基于三绕组耦合电感与改进型开关电容的单开关高增益DC-DC变换器

doi:10.19595/j.cnki.1000-6753.tces.251069

Abstract
Figure/Table
References (0)
Related Citation (2)

Download: PDF (776 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

To address the practical limitations of non-isolated DC-DC converters, including insufficient voltage step-up capability, high voltage stress on switches, and relatively low efficiency, this paper proposes a high gain single-switch DC-DC converter based on a three-winding coupled inductor (TWCI) and a modified switched-capacitor (HSS-TWCI-MSC). In the proposed topology, the input inductor of the conventional Boost converter is replaced by a TWCI, and a switched-capacitor is integrated with a passive clamping branch to form a novel voltage multiplier cell. This structure significantly enhances voltage gain while effectively absorbing leakage energy from the leakage inductor, thereby reducing voltage stress on the switch and diodes. Furthermore, the leakage inductor of the TWCI enables zero-current switching (ZCS) for switch, which helps reduce switching losses and mitigates the reverse recovery issue of diodes, thus improving the overall system efficiency and reliability.
The paper provides a theoretical analysis of the proposed converter and its operating modes under continuous conduction modes. The key performance metrics such as voltage gain, voltage/current stresses, and RMS currents are derived. Additionally, the boundary condition of the proposed converter in DCM is analyzed, and an expression for the critical magnetizing inductor is presented. Moreover, the comprehensive loss analysis is established, evaluating the dominant loss contributions from the switch, diodes, capacitors, and magnetic components. A performance comparison with several state-of-the-art high-gain converters in the references reveals that the proposed converter achieves higher voltage gain with lower voltage stress and a more compact structure under the same input and output conditions.
To validate the theoretical analysis and assess the practical feasibility, a 400?W laboratory prototype was designed and implemented with an input voltage of 36?V, output voltage of 400?V, and a switching frequency of 50?kHz. Experimental results demonstrate that the proposed converter achieves a peak efficiency of 97.20% under 250W load and maintains an efficiency of 96.92% at full load. Measured waveforms confirm key characteristics such as ZCS operation of the switch and low voltage stress. Furthermore, loss distribution analysis shows that the majority of losses are concentrated in the diodes and magnetic components, suggesting that further improvements can be achieved through optimized component selection and magnetic design refinement.
In summary, the proposed HSS-TWCI-MSC converter offers several compelling advantages: (1) By organically integrating the switched-capacitor used to absorb the leakage energy from the TWCI with a passive clamping branch, a novel voltage multiplier cell is constructed. This configuration not only effectively enhances the voltage gain but also significantly suppresses the voltage stress on semiconductor devices. (2) By combining the TWCI with the modified switched-capacitor, the proposed HSS-TWCI-MSC achieves high voltage gain while maintaining low voltage stress, thereby enabling the use of cost-effective and high-performance components. (3) By utilizing the leakage inductor of TWCI, the switch achieves ZCS turn-on, effectively reducing switching losses. Meanwhile, the leakage inductor also limits the current falling rate of diodes, alleviating their reverse recovery issues and reducing associated losses, thereby improving overall system efficiency. (4) The proposed HSS-TWCI-MSC converter employs only one switch, resulting in a simple control strategy that is beneficial for system implementation and stable operation.

Key words： High gain single-switch converter modified switched-capacitor three-winding coupled inductor zero current switching

Received: 18 June 2025

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Li Chao
	Li Hongzhu
	Sun Xuanjin

Cite this article:

Li Chao,Li Hongzhu,Sun Xuanjin. High Gain Single-Switch DC-DC Converter with Three-Winding Coupled Inductor and Modified Switched-Capacitor[J]. Transactions of China Electrotechnical Society, 0, (): 20251069-20251069.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.251069 OR https://dgjsxb.ces-transaction.com/EN/Y0/V/I/20251069

[1] 王强, 党牛, 蒋子龙, 等. 碳中和背景下能源转型研究综述与展望[J]. 地理学报, 2025, 80(3): 586-604.
Wang Qiang, Dang Niu, Jiang Zilong, et al.A review and outlook on energy transition research in the context of carbon neutrality[J]. Acta Geographica Sinica, 2025, 80(3): 586-604.
[2] 李超. 三绕组耦合电感高增益变换器的关键技术研究[D]. 阜新:辽宁工程技术大学, 2024.
Li Chao.Research on the key technologies of high step-up DC/DC converter with the three-winding coupled inductor[D]. Fuxin: Liaoning Technical University, 2024.
[3] Schmitz L, Martins D C, Coelho R F.Generalized high step-up DC-DC boost-based converter with gain cell[J]. IEEE Transactions on Circuits and Systems I: Regular Papers, 2017, 64(2): 480-493.
[4] Habibi S, Rahimi R, Ferdowsi M, et al.A general method for analyzing single-switch step- up DC-DC converters with switched-capacitor cells and an output inductor[J]. IEEE Journal of Emerging and Selected Topics in Industrial Electronics, 2024, 5(3): 858-867.
[5] 陈复. 基于开关电容网络的直流变换器研究[D]. 重庆: 重庆大学, 2015.
[6] Salvador M A, de Andrade J M, Lazzarin T B, et al. Nonisolated high-step-up DC-DC converter derived from switched-inductors and switched-capacitors[J]. IEEE Transactions on Industrial Electronics, 2020, 67(10): 8506-8516.
[7] 赵清林, 付浩辉, 王子博, 等. 定频脉冲宽度调制的宽输入推挽正激谐振变换器[J]. 电网技术, 2024, 48(10): 4317-4329.
Zhao Qinglin, Fu Haohui, Wang Zibo, et al.A push-pull forward resonant converter with wide input based on fixed frequency pulse width modulation[J]. Power System Technology, 2024, 48(10): 4317-4329.
[8] 王智爽, 王萍, 李博, 等. 一族改进型开关电感DC/DC变换器[J]. 中国电机工程学报, 2022, 42(12): 4526-4536.
Wang Zhishuang, Wang Ping, Li Bo, et al.A family of improved active switched-inductor based DC/DC converters[J]. Proceedings of the CSEE, 2022, 42(12): 4526-4536.
[9] 丁杰, 尹华杰, 赵世伟. 反激式隔离型高增益DC/DC变换器[J]. 电源学报, 2022, 20(2): 26-33.
Ding Jie, Yin Huajie, Zhao Shiwei.Flyback isolated high step-up DC/DC converter[J]. Journal of Power Supply, 2022, 20(2): 26-33.
[10] Dwari S, Jayawant S, Beechner T, et al.Dynamics characterization of coupled-inductor boost DC-DC converters[C]//2006 IEEE Workshops on Computers in Power Electronics, Troy, NY, USA, 2006: 264-269.
[11] Zheng Yifei, Smedley K M.Analysis and design of a single-switch high step-up coupled-inductor boost converter[J]. IEEE Transactions on Power Electronics, 2020, 35(1): 535-545.
[12] 李洪珠, 包雨林, 李超, 等. 双耦合电感磁集成开关电容二次型高增益变换器[J]. 电工技术学报, 2025, 40(12): 3964-3976.
Li Hongzhu, Bao Yulin, Li Chao, et al.High step-up quadratic converter integrated switched capacitor and two group of coupled inductor along with magnetic integration[J]. Transactions of China Electrotechnical Society, 2025, 40(12): 3964-3976.
[13] 周鸿彦, 何良宗, 杨泽龙, 等. IPOS型高增益DC/DC变换器[J]. 中国电机工程学报, 2024, 44(增刊1): 306-317.
Zhou Hongyan, He Liangzong, Yang Zelong, et al.IPOS high gain DC/DC converter[J]. Proceedings of the CSEE, 2024, 44(S1): 306-317.
[14] 王哲, 李驰, 郑泽东, 等. 一种基于耦合电感的高增益软开关谐振变换器[J]. 电工技术学报, 2024, 39(1): 194-205.
Wang Zhe, Li Chi, Zheng Zedong, et al.A high step-up ZVS/ZCS resonant converter based on coupled inductor[J]. Transactions of China Electrotechnical Society, 2024, 39(1): 194-205.
[15] 孙瑄瑨, 荣德生, 王宁. 具有谐振软开关的高增益耦合电感组合Boost-Zeta变换器[J]. 电工技术学报, 2024, 39(6): 1830-1842.
Sun Xuanjin, Rong Desheng, Wang Ning.High step-up integrated boost-zeta converter with coupled inductor and resonant soft-switching[J]. Transactions of China Electrotechnical Society, 2024, 39(6): 1830-1842.
[16] 程诗伟, 赵世伟. 双开关二次型结构的耦合电感高增益DC-DC变换器[J]. 电源学报, 2024, 22(4): 29-39.
Cheng Shiwei, Zhao Shiwei.Dual-switch quadratic high-gain DC-DC converter with coupled inductor[J]. Journal of Power Supply, 2024, 22(4): 29-39.
[17] 罗朋, 潘锦超, 洪濬哲, 等. 用于直流微电网的高升压变换器设计及效率优化[J]. 电工技术学报, 2023, 38(20): 5530-5546.
Luo Peng, Pan Jinchao, Hong Junzhe, et al.Design and efficiency optimization of a high step-up converter for DC microgird[J]. Transactions of China Electrotechnical Society, 2023, 38(20): 5530-5546.
[18] Sadeghpour D, Bauman J.A generalized method for comprehension of switched-capacitor high step-up converters including coupled inductors and voltage multiplier cells[J]. IEEE Transactions on Power Electronics, 2022, 37(5): 5801-5815.
[19] 李洪珠, 陈星星, 李超, 等. 带倍压单元的有源开关电感高增益变换器及其磁集成[J]. 电工技术学报, 2025, 40(7): 2191-2202.
Li Hongzhu, Chen Xingxing, Li Chao, et al.Active switched inductor high step-up converter with voltage multiplier cell and magnetic integration[J]. Transactions of China Electrotechnical Society, 2025, 40(7): 2191-2202.
[20] Sun Xuanjin, Rong Desheng, Wang Ning.A high step-up integrated buck-boost-zeta converter using three-winding coupled inductor with current sharing considered[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(3): 3323-3334.
[21] Fang Xupeng, Lai Xuewen, Wang Xuchao, et al.The high voltage gain coupled inductor boost-zeta DC/DC converter[J]. CPSS Transactions on Power Electronics and Applications, 2024, 9(2): 127-140.
[22] 熊振阳, 尹靖元, 霍群海, 等. 基于开关电容与耦合电感倍压单元的高增益直流变换器[J]. 北京航空航天大学学报, 2025, 51(8): 2652-2662.
Xiong Zhenyang, Yin Jingyuan, Huo Qunhai, et al.A high gain DC-DC converter based on switched capacitor and coupled inductor voltage multiplier unit[J]. Journal of Beijing University of Aeronautics and Astronautics, 2025, 51(8): 2652-2662.
[23] Ding Jie, Zhao Shiwei, Gao Shuang, et al.A single-switch high step-up DC-DC converter based on three-winding coupled inductor and pump capacitor unit[J]. IEEE Transactions on Power Electronics, 2022, 37(3): 3053-3061.
[24] 雷浩东, 郝瑞祥, 游小杰, 等. 基于开关电容和三绕组耦合电感的高电压增益DC-DC变换器[J]. 电工技术学报, 2020, 35(17): 3666-3677.
Lei Haodong, Hao Ruixiang, You Xiaojie, et al.High voltage gain DC-DC converter with switched-capacitor and three-winding coupled inductor[J]. Transactions of China Electrotechnical Society, 2020, 35(17): 3666-3677.
[25] Li Chao, Li Hongzhu, Wang Ning, et al.A full soft-switching high step-up DC/DC converter with active switched inductor and three-winding coupled inductor[J]. IEEE Transactions on Power Electronics, 2023, 38(10): 13133-13146.
[26] Liang T J, Luo Peng, Chen Kaihui.A high step-up DC-DC converter with three-winding coupled inductor for sustainable energy systems[J]. IEEE Transactions on Industrial Electronics, 2022, 69(10): 10249-10258.