基于气液两相及光电离的酯基绝缘油流注放电模拟

doi:10.19595/j.cnki.1000-6753.tces.231528

摘要
图/表
参考文献
相关文章 (14)

全文: PDF (1847 KB)
输出: BibTeX | EndNote (RIS)

摘要

流注放电是一个非常复杂的多尺度、多物理耦合过程,目前尚无准确的模型能描述其发展过程。相变及光电离是影响流注演变的重要因素,但现有流注放电模型很少将其影响考虑到模型内,为分析二者对流注放电的影响,该文在COMSOL中建立针/板放电几何模型,以酯基绝缘油为研究对象,基于电流体力学模型,以相变温度为临界点,分别构建气相和液相下的电离机制。此外,建立了与电场阈值相关的光电离数学模型。结果表明,光电离的引入促使优势流注分支的产生,且光电离主要发生在优势流注头部区域。由于高温区域主要集中在针尖处,气相区域会随着局部温度的升高而产生,在电场作用下,气相区域发生碰撞电离在针尖处产生更多小流注分支。气相区域对主流注传播速度几乎没有影响,主流注的传播速度主要受场致电离和光电离控制。光电离在流注头部产生了更多的载流子,促使改进模型的主流注以更快的速度传播,从而易实现传播模式从慢速到快速的转换。该文可为酯基绝缘油快速流注的产生机理提供新的洞察思路,为提高其击穿电压提供指导依据。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王开正
	王帅旗
	俞瑞龙
	李露露
	王飞鹏

关键词 ：酯基绝缘油, 光电离, 气相, 流注放电

Abstract：

In recent years, biodegradable and environmentally friendly synthetic ester insulation oils with high ignition points have received attention and extensive research, and have been applied to in-service power transformers. However, in long oil gaps, synthetic ester insulation oil is more prone to rapid streamer compared to mineral insulation oil, and rapid streamer has been proven to be one of the most critical factors leading to insulation faults in oil-immersed transformers, which limits its application in transformers at higher voltage levels. At present, research on the dielectric properties of synthetic ester insulating oils mainly focuses on experimental observation, making it difficult to observe their microscopic processes under high electric fields. In this study, based on the electrohydrodynamic model, a gas phase impact ionization term with phase transition temperature as the critical point and an ester based insulating oil streamer discharge model considering molecular ionization energy, temperature, and electric field photoionization terms were established. The streamer discharge process of ester based insulating oil was simulated, and the streamer morphology characteristics, streamer channel temperature distribution, propagation characteristics, and space charge distribution were investigated.
Firstly, the mechanism of the generation and capture of positive ions, electrons, and negative ions was explained using the convection diffusion equation. By coupling the Poisson equation with the convection diffusion equation, the process of charge movement and spatial charge distribution in synthetic ester insulating oil under the action of an electric field can be described. Secondly, collision ionization was established using the phase transition temperature of synthetic ester insulating oil as the critical point. Thirdly, a photoionization model was established that considers the correlation between molecular ionization energy, temperature, and electric field. Finally, all oil parameters are derived from the previously prepared synthetic ester insulation oil, trimethylolpropane triate (TME).
The results indicate that the large number of carriers generated by the photoionization term can cause local electric field distortion and promote the generation of dominant streamer branches, while the denser small streamer branches at the needle tip are caused by impact ionization in the gas phase region. The improved model is more in line with the observed multi branch characteristics of the streamer in terms of streamer morphology. The phase transition has almost no effect on the propagation speed of the main streamer, mainly because the development of the main streamer is controlled by photoionization and field ionization. The trend of streamer velocity change is similar to the experimental results, showing a trend of increasing first and then decreasing. The introduction of the photoionization term causes the model to generate more carriers, promoting the propagation of the main streamer. Therefore, the propagation speed of the main streamer in the original model is slower than that of the improved model under three different voltages. Moreover, at higher voltages, the main streamer propagation speed of the improved model is the first to achieve the transition from 2nd to 3rd propagation mode. Therefore, the reason for the rapid streamer of ester based insulating oils may be due to photoionization. The simulation results show that the high-temperature region is mainly concentrated at the needle tip, causing a phase transition as the temperature increases. At this time, impact ionization generates more space charges in the gas phase region. Under the action of electric field, these charges cause more disturbances at the needle tip, which may be the reason for the formation of more dense small streamer branches in the needle tip region.

Key words： Ester based insulating oil photoionization gas phase streamer discharge

收稿日期: 2023-09-18

PACS:

TM214

基金资助:

国家自然科学基金青年项目（52107017）、云南省科技厅基础研究专项青年项目（202201AU070172）、国家自然科学基金面上项目（52177016）和国家自然科学基金重点项目（52130707）资助

通讯作者: 李露露女,1989年生,副教授,硕士生导师,研究方向为电力扰动分析与电力电缆。 E-mail：lilulu1203@foxmail.com

作者简介: 王开正男,1988年生,副教授,硕士生导师,研究方向为电绝缘老化及电工绝缘材料。E-mail：wkz@kust.edu.cn

引用本文:

王开正, 王帅旗, 俞瑞龙, 李露露, 王飞鹏. 基于气液两相及光电离的酯基绝缘油流注放电模拟[J]. 电工技术学报, 0, (): 231528-231528. Wang Kaizheng, Wang Shuaiqi, Yu Ruilong, Li Lulu, Wang Feipeng. Simulation of Ester Based Insulating Oil Streamer Discharge Based on Gas-Liquid Two-Phase and Photoionization. Transactions of China Electrotechnical Society, 0, (): 231528-231528.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.231528 https://dgjsxb.ces-transaction.com/CN/Y0/V/I/231528

[1] 张宁, 刘士利, 郝建, 等. 变压器油中气泡杂质相局部放电特性研究综述[J]. 电工技术学报, 2023, 38(10): 2757-2776.
Zhang Ning, Liu Shili, Hao Jian, et al.Review on partial discharge characteristics of bubble impurity phase in transformer oil[J]. Transactions of China Electrotechnical Society, 2023, 38(10): 2757-2776.
[2] Shen Zijia, Wang Feipeng, Wang Zhiqing, et al.A critical review of plant-based insulating fluids for transformer: 30-year development[J]. Renewable and Sustainable Energy Reviews, 2021, 141: 110783.
[3] 谢一鸣, 金硕, 阮江军, 等. 变压器油浸纸电气参数分区反演优化算法[J]. 高压电器, 2023, 59(8): 1-11.
Xie Yiming, Jin Shuo, Ruan Jiangjun, et al.Multi-regional inverse optimization algorithm for electrical parameters of oil-immersed paper of transformer[J]. High Voltage Apparatus, 2023, 59(8): 1-11.
[4] 刘道生, 周春华, 丁金, 等. 变压器纳米改性油纸复合绝缘研究综述[J]. 电工技术学报, 2023, 38(9): 2464-2479, 2490.
Liu Daosheng, Zhou Chunhua, Ding Jin, et al.Research overview of oil-paper composite insulation modified by nano particles for transformer[J]. Transactions of China Electrotechnical Society, 2023, 38(9): 2464-2479, 2490.
[5] 郑玉平, 郝治国, 薛众鑫, 等. 大型电力变压器安全运行与主动保护技术探索[J]. 电力系统自动化, 2023, 47(20): 1-12.
Zheng Yuping, Hao Zhiguo, Xue Zhongxin, et al.Exploration of safe operation and active protection technology for large-capacity power transformers[J]. Automation of Electric Power Systems, 2023, 47(20): 1-12.
[6] 廖瑞金, 张爽, 杨丽君, 等. 天然酯-纸绝缘与矿物油-纸绝缘的热老化及工频击穿特性对比[J]. 高电压技术, 2012, 38(4): 769-775.
Liao Ruijin, Zhang Shuang, Yang Lijun, et al.Comparative analyses of thermal aging and power frequency breakdown characteristics between natural ester-paper insulation and mineral oil-paper insulation[J]. High Voltage Engineering, 2012, 38(4): 769-775.
[7] 赵洪山, 常杰英, 曲岳晗, 等. 基于二元非线性Wiener随机过程的变压器油纸绝缘剩余寿命预测方法[J]. 电工技术学报, 2023, 38(15): 4040-4049.
Zhao Hongshan, Chang Jieying, Qu Yuehan, et al.Residual life prediction method of transformer oil-paper insulation based on binary nonlinear Wiener random process[J]. Transactions of China Electrotechnical Society, 2023, 38(15): 4040-4049.
[8] 梁苏宁, 李剑, 王飞鹏, 等. 正极性雷电冲击电压下天然酯绝缘油油纸沿面流注动态变化规律研究[J]. 中国电机工程学报, 2021, 41(1): 156-165, 中插14.
Liang Suning, Li Jian, Wang Feipeng, et al. Study on the dynamic characteristics of streamer along the interface surface of natural ester insulating oil-pressboard system under positive lightning impulse voltage[J]. Proceedings of the CSEE, 2021, 41(1): 156-165, 中插14.
[9] 但林阳, 黄正勇, 王飞鹏, 等. 植物绝缘油抑制离子迁移的动力学机制研究[J]. 中国电机工程学报, 2023, 43(11): 4474-4485.
Dan Linyang, Huang Zhengyong, Wang Feipeng, et al.Study on the dynamic mechanism of inhibited ion mobility in vegetable insulating oil[J]. Proceedings of the CSEE, 2023, 43(11): 4474-4485.
[10] 崔鲁, 陈伟根, 张知先, 等. 植物油浸绝缘纸的热稳定性及其对气隙放电发展的影响[J]. 中国电机工程学报, 2018, 38(4): 1248-1254, 1302.
Cui Lu, Chen Weigen, Zhang Zhixian, et al.Thermal stability of vegetable oil impregnated pressboard and its influence on the air-gap discharge development[J]. Proceedings of the CSEE, 2018, 38(4): 1248-1254, 1302.
[11] 陈鑫, 郝建, 冯大伟, 等. 三元混合式绝缘油和矿物油的雷电冲击击穿及产气特性对比分析研究[J]. 电工技术学报, 2020, 35(4): 906-918.
Chen Xin, Hao Jian, Feng Dawei, et al.Comparative study on lightning impulse breakdown and gas production characteristics of three-element mixed insulation oil and mineral oil[J]. Transactions of China Electrotechnical Society, 2020, 35(4): 906-918.
[12] Villarroel R, Garcia D F, Garcia B, et al.Moisture diffusion coefficients of transformer pressboard insulation impregnated with natural esters[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2015, 22(1): 581-589.
[13] Vasconcellos V, Sbravati A, Cera Zanetta L, et al.Increased loadability of transformers using natural ester and cellulosic materials as high temperature insulation systems[J]. IEEE Electrical Insulation Magazine, 2018, 34(5): 8-17.
[14] Lesaint O.Prebreakdown phenomena in liquids: propagation ‘modes’ and basic physical properties[J]. Journal of Physics D: Applied Physics, 2016, 49(14): 144001.
[15] Reffas A, Moulai H, Beroual A.Comparison of dielectric properties of olive oil, mineral oil, and other natural and synthetic ester liquids under AC and lightning impulse stresses[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(5): 1822-1830.
[16] Hwang J G, Zahn M, Pettersson L A A. Mechanisms behind positive streamers and their distinct propagation modes in transformer oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2012, 19(1): 162-174.
[17] Hwang J G.Elucidating the mechanisms behind pre-breakdown phenomena in transformer oil systems[D]. Cambridge: Massachusetts Institute of Technology, 2010.
[18] 李元, 穆海宝, 邓军波, 等. 正极性纳秒脉冲电压下变压器油中流注放电仿真研究[J]. 物理学报, 2013, 62(12): 334-344.
Li Yuan, Mu Haibao, Deng Junbo, et al.Simulational study on streamer discharge in transformer oil under positive nanosecond pulse voltage[J]. Acta Physica Sinica, 2013, 62(12): 334-344.
[19] Wang Zheming, Xu Hongyun, Zhou You, et al.Numerical modeling of positive streamer propagation in alternative natural ester and traditional naphthenic oil under sub-microsecond pulsed voltages[J]. Journal of Physics D Applied Physics, 2023, 56(34): 344004.
[20] 施健, 司马文霞, 杨庆, 等. 纳米粒子对变压器油中流注发展过程影响的仿真分析[J]. 高电压技术, 2015, 41(2): 424-431.
Shi Jian, Sima Wenxia, Yang Qing, et al.Simulation analysis of the effect of nanoparticles on streamer development in transformer oil[J]. High Voltage Engineering, 2015, 41(2): 424-431.
[21] Wang Feng, Liang Kaibin, Zhong Lipeng, et al.Effect of metal ions and suspended particles on streamer propagation[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2023, 30(3): 1154-1161.
[22] 李显东, 何桦, 肖天飞, 等. 液相扰动对水中预击穿过程的影响[J]. 中国电机工程学报, 2022, 42(10): 3846-3853, 中插31.
Li Xiandong, He Hua, Xiao Tianfei, et al. Influence of liquid phase disturbance on underwater pre-breakdown process[J]. Proceedings of the CSEE, 2022, 42(10): 3846-3853, 中插31.
[23] 李显东, 刘毅, 周古月, 等. 针-板电极下水中亚音速流注形态与发展过程[J]. 中国电机工程学报, 2018, 38(5): 1562-1571.
Li Xiandong, Liu Yi, Zhou Guyue, et al.Morphology and development of underwater subsonic streamer under needle to plane electrodes[J]. Proceedings of the CSEE, 2018, 38(5): 1562-1571.
[24] Sun Anbang, Huo Chao, Zhuang Jie.Formation mechanism of streamer discharges in liquids: a review[J]. High Voltage, 2016, 1(2): 74-80.
[25] Liang Suning, Wang Feipeng, Huang Zhengyong, et al.Significantly improved electrical breakdown strength of natural ester liquid dielectrics by doping ultraviolet absorbing molecules[J]. IEEE Access, 2019, 7: 73448-73454.
[26] 李向荣, 王飞鹏, 黄正勇, 等. 光电离对天然酯绝缘油流注放电影响规律[J]. 电工技术学报, 2023, 38(12): 3350-3365.
Li Xiangrong, Wang Feipeng, Huang Zhengyong, et al.Impact of photoionization on streamer discharge in natural ester insulating oil[J]. Transactions of China Electrotechnical Society, 2023, 38(12): 3350-3365.
[27] Madshaven I, Hestad O L, Unge M, et al.Photoionization model for streamer propagation mode change in simulation model for streamers in dielectric liquids[J]. Plasma Research Express, 2020, 2(1): 015002.
[28] Wang Kaizheng, Wang Feipeng, Li Jian, et al.Synthesis of trimethylolpropane fatty acid triester as a high performance electrical insulating oil[J]. Industrial Crops and Products, 2019, 142: 111834.
[29] Lesaint O, Gournay P.On the gaseous nature of positive filamentary streamers in hydrocarbon liquids. I: Influence of the hydrostatic pressure on the propagation[J]. Journal of Physics D: Applied Physics, 1994, 27(10): 2111-2116.
[30] Gournay P, Lesaint O.On the gaseous nature of positive filamentary streamers in hydrocarbon liquids. II: propagation, growth and collapse of gaseous filaments in pentane[J]. Journal of Physics D Applied Physics, 1994, 27(10): 2117-2127.
[31] 安大炜. 针-板电晕放电特性及空间电荷迁移规律研究[D]. 重庆: 重庆大学, 2017.
An Dawei.Study on needle-plate corona discharge and migration characteristics of ion space charge[D]. Chongqing: Chongqing University.
[32] O'Sullivan F M.A model for the initiation and propagation of electrical streamers in transformer oil and transformer oil based nanofluids[D]. Cambridge: Massachusetts Institute of Technology, 2007.
[33] Devins J C, Rzad S J, Schwabe R J.Breakdown and prebreakdown phenomena in liquids[J]. Journal of Applied Physics, 1981, 52(7): 4531-4545.
[34] 陈刚, 李剑, 黄正勇, 等. 考虑载流子密度扰动的植物绝缘油中初始流注放电仿真[J]. 中国电机工程学报, 2021, 41(3): 1176-1184.
Chen Gang, Li Jian, Huang Zhengyong, et al.Simulation of streamer discharge considering carrier density fluctuation in vegetable insulating oil[J]. Proceedings of the CSEE, 2021, 41(3): 1176-1184.
[35] 郑含博, 杨杭, 凤永吉, 等. 雷电冲击下天然酯的长间隙击穿特性仿真研究[J]. 电工技术学报, 2023, 38(23): 6451-6460.
Zheng Hanbo, Yang Hang, Feng Yongji, et al.Simulation Study on Long Gap Breakdown Characteristics of Natural Esters under Lightning Impulse[J]. Transactions of China Electrotechnical Society, 2023, 38(23): 6451-6460.
[36] Qian J, Joshi R P, Schamiloglu E, et al.Analysis of polarity effects in the electrical breakdown of liquids[J]. Journal of Physics D: Applied Physics, 2006, 39(2): 359-369.
[37] Sun Anbang, Teunissen J, Ebert U.3-D particle modeling of positive streamer inception from a needle electrode in supercritical nitrogen[J]. IEEE Transactions on Plasma Science, 2014, 42(10): 2416-2417.
[38] 蒋兴良, 吴建国, 任晓东, 等. 大气压下湿度对气隙流注放电及击穿的影响[J]. 高电压技术, 2023, 49(4): 1743-1752.
Jiang Xingliang, Wu Jianguo, Ren Xiaodong, et al.Influence of humidity on air gap streamer discharge and breakdown under atmospheric pressure[J]. High Voltage Engineering, 2023, 49(4): 1743-1752.
[39] Meek J M, Craggs J D.Electrical Breakdown of Gases[M]. New York: John Wiley & Sons, 1978.
[40] Davari N, \rAstrand P O, Van Voorhis T. Field-dependent ionisation potential by constrained density functional theory[J]. Molecular Physics, 2013, 111(9/10/11): 1456-1461.
[41] 王亚超. 基于密度泛函理论的甘油三酯分子及植物绝缘油放电相关参量研究[D]. 重庆: 重庆大学, 2018.
Wang Yachao.Study on the discharge-related parameters of triglyceride molecules and vegetable insulating oils based on density functional theory[D]. Chongqing: Chongqing University, 2018.
[42] Li Xiangrong, Wang Feipeng, Wang Kaizheng, et al.Numerical evaluation on the propagation of non-breakdown streamer in natural ester under negative lightning impulse voltage via shadowgraph imaging[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2021, 28(4): 1198-1206.
[43] Hallac A, Georghiou G E, Metaxas A C.Secondary emission effects on streamer branching in transient non-uniform short-gap discharges[J]. Journal of Physics D: Applied Physics, 2003, 36(20): 2498-2509.
[44] Qureshi M I, Beroual A, Al-Ammar E A. Optical observation of streamer propagation and breakdown in seed based insulating oil under impulse voltages[J]. International Journal of Physical Sciences, 2014, 9(13): 292-301.
[45] 王琪, 王萌, 王珏, 等. 纳秒脉冲下变压器油两相流注放电仿真研究[J]. 强激光与粒子束, 2020, 32(2): 63-67.
Wang Qi, Wang Meng, Wang Jue, et al.Two-phase streamer characteristics in transformer oil under nanosecond impulses voltages[J]. High Power Laser and Particle Beams, 2020, 32(2): 63-67.
[46] 王开正. 抗老化中链脂肪酸三酯绝缘油的击穿及流注放电研究[D]. 重庆: 重庆大学, 2020.
Wang Kaizheng.Investigation on breakdown and streamer discharge of anti-aging medium-chain fatty acid triester insulating oil[D]. Chongqing: Chongqing University, 2020.
[47] Li Shi, Wang Feipeng, Wang Qiang, et al.Numerical modeling of branching-streamer propagation in ester-based insulating oil under positive lightning impulse voltage: effects from needle curvature radius[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2023, 30(1): 139-147.
[48] Liu Qiang, Wang Zhogndong.Streamer characteristic and breakdown in synthetic and natural ester transformer liquids under standard lightning impulse voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2011, 18(1): 285-294.
[49] Hizal E M, Dinçer S. Breakdown time lags and prebreakdown phenomena in transformer oil, effects of hydrostatic pressure[J]. Journal of Electrostatics, 1982, 12: 333-343.
[50] Linhjell D, Lundgaard L E, Unge M.Pressure dependent propagation of positive streamers in a long point-plane gap in transformer oil[C]//2019 IEEE 20th International Conference on Dielectric Liquids (ICDL), Roma, Italy, 2019: 1-3.
[51] Linhjell D, Lundgaard L E, Unge M, et al.Pressure-dependent propagation of streamers under step voltage in a long point-plane gap in transformer oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2020, 27(5): 1595-1603.
[52] Shen Shuhang, Liu Qiang, Wang Zhongdong.Shockwave characteristics of streamer propagation in insulating liquids under positive lightning impulse[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2021, 28(2): 493-501.