Analytical Calculation of Ripple Current on DC-Link Capacitor for Brushless DC Motor Square Wave Control System
Huang Yuanfeng1, Xu Song1, Wang Haifeng1, Meng Jing2
1. Institute of Electrical Engineering Chinese Academy of Sciences Beijing 100190 China; 2. State Grid Beijing Electric Power Corporation Beijing 100031 China
Abstract：Ripple current on DC-link capacitor is one of the key factors affecting weight and volume of brushless DC motor (BLDCM) control system. Analytical calculation of the ripple current can guide the process of choosing DC-link capacitor, and can be of help for the BLDCM control system design in practical project. For now, however, there are few studies on the calculation method of the ripple current on DC-link capacitor for BLDCM square wave control system. The generation mechanism of ripple current on DC-link capacitor for BLDCM square wave control system was studied. Based on the analysis of current variation regularity during commutation processes of BLDCM, the analytical expressions of effective value, average value and instantaneous value of DC-link current were derived. The exact expression of the ripple current on DC-link capacitor for BLDCM square wave control system was obtained finally, and the expression accuracy was validated by simulation and test result.
黄元峰, 徐松, 王海峰, 孟静. 直流无刷电机方波控制系统母线电容纹波电流的分析计算[J]. 电工技术学报, 2018, 33(19): 4544-4552.
Huang Yuanfeng, Xu Song, Wang Haifeng, Meng Jing. Analytical Calculation of Ripple Current on DC-Link Capacitor for Brushless DC Motor Square Wave Control System. Transactions of China Electrotechnical Society, 2018, 33(19): 4544-4552.
[1] 张长庚, 杨庆新, 李永健. 电工软磁材料旋转磁滞损耗测量及建模[J]. 电工技术学报, 2017, 32(11): 208-216. Zhang Changgeng, Yang Qingxin, Li Yongjian. Measurement and modeling of rotational hysteresis loss of electric soft magnetic material[J]. Transactions of China Electrotechnical Society, 2017, 32(11): 208-216. [2] 陈丽香, 解志霖, 王雪斌. 低速大转矩永磁电机的转子散热问题[J]. 电工技术学报, 2017, 32(7): 40-48. Chen Lixiang, Xie Zhilin, Wang Xuebin. The rotor heat dissipation problem of low speed and high torque permanent magnet motor[J]. Transactions of China Electrotechnical Society, 2017, 32(7): 40-48. [3] 韩雪岩, 张华伟, 徐昕, 等. 基于计算流体力学的非晶合金轴向磁通永磁电机冷却系统设计[J]. 电工技术学报, 2017, 32(20): 189-197. Han Xueyan, Zhang Huawei, Xu Xin, et al. Design of cooling system for amorphous alloy axial flux permanent magnet motor based on CFD[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 189-197. [4] 朱高嘉, 朱英浩, 朱建国, 等. 基于有限公式法和流固耦合的永磁牵引电动机冷却系统设计与分析[J]. 电工技术学报, 2017, 32(5): 70-77. Zhu Gaojia, Zhu Yinghao, Zhu Jianguo, et al. Thermal analysis and cooling system design of a permanent magnet tractionmotor using computational fluid dynamics and cell method[J]. Transactions of China Electrotechnical Society, 2017, 32(5): 70-77. [5] 张凤阁, 杜光辉, 王天煜, 等. 高速电机发展与设计综述[J]. 电工技术学报, 2016, 31(7): 1-18. Zhang Fengge, Du Guanghui, Wang Tianyu, et al. Review on development and design of high speed machine[J]. Transactions of China Electrotechnical Society, 2016, 31(7): 1-18. [6] 马伟明, 王东, 程思为, 等. 高性能电机系统的共性基础科学问题与技术发展前沿[J]. 中国电机工程学报, 2016, 36(8): 2025-2036. Ma Weiming, Wang Dong, Cheng Siwei, et al. Common basic scientific problems and development of leading-edge technology of high performance motor system[J]. Proceedings of the CSEE, 2016, 36(8): 2025-2036. [7] 林黄达, 王东, 程思为, 等. 环形绕组无刷直流电机负载换向的解析模型[J]. 电工技术学报, 2017, 32(9): 40-47.Lin Huangda, Wang Dong, Cheng Siwei, et al. Analytical model of load commutation of the circular winding brushless DC machine[J]. Transactions of China Electrotechnical Society, 2017, 32(9): 40-47. [8] 陈云云, 朱孝勇, 全力, 等. 基于参数敏感度的双凸极永磁型双定子电机的优化设计和性能分析[J]. 电工技术学报, 2017, 32(8): 160-167. Chen Yunyun, Zhu Xiaoyong, Quan Li, et al. Parameter sensitivity optimization design and performance analysis of double salient permanent magnet double stator machine[J]. Transactions of China Electrotechnical Society, 2017, 32(8): 160-167. [9] 谢江华, 张方华, 张帅, 等. 基于载波移相控制的高功率密度双降压式全桥逆变器[J]. 电工技术学报, 2016, 31(13): 1-9. Xie Jianghua, Zhang Fanghua, Zhang Shuai, et al. A high power density dual-buck full-bridge inverter based on carrier phase-shifted control[J]. Transactions of China Electrotechnical Society, 2016, 31(13): 1-9. [10] Yeongrack S, Jungik H.Direct power control of a three-phase inverter for grid input current shaping of a single-phase diode rectifier with a small DC-link capacitor[J]. IEEE Transactions on Power Electronics, 2015, 30(7): 3794-3803. [11] Kim S, Julki S.Induction motor control with a small DC-link capacitor inverter fed by three-phase diode front-end rectifiers[J]. IEEE Transactions on Power Electronics, 2015, 30(5): 2713-2720. [12] Hojoon S, Youngho C, Yeongrack S, et al.Single-phase grid-connected motor drive system with DC-link shunt compensator and small DC-link capacitor[J]. IEEE Transactions on Power Electronics, 2017, 32(2): 1268-1278. [13] Zeng Zhiyong, Zheng Weiyi, Zhao Rongxiang.Space-vector-based hybrid PWM strategy for reduced DC-link capacitor current stress in the postfault grid-connected three-phase rectifier[J]. IEEE Transactions on Industrial Electronics, 2016, 63(8): 4989-5000. [14] Yeongrack S, Jungik H.Discontinuous grid current control of motor drive system with single-phase diode rectifier and small DC-link capacitor[J]. IEEE Transactions on Power Electronics, 2017, 32(2): 1324-1334. [15] 李红梅, 候书寒, 姚宏洋. 基于纹波电流计算的面装式永磁同步电机驱动系统逆变器死区补偿[J]. 电工技术学报, 2017, 32(增刊2): 34-41. Li Hongmei, Hou Shuhan, Yao Hongyang. The inverter dead-time compensation of surface mounted permanent magnet synchronous motor drive system based on ripple current calculation[J]. Transactions of China Electrotechnical Society, 2017, 32(S2): 34-41. [16] 应婷, 张宇, 王坚, 等. 直流母线支撑电容纹波电流研究[J]. 大功率变流技术, 2015(1): 15-19. Ying Ting, Zhang Yu, Wang Jian, et al. Research on the ripple current of support capacitor for DC bus[J]. High Power Converter Technology, 2015(1): 15-19. [17] 王正, 于新平. 逆变电源直流母线纹波电流分析与抑制研究[J]. 电力电子技术, 2013, 47(3): 93-95. Wang Zheng, Yu Xinping. Analysis and inhibition studies of the DC-bus ripple of inverter power supply[J]. Power Electronics, 2013, 47(3): 93-95. [18] 赵逸众. 两象限变频器直流电容纹波电流分析与抑制研究[J]. 电子设计工程, 2015, 23(7): 134-137. Zhao Yizhong. Analysis and inhibition studies of the ripple current on the DC capacitor of two quadrant converter[J]. Electronic Design Engineering, 2015, 23(7): 134-137. [19] Kolar J W, Round S D.Analytical calculation of the RMS current stress on the DC-link capacitor of voltage-PWM converter systems[J]. IEEE Proceedings-Electric Power Applications, 2006, 153(4): 535-543. [20] 李鲲鹏, 胡虔生, 黄允凯. 计及绕组电感的永磁无刷直流电动机电路模型及其分析[J]. 中国电机工程学报, 2004, 24(1): 76-80.Li Kunpeng, Hu Qiansheng, Huang Yunkai. The circuit model of the permanent-magnet brushless DC motor allowing for its windings inductances and its analysis[J].Proceedings of the CSEE, 2004, 24(1): 76-80. [21] 余莉, 刘合祥, 易龙芳. 永磁无刷直流电机电路计算模型及其换相分析[J]. 微电机, 2010, 43(10): 6-9. Yu Li, Liu Hexiang, Yi Longfang. The circuit model of permanent magnet brushless DC motor and analysis of the alternated phase[J]. Micromotors, 2010, 43(10): 6-9. [22] 王晋, 陶桂林, 周理兵, 等. 基于换相过程分析的无刷直流电动机机械特性的研究[J]. 中国电机工程学报, 2005, 25(14): 141-145.Wang Jin, Tao Guilin, Zhou Libing, et al. Research on the mechanical characteristic of brushless DC motors based on the analysis of phase commutation [J].Proceedings of the CSEE, 2005, 25(14): 141-145. [23] 谭建成. 无刷直流电动机换相分析和电流转矩解析表达式[J]. 微电机, 2010, 43(5): 13-18. Tan Jiancheng. Commutation process analysis of brushless DC motor and analytical expression of average current and average electromagnetic torque[J]. Micromotors, 2010, 43(5): 13-18. [24] Kolar J W, Ertl H, Zach F C, et al.A novel concept for regenerative braking of PWM-VSI drives employing a loss-free braking resistor[C]//Proceedings of APEC 97-Applied Power Electronics Conference, Atlanta, GA, USA, 1997: 297-305. [25] 陈渊伟. 车用DC-Link电容器的选择和主要电参数估算[J]. 电子世界, 2016(12): 98-99. Chen Yuanwei. Parameter estimation and selection of DC-link capacitor on electric vehicle[J]. Electronics World, 2016(12): 98-99.
2018, Vol. 33 
