Energy Transmission Modes and Output Ripple Voltage of Forward-Flyback Converter
Liu Shulin1, Cao Jian1, Hu Chuanyi1, Yan Jizhi1, Wang Chuanliang1,2
1. College of Electrical and Control Engineering Xi’an University of Science & Technology Xi’an 710054 China;; 2. Shaanxi ZTE Xianglin Electronic Technology Co. Ltd Xi’an 710065 China;
Abstract：The energy transmission modes (ETM) of forward-flyback converter were deeply studied to provide theoretical guidance for its design and development. When the flyback part works in continuous conduction mode (CCM) and discontinuous conduction mode (DCM), there are six kinds and four kinds of energy transfer modes of the ETM respectively. The critical inductances among ETMs were obtained, and the critical inductances of transformer in CCM increase with the decrease of inductance. The expression of the output ripple voltage (ORV) in each ETM was deduced. It is pointed out that the ORV decreases with increasing the inductance of transformer when flyback part works in incomplete inductor supplying mode. However, the ORV is independent of the transformer inductance in complete inductor supplying mode and decreases with decreasing inductance. Meanwhile, only a small inductance and capacitance are needed to meet the requirement of ORV. Simulation and experimental results verify the correctness of the theoretical analysis.
刘树林, 曹剑, 胡传义, 严纪志, 王传良. 正-反激组合变换器的能量传输模式及输出纹波电压分析[J]. 电工技术学报, 2019, 34(8): 1647-1656.
Liu Shulin, Cao Jian, Hu Chuanyi, Yan Jizhi, Wang Chuanliang. Energy Transmission Modes and Output Ripple Voltage of Forward-Flyback Converter. Transactions of China Electrotechnical Society, 2019, 34(8): 1647-1656.
[1] 李龙春, 嵇保健, 洪峰, 等. 1500V三电平正激变换器[J]. 电工技术学报, 2018, 33(9): 2044-2054. Li Longchun, Ji Baojian, Hong Feng, et al.1500V three-level forward converter[J]. Transactions of China Electrotechnical Society, 2018, 33(9): 2044-2054. [2] 卢增艺, 陈为, 章进法. 磁集成开关变换器的小信号建模方法[J]. 电工技术学报, 2015, 30(24): 103-109. Lu Zengyi, Chen Wei, Zhang Jinfa.Small signal modeling methods of switched-mode converter with magnetic integration[J]. Transactions of China Electrotechnical Society, 2015, 30(24): 103-109. [3] Lin Jingyuan, Liu Pangjung, Yang Chengyan.A dual-transformer active-clamp forward converter with nonlinear conversion ratio[J]. IEEE Transactions on Power Electronics, 2016, 31(6): 4353-4361. [4] 胡海兵, 吴红飞, 刘薇, 等. 一族有源钳位正激变换器[J]. 电工技术学报, 2013, 28(12): 245-250, 261. Hu Haibing, Wu Hongfei, Liu Wei, et al.A family of active clamp forward converters[J]. Transactions of China Electrotechnical Society, 2013, 28(12): 245-250, 261. [5] 薛伟民, 陈乾宏. 有源钳位正激变换器寄生参数对软开关和直流偏磁的影响[J]. 电工电能新技术, 2017, 36(5): 75-80. Xue Weimin, Chen Qianhong.Influence of parasitic parameters on soft switching and DC magnetic bias for active-clamp forward converter[J]. Advanced Technology of Electrical Engineering and Energy, 2017, 36(5): 75-80. [6] Cobos J A, Garcia Q, Sebastian J, et al.Resonant reset forward topologies for low output voltage on board converters[C]//IEEE Applied Power Electronics Conference, Florida, 1994, 2: 703-708. [7] 任小永, 张强, 庞振进, 等. 输入串联输出准并联的多路输出变换器[J]. 中国电机工程学报, 2016, 36(13): 3582-3589, 3377. Ren Xiaoyong, Zhang Qiang, Pang Zhenjin, et al.Input-series output-quasi-parallel multiple output converter[J]. Proceedings of the CSEE, 2016, 36(13): 3582-3589, 3377. [8] 王星星, 嵇保健, 洪峰, 等. 一种改进的正反激并网微型逆变器[J]. 电工技术学报, 2017, 32(18): 202-210. Wang Xingxing, Ji Baojian, Hong Feng, et al.An improved forward-flyback grid-connected micro- inverter[J]. Transactions of China Electrotechnical Society, 2017, 32(18): 202-210. [9] 石健将, 洪峰, 严仰光. 双管正—反励组合变换器研究[J]. 电工技术学报, 2003, 18(5): 87-90. Shi Jianjiang, Hong Feng, Yan Yangguang.Study of two-transistor forward-flyback combined converter[J]. Transactions of China Electrotechnical Society, 2003, 18(5): 87-90. [10] Chen Frank, Auadisian Emil, Shen John, et al.Forward-flyback mixed ZVS DC-DC converter with non-dissipative LC snubber circuit[C]//IEEE Applied Power Electronics Conference and Exposition, California, 2013: 2132-2138. [11] Chen Frank Amirahmadi A, Batarseh I. Zero voltage switching forward-flyback converter with efficient active LC snubber circuit[C]//IEEE Applied Power Electronics Conference and Exposition, Texas, 2014: 2041-2047. [12] Chen Lin, Hu Haibing, Zhang Qian, et al.A boundary-mode forward-flyback converter with an efficient active LC snubber circuit[J]. IEEE Transa- ctions on Power Electronics, 2014, 29(6): 2944-2958. [13] 谢小高, 赵晨, 郑凌蔚, 等. 有源钳位正反激变流器的第三绕组与电流型混合同步整流驱动方案[J]. 中国电机工程学报, 2012, 32(33): 31-36, 172. Xie Xiaogao, Zhao Chen, Zheng Lingwei, et al.A third-winding and current-driven hybrid driving scheme for SRs of active-clamped forward-flyback converters[J]. Proceedings of the CSEE, 2012, 32(33): 31-36, 172. [14] Chen Frank, Hu Haibing, Shen John, et al.Design and analysis for ZVS forward-flyback DC-DC converter[C]//IEEE Energy Conversion Congress and Exposition, Arizona, 2011: 116-121. [15] Xie Xiaogao, Li Jiangsong, Peng Kunsheng, et al.Study on the single-stage forward-flyback PFC converter with QR control[J]. IEEE Transactions on Power Electronics, 2016, 31(1): 430-442. [16] Li Jiangsong, Xie Xiaogao, Peng Kunsheng, et al.Optimum design on the single-stage forward-flyback PFC converter with two different QR controls[C]// IEEE Applied Power Electronics Conference and Exposition, California, 2015: 1869-1874. [17] 王国礼, 金新民. 一种正-反激组合变换器的研究[J]. 电力电子技术, 2001, 35(2): 4-6. Wang Guoli, Jin Xinmin.Research on a forward- flyback converter[J]. Power Electronics, 2001, 35(2): 4-6. [18] Himmelstoss F, Votzi H L.Comparison of a new combined four-diode forward-flyback converter with the classical forward converter[C]//International Symposium on Signals, Circuits and Systems, Iasi, Romania, 2009: 1-4. [19] 卢增艺, 陈为, 陈志宇. 磁集成正激变换器输出电流纹波减小的分析和设计[J]. 电工电能新技术, 2014, 33(3): 23-26. Lu Zengyi, Chen Wei, Chen Zhiyu.Analysis and design of output current ripple reduction in forward converter with integrated magnetics[J]. Advanced Technology of Electrical Engineering and Energy, 2014, 33(3): 23-26. [20] 朴政国, 郭裕祺, 户永杰, 等. 一种集成化蓄电池脉冲充放电控制器[J]. 电工技术学报, 2017, 32(10): 231-240. Piao Zhengguo, Guo Yuqi, Hu Yongjie, et al.Integrated battery pulse charging-discharging con- troller[J]. Transactions of China Electrotechnical Society, 2017, 32(10): 231-240. [21] 王武, 卢德祥, 林琼斌, 等. 谐振电容电压反馈单输入多输出反激式变换器[J]. 电工技术学报, 2017, 32(14): 96-105. Wang Wu, Lu Dexiang, Lin Qiongbin, et al.Resonant capacitor voltage feedback of single-input multi- output flyback converter[J]. Transactions of China Electrotechnical Society, 2017, 32(14): 96-105.
2019, Vol. 34 
