Abstract：Four-level neutral-point-clamped (4L-NPC) inverters are widely employed in medium- and high-voltage power conversion systems due to their low harmonic distortion, reduced device voltage stress, and high conversion efficiency. Representative applications include renewable energy generation, industrial motor drives, and electric propulsion systems. Nevertheless, dc-link neutral-point (NP) voltage imbalance remains a critical challenge, primarily caused by asymmetrical utilization of switching states and the inherent charging/discharging dynamics of the dc-link capacitors. Such an imbalance degrades the quality of the output voltage, increases semiconductor stress, and adversely affects system reliability. Moreover, in the 4L-NPC topology, the intermediate-level switches (Sx2) typically operate at higher switching frequencies than the other switches, leading to increased switching losses and reduced overall efficiency. Therefore, a modulation strategy that simultaneously improves NP voltage balance and reduces the intermediate-device switching frequency is of practical significance. This paper proposes a hybrid pulse-width modulation (PWM) method that integrates variable-reference modulation with dual-zero-sequence-voltage (DZSV) injection to regulate NP voltage and reduce the switching frequency of intermediate-level devices. First, an analytical model of the neutral-point current is developed to identify the key causes of capacitor voltage imbalance in conventional carrier-overlapped PWM. The analysis indicates that the third-harmonic component of neutral-point current primarily induces triple-frequency voltage ripple, exacerbating voltage imbalance. To suppress this ripple, a decoupled zero-sequence compensation scheme is introduced that dynamically adjusts the zero-sequence voltage components based on operating parameters, such as the power factor angle and modulation index. This compensation reduces triple-frequency voltage ripple in both upper and lower dc-link capacitors, enhancing NP voltage stability under varying load and frequency conditions. A mathematical model of switching-state evolution is developed, enabling active control of the switching behavior of intermediate-level devices. This control reduces the effective switching frequency of switches (Sx2) by approximately 33.3% without compromising output waveform quality or NP voltage balance. An experimental platform employing a 4L-ANPC inverter was established, and the proposed VR+DZSV modulation strategy, the traditional variable-reference PWM, and the variable-reference plus zero-sequence voltage (VR+ZSV) methods were compared. The VR+DZSV approach maintains the NP voltage-balancing capability of VR+ZSV while improving the suppression of low-frequency capacitor voltage ripple and NP potential regulation across fundamental frequencies of 0.5 Hz, 5 Hz, and 50 Hz. Further optimization of the voltage-clamping region, termed VR+DZSV1, improves current harmonic performance at the tested frequencies. Specifically, phase current total harmonic distortion (THD) decreases from 17.83% to 1.69% at 0.5 Hz, and reduces to 1.50% and 1.44% at 5 Hz and 50 Hz, respectively. Although the phase-voltage THD at the fundamental frequency is slightly higher than that of traditional variable-reference PWM, the method effectively balances NP voltage and reduces system switching losses. Moreover, no current oscillations occur under rapid variations in modulation index, indicating favorable dynamic response characteristics. In summary, the proposed VR+DZSV hybrid PWM method addresses NP voltage imbalance and switching loss challenges in 4L-ANPC inverters. The approach improves NP voltage stability, reduces switching frequency of intermediate-level devices, and enhances system efficiency without degrading output quality. It is a promising solution for high-power conversion applications, particularly in renewable energy systems and industrial motor drives.
王玉, 陈剑飞, 李承志, 迟佳琦, 李鸿达. 兼顾中点电位平衡与效率优化的四电平中点钳位型逆变器混合调制方法[J]. 电工技术学报, 2026, 41(12): 4115-4130.
Wang Yu, Chen Jianfei, Li Chengzhi, Chi Jiaqi, Li Hongda. A Hybrid Modulation Method for Four-Level Neutral Point Clamped Inverters Considering Neutral-Point Voltage Balance and Efficiency Optimization. Transactions of China Electrotechnical Society, 2026, 41(12): 4115-4130.
[1] 陈凯, 温旭辉, 李文善, 等. 考虑数字化控制离散性的三电平低调制比区域窄脉冲抑制策略[J]. 电工技术学报, 2025, 40(8): 2587-2600. Chen Kai, Wen Xuhui, Li Wenshan, et al.Narrow pulse suppression strategy of three-level converter considering digital control discreteness in low modulation index region[J]. Transactions of China Electrotechnical Society, 2025, 40(8): 2587-2600. [2] 王汝田, 王浩, 袁帅, 等. 一种基于分裂源的双输出T型三电平逆变器[J]. 电工技术学报, 2024, 39(24): 7777-7792. Wang Rutian, Wang Hao, Yuan Shuai, et al.A dual-output T-type three-level inverter topology based on split source inverter[J]. Transactions of China Elec-trotechnical Society, 2024, 39(24): 7777-7792. [3] 黄德猛, 周扬忠, 屈艾文, 等. 具有中点电压平衡与零序电流抑制的T型三电平逆变器供电六相PMSM-DTC[J]. 电工技术学报, 2024, 39(20): 6371-6385. Huang Demeng, Zhou Yangzhong, Qu Aiwen, et al.Six-phase PMSM-DTC control with midpoint voltage balance and zero-sequence current suppression powered by T-type three-level inverter[J]. Transactions of China Electrotechnical Society, 2024, 39(20): 6371-6385. [4] 杨亚宇, 邰能灵, 黄文焘, 等. 船舶中压直流综合电力系统(一): 系统结构和电力电子变换器[J]. 电工技术学报, 2024, 39(21): 6647-6665. Yang Yayu, Tai Nengling, Huang Wentao, et al.Shipboard medium-voltage DC integrated power system Ⅰ: system architecture and power electronic converter[J]. Transactions of China Electrotechnical Society, 2024, 39(21): 6647-6665. [5] 向超群, 杜京润, Zhang Xinan, 等. 电容电压平衡的四电平有源中性点钳位逆变器的改进模型预测电流控制[J]. 电工技术学报, 2024, 39(18): 5826-5838. Xiang Chaoqun, Du Jingrun, Zhang Xinan, et al.An improved model predictive control of four-level active neutral point clamped inverter with balanced capacitor voltage[J]. Transactions of China Electro-technical Society, 2024, 39(18): 5826-5838. [6] Wang Yu, Chen Jianfei.Voltage balancing control and implementation of detroit rectifier[J]. IEEE Transactions on Industrial Electronics, 2025, 72(3): 2180-2190. [7] 王伟, 李彬彬, 宋昕哲, 等. 三电平串联谐振变换器内外管均压方法[J]. 电力系统自动化, 2024, 48(23): 188-196. Wang Wei, Li Binbin, Song Xinzhe, et al.General Modeling method of voltage source converter for electromagnetic transient simulation based on state space equation and switching function[J]. Automation of Electric Power Systems, 2024, 48(23): 188-196. [8] 胡瀚林, 赵咪, 黄毅, 等. 中高调制度下NPC逆变器扇区重构型虚拟空间矢量脉宽调制及中点平衡策略[J]. 电工技术学报, 2025, 40(8): 2573-2586. Hu Hanlin, Zhao Mi, Huang Yi, et al.Sector reconfiguration virtual space vector pulse width modulation and neutral point balance strategy of NPC inverter in medium and high modulation depth[J]. Transactions of China Electrotechnical Society, 2025, 40(8): 2573-2586. [9] 王奎, 郑泽东, 许烈, 等. 二极管箝位型四电平逆变器的中点电压平衡控制方法[J]. 电机与控制学报, 2021, 25(3): 1-7. Wang Kui, Zheng Zedong, Xu Lie, et al.Neutral-point voltage balance method for diode-clamped four-level inverters[J]. Electric Machines and Control, 2021, 25(3): 1-7. [10] Chen Jianfei, Wang Caisheng.A five-switch four-level converter[C]//2020 IEEE Energy Conversion Congress and Exposition (ECCE), Detroit, MI, USA, 2020: 3915-3920. [11] Yaramasu V, Wu Bin.Model predictive decoupled active and reactive power control for high-power grid-connected four-level diode-clamped inverters[J]. IEEE Transactions on Industrial Electronics, 2014, 61(7): 3407-3416. [12] 王奎, 郑泽东, 许烈, 等. 混合钳位型四电平和五电平逆变器拓扑结构和控制策略[J]. 电工技术学报, 2018, 33(2): 353-360. Wang Kui, Zheng Zedong, Xu Lie, et al.The topologies and control of hybrid-clamped four-level and five-level inverters[J]. Transactions of China Electrotechnical Society, 2018, 33(2): 353-360. [13] Chen Jianfei, Wang Caisheng.Dual T-type four-level converter[J]. IEEE Transactions on Power Electronics, 2020, 35(6): 5594-5600. [14] Wu Mingzhe, Tian Hao, Wang Kui, et al.Generalized low switching frequency modulation for neutral-point-clamped and flying-capacitor four-level con-verters[J]. IEEE Transactions on Power Electronics, 2022, 37(7): 8087-8103. [15] Yuan Xibo.Derivation of voltage source multilevel converter topologies[J]. IEEE Transactions on Indu-strial Electronics, 2017, 64(2): 966-976. [16] Chen Jianfei.A new insight on four-level neutral point clamped converters: four-level=two-level three-level[J]. IEEE Transactions on Power Electronics, 2024, 39(5): 5166-5177. [17] Pou J, Pindado R, Boroyevich D.Voltage-balance limits in four-level diode-clamped converters with passive front ends[J]. IEEE Transactions on Industrial Electronics, 2005, 52(1): 190-196. [18] Wang Kui, Zheng Zedong, Li Yongdong.A novel carrier-overlapped PWM method for four-level neutral-point clamped converters[J]. IEEE Transactions on Power Electronics, 2019, 34(1): 7-12. [19] Wu Mingzhe, Li Yunwei, Tian Hao, et al.Modified carrier-overlapped PWM with balanced capacitors and eliminated dead-time spikes for four-level NNPC converters under low frequency[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2022, 10(6): 6832-6844. [20] Chen Jianfei, Fu Yongsheng.Topology and voltage-balance control of a single-phase active neutral point clamped seven-level inverter[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2021, 9(4): 4762-4773. [21] Chen Jianfei, Zhong Yulin, Wang Caisheng, et al.Four-level hybrid neutral point clamped converters[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2021, 9(4): 4786-4801. [22] Wang Jun, Yuan Xibo, Jin Bosen.Carrier-based closed-loop DC-link voltage balancing algorithm for four level NPC converters based on redundant level modulation[J]. IEEE Transactions on Industrial Electronics, 2021, 68(12): 11707-11718. [23] Jin Bosen, Yuan Xibo.Control of a four-level active neutral point clamped converter with neutral point voltage balance[C]//2016 IEEE 8th International Power Electronics and Motion Control Conference (IPEMC-ECCE Asia), Hefei, China, 2016: 2337-2344. [24] Jin Bosen, Yuan Xibo.Topology, efficiency analysis, and control of a four-level PI-type converter[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2019, 7(2): 1044-1059. [25] Tan Longcheng, Wu Bin, Sood V, et al.A simplified space vector modulation for four-level nested neutral-point clamped inverters with complete control of flying-capacitor voltages[J]. IEEE Transactions on Power Electronics, 2018, 33(3): 1997-2006. [26] Pan Jianyu, Yang Yong, Cai Haiwei, et al.Capacitor voltage fluctuation minimization for four-level hybrid clamped converter using improved common-mode voltage injection[J]. IEEE Transactions on Power Electronics, 2020, 35(7): 7563-7573. [27] Pou J, Pindado R, Boroyevich D, et al.Evaluation of the low-frequency neutral-point voltage oscillations in the three-level inverter[J]. IEEE Transactions on Industrial Electronics, 2005, 52(6): 1582-1588. [28] Tan Longcheng, Wu Bin, Narimani M, et al.A space virtual-vector modulation with voltage balance control for nested neutral-point clamped converter under low output frequency conditions[J]. IEEE Transactions on Power Electronics, 2017, 32(5): 3458-3466. [29] Pan Zhiguo, Peng Fangzheng, Corzine K A, et al.Voltage balancing control of diode-clamped multi-level rectifier/inverter systems[J]. IEEE Transactions on Industry Applications, 2005, 41(6): 1698-1706. [30] Sano K, Fujita H.Voltage-balancing circuit based on a resonant switched-capacitor converter for multilevel inverters[J]. IEEE Transactions on Industry Appli-cations, 2008, 44(6): 1768-1776. [31] Hachlowski J, Stala R.DC-link voltage balancing converter with resonant switched-capacitor circuit for four-level and six-level NPC inverter[C]//2019 21st European Conference on Power Electronics and Applications (EPE'19 ECCE Europe), Genova, Italy, 2019: 1-10.
2026, Vol. 41 
