Effect of Surface Foreign Matters on the Insulation Property of 252kV Gas Insulated Switchgear Basin Insulators
Zhuang Cheng1, Zeng Jianbin1, Yuan Chuanzhen2
1. School of Electrical Engineering and Automation Xiamen University of Technology Xiamen 361000 China; 2. Xu Ji (Xiamen) Intelligent Power Equipment Co. Ltd Xiamen 361000 China
Abstract This paper establishes a model to evaluate the influence on local electric field caused by five common foreign matters on the surface of 252kV GIS basin insulator, such as metal scraps, hair, paper scraps, silicone grease and sand. Later, a series of simulations have been carried out using three-dimensional finite element analysis software. An insulation test platform was built in order to verify the validity of results of the theoretical analysis. On this test platform, lightning impulse, power frequency withstand voltage and partial discharge tests were carried out under different positions (high, medium and low potential areas) and different arrangements (linear, scattered) of foreign matters adhered to the surface of basin insulator. The experimental results illustrate that when the small size of a single metal scrap adheres to the insulator convex high potential area, it does not cause the breakdown phenomenon. When the metal scraps are in the low potential area of convex of insulator, the linear arrangement of the metal scraps is more likely to cause insulation breakdown. Four types of non-metallic foreign matters have less influence on the insulation property of the insulators. The measured discharge capacity of the sand is significantly higher than other three types of non-metallic foreign matters, which indicates that the possibility of insulation fault will increase significantly after the long-term induced accumulation of sand-type foreign matters.
Zhuang Cheng,Zeng Jianbin,Yuan Chuanzhen. Effect of Surface Foreign Matters on the Insulation Property of 252kV Gas Insulated Switchgear Basin Insulators[J]. Transactions of China Electrotechnical Society, 2019, 34(20): 4208-4216.
[1] 季洪鑫, 李成榕, 庞志开, 等. 电压波形对GIS自由金属颗粒放电特性的影响[J]. 电工技术学报, 2016, 31(13): 218-226. Ji Hongxin, Li Chengrong, Pang Zhikai, et al.Influence of voltage waveform on the discharge characteristics of GIS free metal particles[J]. Transactions of China Electrotechnical Society, 2016, 31(13): 218-226. [2] 杜晓平, 李涛, 陈瑞林. 一起220kV GIS闪络故障分析及建议[J].电力系统保护与控制, 2010, 38(3): 128-129, 132. Du Xiaoping, Li Tao, Chen Ruilin.A 220kV GIS flashover fault analysis and recommendations[J]. Power System Protection and Control, 2010, 38(3): 128-129, 132. [3] Wen Tao, Zhang Qiaogen, Ma Jingtan, et al.Research on the detecting effectiveness of on-site lightning impulse test for GIS equipment with insulation defects[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(2): 551-558. [4] 杨堃. 国家电网公司2015年开关设备运行情况及近十年GIS故障专题分析[R]. 北京: 中国电力科学研究院, 2015. [5] Ren M, Dong M, Ye R, et al.Partial discharge test under standard oscillating impulses on a gas- insulated bus with artificial metal particle defects on the insulator surface[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(6): 3593-3601. [6] 黄辉, 张欣, 秦逸帆, 等. 雷电冲击下金属污染物对GIS中盆式绝缘子闪络特性的影响[J]. 高压电器, 2016, 52(4): 111-116. Huang Hui, Zhang Xin, Qin Yifan, et al.Effect of metal contaminants on flashover characteristics of basin insulators in GIS[J]. High Voltage Apparatus 2016, 52(4): 111-116. [7] 夏小飞. 表面金属异物引起盆式绝缘子局部放电的研究[J]. 电气技术, 2016, 17(5): 54-58. Xia Xiaofei.Research on partial discharge of basin insulators caused by foreign metal on the surface[J]. Electrical Technology, 2016, 17(5): 54-58. [8] 李岩松, 李世延, 仇仔来, 等. GIS绝缘子表面固定金属颗粒放电特性研究[J]. 电测与仪表, 2014, 51(15): 33-36. Li Yansong, Li Shiyan, Qiu Zailai, et al.Study on discharge characteristics of fixed metal particles on GIS insulators[J]. Electrical measurement and instrumentation, 2014, 51(15): 33-36. [9] 李伯涛. 直流GIL中金属微粒对绝缘子表面电荷积聚的作用机制研究[D]. 北京: 华北电力大学, 2016. [10] 王峰. 252kV GIS五种绝缘故障诱发因素的模拟计算及试验研究[D]. 山东: 山东大学, 2015. [11] Huicheng Z, Xu C, Jinbo Z, et al.On-line monitoring device for operating state of GIS isolating switch operating mechanism[C]//IEEE 2nd International Conference on Power and Renewable Energy, Chengdu, China, 2017: 306-309. [12] 金立军, 张明锐, 刘卫东. GIS局部放电故障诊断试验研究[J]. 电工技术学报, 2005, 20(11): 88-92. Jin Lijun, Zhang Mingrui, Liu Weidong.Study on partial discharge fault diagnosis of GIS[J]. Transa- ctions of China Electrotechnical Society, 2005, 20(11): 88-92. [13] 任敬国, 辜超, 师伟, 等. 1100kV GIS设备主回路绝缘试验电气参量估算方法研究[J]. 电力系统保护与控制, 2018, 46(3): 103-109. Ren Jingguo, Gu Chao, Shi Wei, et al.Research on estimation method of electrical parameters for insulation test of 1100kV GIS equipment[J]. Power System Protection and Control, 2018, 46(3): 103-109. [14] 王涛云, 马宏忠, 崔杨柳, 等. 基于可拓分析和熵值法的GIS状态评估[J]. 电力系统保护与控制, 2016, 44(8): 115-120. Wang Taoyun, Ma Hongzhong, Cui Yangliu, et al.Condition evaluation of gas insulated switchgear based on extension analysis and entropy method[J]. Power System Protection and Control, 2016, 44(8): 115-120. [15] 唐炬, 杨东, 曾福平, 等. 基于分解组分析的SF6设备绝缘故障诊断方法与技术的研究现状[J]. 电工技术学报,2016, 31(20): 41-54. Tang Ju, Yang Dong, Zeng Fuping, et al.Research status of SF6 insulation equipment fault diagnosis method and technology based on decomposed com- ponents analysis[J]. Transactions of China Electro- technical Society, 2016, 31(20): 41-54. [16] 唐念, 乔胜亚, 李丽, 等. HF和H2S作为气体绝缘组合电器绝缘缺陷诊断特征气体的有效性[J]. 电工技术学报, 2017, 32(19): 202-211. Tang Nian, Qiao Shengya, Li Li, et al.Validity of HF and H2S as target gases of insulation monitoring in gas insulated switchgear[J]. Transactions of China Electrotechnical Society, 2017, 32(19): 202-211. [17] 黎斌. 高压电器设计[M]. 北京: 机械工业出版社, 2015.
2019, Vol. 34 
