Abstract：The traditional finite constraint set model predictive control method only uses six effective space voltage vectors and two zero vectors of two-level voltage source inverter as the control set, resulting in high current harmonics in the phase current of permanent magnet synchronous motor. To solve this problem, an amplitude control set model predictive control method based on voltage amplitude control set in rotating coordinate system is proposed in this paper. Firstly, the load state of the motor is analyzed, and the voltage amplitude control set is designed according to the motor voltage state equation. Then the optimal voltage amplitude is selected according to the current reference value and current prediction model. Based on the current rotor position, the optimal vector is synthesized and the inverter voltage vector is applied to the motor. This method can effectively reduce the phase error and amplitude error of the optimal vector, so as to reduce the current harmonic and torque ripple of the motor. At the same time, the limited optimal range and the design of amplitude control set make the method effectively reduce the computational complexity of the algorithm. Finally, by building a hardware experimental platform and comparing with current loop PI controller and duty cycle model predictive current controller, the improvement of steady-state performance and dynamic performance of this method is verified.
张珍睿, 刘彦呈, 陈九霖, 郭昊昊, 李冠桦. 永磁同步电机幅值控制集模型预测控制策略[J]. 电工技术学报, 2022, 37(23): 6126-6134.
Zhang Zhenrui, Liu Yancheng, Chen Jiulin, Guo Haohao, Li Guanhua. Amplitude Control Set Model Predictive Control Strategy for Permanent Magnet Synchronous Motor. Transactions of China Electrotechnical Society, 2022, 37(23): 6126-6134.
[1] 姚绪梁, 黄乘齐, 王景芳, 等. 两相静止坐标系下的永磁同步电动机模型预测功率控制[J]. 电工技术学报, 2021, 36(1): 60-67. Yao Xuliang, Huang Shengqi, Wang Jingfang, et al.Model predictive power control of permanent magnet synchronous motor in two-phase static coordinate system[J]. Transactions of China Electrotechnical Society, 2021, 36(1): 60-67. [2] 贾成禹, 王旭东, 周凯. 基于线性变参数模型预测控制的内置式永磁同步电机转速控制器设计[J]. 电工技术学报, 2020, 35(22): 4666-4677. Jia Chengyu, Wang Xudong, Zhou Kai.Design of interior permanent magnet synchronous motor speed controller based on linear parameter-varying model predictive control[J]. Transactions of China Electrotechnical Society, 2020, 35(22): 4666-4677. [3] 郭磊磊, 金楠, 李琰琰, 等. 电压源逆变器虚拟矢量模型预测共模电压抑制方法[J]. 电工技术学报, 2020, 35(4): 839-849. Guo Leilei, Jin Nan, Li Yanyan, et al.Virtual vector based model predictive common-mode voltage reduction method for voltage source inverters[J]. Transactions of China Electrotechnical Society, 2020, 35(4): 839-849. [4] Bemporad A, Borrelli F, Morari M.Model predictive control based on linear programming - the explicit solution[J]. IEEE Transactions on Automatic Control, 2002, 47(12): 1974-1985. [5] Mariethoz S, Domahidi A, Morari M.High-bandwidth explicit model predictive control of electrical drives[J]. IEEE Transactions on Industry Applications, 2012, 48(6): 1980-1992. [6] 陈卓易, 屈稳太. 基于PID型代价函数的永磁同步电机模型预测电流控制[J]. 电工技术学报, 2021, 36(14): 2971-2978. Chen Zhuoyi, Qu Wentai.Model predictive current control for permanent magnet synchronous motors based on PID-type cost function[J]. Transactions of China Electrotechnical Society, 2021, 36(14): 2971-2978. [7] Zhang Yanqing, Yin Zhonggang, Li Wei, et al.Finite control set model predictive torque control using sliding model control for induction motors[J]. CES Transactions on Electrical Machines and Systems, 2021, 5(3): 262-270. [8] Rodriguez J, Pontt J, Silva C A, et al.Predictive Current control of a voltage source inverter[J]. IEEE Transactions on Industrial Electronics, 2007, 54(1): 495-503. [9] Wang Yuanlin, Wang Xiaocan, Xie Wei, et al.Deadbeat model-predictive torque control with discrete space-vector modulation for PMSM drives[J]. IEEE Transactions on Industrial Electronics, 2017, 64(5): 3537-3547. [10] Wang Tianshi, Liu Chengcheng, Lei Gang, et al.Model predictive direct torque control of permanent magnet synchronous motors with extended set of voltage space vectors[J]. IET Electric Power Applications, 2017, 11(8): 1376-1382. [11] Zhou Zhanqing, Xia Changliang, Yan Yan, et al.Torque ripple minimization of predictive torque control for PMSM with extended control set[J]. IEEE Transactions on Industrial Electronics, 2017, 64(9): 6930-6939. [12] Ma Zhixun, Saeidi S, Kennel R.FPGA implementation of model predictive control with constant switching frequency for PMSM drives[J]. IEEE Transactions on Industrial Informatics, 2014, 10(4): 2055-2063. [13] 肖萌. 永磁同步电机系统模型预测转矩控制[D]. 天津: 天津大学, 2018. [14] Muddineni V P, Sandepudi S R, Bonala A K.Finite control set predictive torque control for induction motor drive with simplified weighting factor selection using TOPSIS method[J]. IET Electric Power Applications, 2017, 11(5): 749-760. [15] Muddineni V P, Bonala A K, Sandepudi S R.Enhanced weighting factor selection for predictive torque control of induction motor drive based on VIKOR method[J]. IET Electric Power Applications, 2016, 10(9): 877-888. [16] Davari S A, Khaburi D A, Kennel R.An improved FCS-MPC algorithm for an induction motor with an imposed optimized weighting factor[J]. IEEE Transactions on Power Electronics, 2012, 27(3): 1540-1551. [17] 陈炜, 曾思坷, 张国政, 等. 永磁同步电机改进型三矢量模型预测转矩控制[J]. 电工技术学报, 2018, 33(增刊2): 420-426. Chen Wei, Zeng Sike, Zhang Guozheng, et al.Improved three-vector model predictive torque control of permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2018, 33(S2): 420-426. [18] Vafaie M H, Mirzaeian Dehkordi B, Moallem P, et al.A new predictive direct torque control method for improving both steady-state and transient-state operations of the PMSM[J]. IEEE Transactions on Power Electronics, 2016, 31(5): 3738-3753. [19] Zhang Xiaoguang, He Yikang.Robust model predictive direct speed control for SPMSM drives based on full parameters and load observer[C]//2019 IEEE International Symposium on Predictive Control of Electrical Drives and Power Electronics, Quanzhou, 2019: 1-5. [20] Chen Wei, Zeng Sike, Zhang Guozheng, et al.A modified double vectors model predictive torque control of permanent magnet synchronous motor[J]. IEEE Transactions on Power Electronics, 2019, 34(11): 11419-11428. [21] 於锋, 朱晨光, 吴晓新, 等. 基于矢量分区的永磁同步电机三电平双矢量模型预测磁链控制[J]. 电工技术学报, 2020, 35(10): 2130-2140. Yu Feng, Zhu Chenguang, Wu Xiaoxin, et al.Two-vector-based model predictive flux control of three-level based permanent magnet synchronous motor with sector subregion[J]. Transactions of China Electrotechnical Society, 2020, 35(10): 2130-2140. [22] 秦艳忠, 阎彦, 陈炜, 等. 永磁同步电机参数误差补偿-三矢量模型预测电流控制[J]. 电工技术学报, 2020, 35(2): 255-265. Qin Yanzhong, Yan Yan, Chen Wei, et al.Three-vector model predictive current control strategy for permanent magnet synchronous motor drives with parameter error compensation[J]. Transactions of China Electrotechnical Society, 2020, 35(2): 255-265. [23] Liu Ying, Cheng Shanmei, Zhao Yunzheng, et al.Optimal two-vector combination-based model predictive current control with compensation for PMSM drives[J]. International Journal of Electronics, 2019, 106(6): 880-894. [24] Tu Wencong, Luo Guangzhao, Chen Zhe, et al.Predictive cascaded speed and current control for PMSM drives with multi-timescale optimization[J]. IEEE Transactions on Power Electronics, 2019, 34(11): 11046-11061. [25] Preindl M, Bolognani S.Model predictive direct torque control with finite control set for PMSM drive systems, part 2: field weakening operation[J]. IEEE Transactions on Industrial Informatics, 2013, 9(2): 648-657. [26] Liu Ming, Chan K W, Hu Jiefeng, et al.Model predictive direct speed control with torque oscillation reduction for PMSM drives[J]. IEEE Transactions on Industrial Informatics, 2019, 15(9): 4944-4956. [27] 徐艳平, 张保程, 周钦. 永磁同步电机双矢量模型预测电流控制[J]. 电工技术学报, 2017, 32(20): 222-230. Xu Yanping, Zhang Baocheng, Zhou Qin.Two-vector based model predictive current control for permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 222-230.
2022, Vol. 37 
