刘昌咏, 赵晋斌, 毛玲, 等. 一种高降压比DC-DC变换器[J]. 电工技术学报, 2019, 34(20): 4264-4271. Liu Changyong, Zhao Jinbin, Mao Ling, et al.A high step-down DC-DC converter[J]. Transaction of China Electrotechnical Society, 2019, 34(20): 4264-4271. [11] 刘桂花, 王博鑫, 王卫, 等. 一种改进型高转换比两相串联电容变换器[J]. 电工技术学报, 2023, 38(增刊1): 114-123. Liu Guihua, Wang Boxin, Wang Wei, et al.An improved two-phase series-capacitor converter with high conversion ratio[J]. Transaction of China Electrotechnical Society, 2023, 38(S1): 114-123. [12] Yang Lungsheng, Liang Tsorngjuu, Chen Jiannfuh.Transformerless DC-DC converters with high step-up voltage gain[J]. IEEE Transactions on Industrial Electronics, 2009, 56(8): 3144-3152. [13] Yang Lungsheng, Liang Tsorngjuu, Lee Haucheng, et al.Novel high step-up DC-DC converter with coupled-inductor and voltage-doubler circuits[J]. IEEE Transactions on Industrial Electronics, 2011, 58(9): 4196-4206. [14] Lakshmi M, Hemamalini S.Nonisolated high gain DC-DC converter for DC microgrids[J]. IEEE Transactions on Industrial Electronics, 2018, 65(2): 1205-1212. [15] Coutellier D, Agelidis V G, Choi S.Experimental verification of floating-output interleaved-input DC- DC high-gain transformer-less converter topologies[C]// 2008 IEEE Power Electronics Specialists Conference, Rhodes, Greece, 2008: 562-568. [16] Zhuo Shengrong, Gaillard A, Guo Liang, et al.Active disturbance rejection voltage control of a floating interleaved DC-DC Boost converter with switch fault consideration[J]. IEEE Transactions on Power Elec- tronics, 2019, 34(12): 12396-12406. [17] Li Qian, Huangfu Yigeng, Xu Liangcai, et al.An improved floating interleaved Boost converter with the zero-ripple input current for fuel cell appli- cations[J]. IEEE Transactions on Energy Conversion, 2019, 34(4): 2168-2179. [18] Wang Shuo, Kong Pengju, Lee F C.Common mode noise reduction for Boost converters using general balance technique[J]. IEEE Transactions on Power Electronics, 2007, 22(4): 1410-1416. [19] Xin Wu, Pong Manhay, Lu Zhengyu, et al.Novel Boost PFC with low common mode EMI: modeling and design[C]//Fifteenth Annual IEEE Applied Power Electronics Conference and Exposition, New Orleans, LA, USA, 2000: 178-181. [20] 林苏斌, 陈为, 董纪清, 等. Boost变换器共模噪声反相补偿法的高频特性分析与改善[J]. 中国电机工程学报, 2013, 33(27): 52-59, 9. Lin Subin, Chen Wei, Dong Jiqing, et al.High- frequency behaviors analysis and improvement of anti-phase compensation method for CM EMI noise suppression in Boost converters[J]. Proceedings of the CSEE, 2013, 33(27): 52-59, 9. [21] Xie Lihong, Ruan Xinbo, Zhu Haonan, et al.Common-mode voltage cancellation for reducing the common-mode noise in DC-DC converters[J]. IEEE Transactions on Industrial Electronics, 2021, 68(5): 3887-3897. [22] Xie Lihong, Yuan Xibo.Non-isolated DC-DC converters with low common-mode noise by using split-winding configuration[J]. IEEE Transactions on Power Electronics, 2022, 37(1): 452-461. [23] 林苏斌, 周云, 张丽萍, 等. Boost电感反相绕组法的共模噪声抑制特性分析与设计[J]. 中国电机工程学报, 2022, 42(5): 1946-1957. Lin Subin, Zhou Yun, Zhang Liping, et al.Analysis and design of common mode noise suppression characteristics of Boost inductor anti-phase winding method[J]. Proceedings of the CSEE, 2022, 42(5): 1946-1957.
2025, Vol. 40 
