Speed and Rotor Position Estimation for PMSM Based on Hall Vector Phase-Tracking
Zhao Yuanyang1, 2, Han Bangcheng1, 2, Chen Baodong1, 2
1. Science and Technology on Inertial Laboratory BeihangUniverityBeijing 100191 China; 2. Beijing Engineering Research Center of High-Speed Magnetically Suspended Motor Technology and ApplicationBeijing 100191 China
Abstract：Three-phasehall sensors are commonly utilized in permanent-magnet synchronous motor (PMSM) to provide lowresolution rotor position. In order to correct the rotor position estimation error of PMSM, the hall vector phase tracking (HVPT)method was proposed.Firstly,the hall rotation vector which contains the rotor position information was obtained by 3/2coordinate transformation. Secondly, the synchronous frequency tracking-filterswere applied in two orthogonal components of the hall rotation vector. Next, the fundamental waves which containthe sine and cosine function of the rotor position were obviously obtained as their high-order harmonic nosies were filtered out. Finally, the orthogonal phase-locked loop was used in the fundamental waves to estimate the rotor position and speed. This method using HVPT which can compensate the estimated error caused by the mechanical unevennessrelated to hall sensors has the feature of no needs for system parameters, easily implemented and low cost. The validity of the proposed method is verified through simulation and experimental results.
赵远洋, 韩邦成, 陈宝栋. 基于霍尔矢量相位跟踪的永磁同步电机转子位置与速度估算方法[J]. 电工技术学报, 2019, 34(15): 3147-3157.
Zhao Yuanyang, Han Bangcheng, Chen Baodong. Speed and Rotor Position Estimation for PMSM Based on Hall Vector Phase-Tracking. Transactions of China Electrotechnical Society, 2019, 34(15): 3147-3157.
[1] 刘计龙, 肖飞, 沈洋, 等. 永磁同步电机无位置传感器控制技术研究综述[J]. 电工技术学报, 2017, 32(16): 76-88. Liu Jilong, Xiao Fei, Shen Yang, et al.Position-sensorless control technology of permanent magnet synchronous motor a review[J]. Transactions of China Electrotechnical Society, 2017, 32(16): 76-88. [2] 吕晓源, 刘刚, 毛琨, 等. 基于虚拟脉振高频注入法的永磁电机初始位置检测[J]. 电工技术学报, 2017, 32(23): 34-41. Lü Xiaoyuan, Liu Gang, Mao Kun, et al.Initial position detection of permanent magnet motor based on virtual pulsating high-frequency injection method[J]. Transactions of China Electrotechnical Society, 2017, 32(23): 34-41. [3] Song Xinda, Fang Jiancheng, Han Bangcheng, et al.Adaptive compensation method for high-speed surface PMSM sensorless drives of emf-based position estimation error[J]. IEEE Transactions on Power Electronics, 2015, 31(2): 1438-1449. [4] Luo Xin, Tang Qipeng, Shen Anwen, et al.PMSM sensorless control by injecting HF pulsating carrier signal into estimated fixed-frequency rotating reference frame[J]. IEEE Transactions on Industrial Electronics, 2016, 63(4): 2294-2303. [5] 倪启南, 杨明, 徐殿国, 等. 低分辨率位置传感器永磁同步电机精确位置估计方法综述[J]. 电工技术学报, 2017, 32(22): 70-81. Ni Qinan, Yang Ming, Xu Dianguo, et al.Review of precise position estimation method of PMSM with low-resolution position sensor[J]. Transactions of China Electrotechnical Society, 2017, 32(22): 70-81. [6] Capponi F G, Donato G D, Ferraro L D, et al.AC brushless drive with low-resolution Hall-effect sensors for surface-mounted PM Machines[J]. IEEE Transactions on Industry Applications, 2006, 42(2): 526-535. [7] 荀倩, 王培良, 蔡志端, 等. 霍尔转子位置预估方法及其误差校正[J]. 电工技术学报, 2017, 32(6): 145-155. Xun Qian, Wang Peiliang, Cai Zhiduan, et al.Hall rotor position estimation method and its error compensation[J]. Transactions of China Electrotechnical Society, 2017, 32(6): 145-155. [8] Zhang Xinghao, Zhang Wei.An improved rotor position estimation in PMSM with low-resolution hall-effect sensors[C]//2014 17th International Conference on Electrical Machines and Systems, Hangzhou, China, 2015: 2722-2727. [9] Ahn H J, Lee D M.A new bumpless rotor-flux position estimation scheme for vector-controlled washing machine[J]. IEEE Transactions on Industrial Informatics, 2016, 12(2): 466-473. [10] Tesch T R, Lorenz R D.Disturbance torque and motion state estimation with low-resolution position interfaces using heterodyning observers[J]. IEEE Transactions on Industry Applications, 2008, 44(1): 124-134. [11] 董亮辉, 刘景林. 霍尔传感器故障下的永磁无刷电机容错控制及其动态性能研究[J]. 中国电机工程学报, 2017, 37(12): 3602-3611. Dong Lianghui, Liu Jinglin.Research on the fault tolerant control and its dynamic performance of brushless permanent magnet motor with faults in hall sensor[J]. Proceedings of the CSEE, 2017, 37(12): 3602-3611. [12] 倪启南, 杨明, 董翔, 等. 基于霍尔位置传感器的PMSM转速观测器状态估算误差抑制方法[J]. 电工技术学报, 2017, 32(17): 189-198. Ni Qinan, Yang Ming, Dong Xiang, et al.State estimation error suppression for PMSM speed observer based on hall position sensor[J]. Transactions of China Electrotechnical Society, 2017, 32(17): 189-198. [13] Yoo A, Sul S K, Lee D C, et al.Novel speed and rotor position estimation strategy using a dual observer for low-resolution position sensors[J]. IEEE Transactions on Power Electronics, 2009, 24(12): 2897-2906. [14] Kim S Y, Choi C, Lee K, et al.An improved rotor position estimation with vector-tracking observer in PMSM drives with low-resolution hall-effect sensors[J]. IEEE Transactions on Industrial Electronics, 2011, 58(9): 4078-4086. [15] Dalala Z M, Cho Y, Lai J S.Enhanced vector tracking observer for rotor position estimation for PMSM drives with low resolution Hall-Effect position sensors[C]//2013 International Electric Machines & Drives Conference, Chicago, IL, USA, 2013: 484-491. [16] 谭建成. 适用于各类无刷直流电动机确定霍尔传感器位置的通用方法[J]. 微电机, 2014, 47(8): 1-6. Tan Jiancheng.General method to determine Hall sensor position applicable to all kinds of brushless DC motors[J]. Micromotors, 2014, 47(8): 1-6. [17] 刘刚, 肖烨然, 宋欣达. 永磁同步电机用线性霍尔位置检测的误差补偿[J]. 电机与控制学报, 2014, 18(8): 36-42. Liu Gang, Xiao Yeran, Song Xinda.Error compensation of rotor position detection for permanent magnetic synchronous motor based on linear Hall sensors[J]. Eelctric Machines and Control, 2014, 18(8): 36-42.
2019, Vol. 34 
