基于驱动电压主动切换的Si/SiC混合器件结温波动平滑控制

doi:10.19595/j.cnki.1000-6753.tces.241233

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (7895 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The Si/SiC hybrid switch has low cost and low loss advantages for supporting the development of large capacity and high reliability of power electronic equipment. The change of load current causes a significant fluctuation of the junction temperature of SiC MOSFET, and then the improvement of the overall life of the Si/SiC hybrid switch is restricted. Therefore, this paper proposes a smooth control strategy for junction temperature fluctuation based on active switching of drive voltage. The junction temperature fluctuation of the SiC MOSFET in the Si/SiC hybrid switch is significantly smoothed. The difference in junction temperature fluctuation between the SiC MOSFET and Si IGBT is also reduced, and the remaining service life of the whole hybrid switch is effectively extended.
Firstly, the influence of drive voltage on the switching trajectory of the hybrid switch is analyzed. The loss model of the hybrid switch, considering the influence of drive voltage, is established. Secondly, based on the loss distribution of the hybrid switch under different drive voltage combinations, four drive voltage modes are determined to correspond to the four load intervals divided by the equal rated current. Combined with the designed drive voltage autonomous switching circuit, a complete set of the Si/SiC hybrid switch thermal management schemes is formed. Finally, the designed drive circuit board is mounted on a single-phase inverter. The drive voltage switching function of the drive circuit board and the effect of the proposed strategy on the junction temperature swing suppression are verified.
Based on the experimental platform, when the inverter runs under the load profile set, four drive voltage modes are output accurately by the designed drive voltage switching circuit according to the effective value of the load, and the sinusoidal AC current can be stably output by the single-phase inverter in each drive voltage mode. Through the proposed strategy, under any load fluctuation, the smoothness of the junction temperature fluctuation of MOSFET is more than 30%, and the difference in junction temperature fluctuation between MOSFET and IGBT is reduced by more than 49%.
The following conclusions can be drawn. (1) The drive voltage affects the current trajectory, voltage trajectory, and steady-state shunt between MOSFET and IGBT during the turn-on process of the hybrid switch. The drive voltage has multiple degrees of freedom to control the loss of the hybrid switch. (2) In the Si/SiC hybrid switch, the junction temperature of MOSFET is greatly affected by the drive voltage regulation, but the junction temperature of IGBT is less affected. (3) Through the switching of four drive voltage modes in load current intervals of V_GM=15 V, V_GT=15 V; V_GM=20 V, V_GT=15 V; V_GM=20 V, V_GT=20 V; V_GM=15 V, V_GT=20 V, the loss of MOSFET can be reduced under heavy load conditions to reduce the junction temperature and increased under light load conditions to increase the junction temperature. (4) Through the proposed strategy, the junction temperature fluctuation of MOSFET can be smoothed by more than 30% under any load fluctuation, and the junction temperature fluctuation’s amplitude difference between MOSFET and IGBT is reduced by up to 84.4%. The service life of the Si/SiC hybrid switch is extended.

Key words： Si/SiC hybrid switch SiC MOSFET smoothing of junction temperature fluctuation drive voltage mode fluctuation of load

Received: 12 July 2024

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Bai Dan
	Tu Chunming
	Long Liu
	Xiao Fan
	Xiao Biao

Cite this article:

Bai Dan,Tu Chunming,Long Liu等. Smooth Control For Junction Temperature Fluctuation of Si/SiC Hybrid Switch Based on Active Switching of Drive Voltage[J]. Transactions of China Electrotechnical Society, 2025, 40(16): 5068-5080.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.241233 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I16/5068

[1] 肖标, 郭祺, 涂春鸣, 等. 面向开关时序与驱动电压自主协同调控的SiC/Si混合开关驱动电路[J/OL]. 电工技术学报, 1-12[2024-07-11]. https://doi.org/10.19595/j.cnki.1000-6753.tces.240081.
Xiao Biao, Guo Qi, Tu Chunming, et al. SiC/Si hybrid switch drive circuit with autonomous and coordinated control of switching sequences and driving volta- ges[J/OL]. Transactions of China Electronical Society, 1-12 [2024-07-11]. https://doi.org/10.19595/j.cnki.1000-6753.tces.240081.
[2] Emon A I, Yuan Zhao, Mirza A B, et al.1200 V/ 650 V/160 A SiC Si IGBT 3L hybrid T-type NPC power module with enhanced EMI shielding[J]. IEEE Transactions on Power Electronics, 2021, 36(12): 13660-13673.
[3] 任鹏, 涂春鸣, 侯玉超, 等. 基于Si和SiC器件的混合型级联多电平变换器及其调控优化方法[J]. 电工技术学报, 2023, 38(18): 5017-5028.
Ren Peng, Tu Chunming, Hou Yuchao, et al.Research on a hybrid cascaded multilevel converter based on Si and SiC device and its control optimization method[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 5017-5028.
[4] Peng Zishun, Wang Jun, Liu Zeng, et al.Adaptive gate delay-time control of Si/SiC hybrid switch for efficiency improvement in inverters[J]. IEEE Transa- ctions on Power Electronics, 2021, 36(3): 3437-3449.
[5] 赵靖英, 乔珩埔, 姚帅亮, 等. 考虑储能SOC自恢复的风电波动平抑混合储能容量配置策略[J]. 电工技术学报, 2024, 39(16): 5206-5219.
Guo Jingying, Qiao Hengpu, Yao Shuailiang, et al.Hybrid energy storage system capacity configuration strategy for stabilizing wind power fluctuation considering SOC self-recovery[J]. Transactions of China Electronical Society, 2024, 39(16): 5206-5219.
[6] 林帆, 张耀, 东琦, 等. 基于分位数插值和深度自回归网络的光伏出力概率预测[J]. 电力系统自动化, 2023, 47(9): 79-87.
Lin Fan, Zhang Yao, Dong Qi, et al.Probability prediction of photovoltaic output based on quantile interpolation and deep autoregressive network[J]. Automation of Electric Power Systems, 2023, 47(9): 79-87.
[7] 张峰, 田宇, 丁磊. 风电虚拟惯量延时的影响机理模型解析及替代性研究[J]. 电力系统自动化, 2024, 48(7): 267-276.
Zhang Feng, Tian Yu, Ding Lei.Analytical solution for influential mechanism model of virtual inertia delay of wind power and its substitutability research[J]. Automation of Electric Power Systems, 2024, 48(7): 267-276.
[8] 邓二平, 严雨行, 陈杰, 等. 功率器件功率循环测试技术的挑战与分析[J]. 中国电机工程学报, 2023, 43(13): 5132-5150.
Deng Erping, Yan Yuhang, Chen Jie, et al.Challenge and analysis of power cycle testing technology for power devices[J]. Proceedings of the CSEE, 2023, 43(13): 5132-5150.
[9] 皇甫宜耿, 宋少林, 王晓鹏, 等. 功率模块主动热控制技术研究综述[J]. 电源学报, 2024, 22(3): 118-126.
Huangfu Yigeng, Song Shaolin, Wang Xiaopeng, et al.Summary of active thermal control technology for power module[J]. Journal of Power Supply, 2024, 22(3): 118-126.
[10] Wang Yanhao, Deng Erping, Wu Lixin, et al.Influence of humidity on the power cycling lifetime of SiC MOSFETs[J]. IEEE Transactions on Com- ponents, Packaging and Manufacturing Technology, 2022, 12(11): 1781-1790.
[11] 胡震, 崔曼, 吴晓华, 等.功率器件结温主动控制及优化策略[J]. 电工技术学报, 2024, 39(18): 5732-5741.
Hu Zhen, Cui Man, Wu Xiaohua, et al.Active control and optimization strategy of junction temperature for power devices[J]. Transactions of China Electronical Society, 2024, 39(18): 5732-5741.
[12] 龙柳, 肖凡, 涂春鸣, 等. 基于热网络分区等效策略的Si/SiC混合器件耦合热参数辨识方法[J]. 电工技术学报, 2024, 39(12): 3718-3731.
Long Liu, Xiao Fan, Tu Chunming, et al.Enhanced identification approach for RC parameters of Si/SiC hybrid switches based on thermal network partition scheme[J]. Transactions of China Electrotechnical Society, 2024, 39(12): 3718-3731.
[13] 孙建平. 变流器变开关频率IGBT模块热特性研究[D]. 成都: 电子科技大学, 2022.
Sun Jianping.Study on thermal characteristics of IGBT module with variable switching frequency of converter[D]. Chengdu: University of Electronic Science and Technology of China, 2022.
[14] 张军, 管勃, 杜雄, 等. 基于寿命消耗分布规律的风电变流器IGBT模块热管理控制策略[J]. 中国电机工程学报, 2022, 42(3): 1103-1113.
Zhang Jun, Guan Bo, Du Xiong, et al.A thermal management control strategy for IGBT module in the wind power converter based on the distribution characteristics of consumed lifetime[J]. Proceedings of the CSEE, 2022, 42(3): 1103-1113.
[15] Wölfle J, Nitzsche M, Ruthardt J, et al.Junction temperature control system to increase the lifetime of IGBT-power-modules in synchronous motor drives without affecting torque and speed[J]. IEEE Open Journal of Power Electronics, 2020, 1: 273-283.
[16] Wang Cong, Tian Changgeng, Cheng Hong, et al.A PWM method of H-bridge converter with temperature rise balancing and minimization based on periodically alternating employment of power devices[J]. IEEE Transactions on Power Electronics, 2022, 37(9): 11135-11151.
[17] Desingu K, Selvaraj R, Chelliah T R.Control of reactive power for stabilized junction temperature in power electronic devices serving to a 250-MW asynchronous hydrogenerating unit[J]. IEEE Transa- ctions on Industry Applications, 2019, 55(6): 7854-7867.
[18] Peng Zishun, Wang Jun, Liu Zeng, et al.A variable- frequency current-dependent switching strategy to improve tradeoff between efficiency and SiC MOSFET overcurrent stress in Si/SiC-hybrid-switch- based inverters[J]. IEEE Transactions on Power Electronics, 2021, 36(4): 4877-4886.
[19] 杨华. Si/SiC混合并联器件特性及其逆变器应用[D]. 合肥: 安徽工业大学, 2022.
Yang Hua.Characteristics of Si/SiC hybrid parallel device and its inverter application[D]. Hefei: Anhui University of Technology, 2022.
[20] Li Zongjian, Wang Jun, Deng Linfeng, et al.Active gate delay time control of Si/SiC hybrid switch for junction temperature balance over a wide power range[J]. IEEE Transactions on Power Electronics, 2020, 35(5): 5354-5365.
[21] van der Broeck C H, Ruppert L A, Lorenz R D, et al. Methodology for active thermal cycle reduction of power electronic modules[J]. IEEE Transactions on Power Electronics, 2019, 34(8): 8213-8229.
[22] Wang Jun, Li Zongjian, Jiang Xi, et al.Gate control optimization of Si/SiC hybrid switch for junction temperature balance and power loss reduction[J]. IEEE Transactions on Power Electronics, 2019, 34(2): 1744-1754.
[23] Lüdecke C, Aghdaei A, Laumen M, et al.Balancing the switching losses of paralleled SiC MOSFETs using a stepwise gate driver[C]//2021 IEEE Energy Conversion Congress and Exposition (ECCE), Vancouver, BC, Canada, 2021: 5400-5406.
[24] 张凯, 高峰. 一种可提高IGBT可靠性的新型结温管控策略[J]. 电气传动, 2020, 50(2): 92-96.
Zhang Kai, Gao Feng.A new junction temperature control strategy which improve IGBT reliability[J]. Electric Drive, 2020, 50(2): 92-96.
[25] Ekren H B, Philipps D A, Lyng Rødal G, et al.Four level voltage active gate driver for loss and slope control in SiC MOSFETs[C]//2022 IEEE 13th International Symposium on Power Electronics for Distributed Generation Systems (PEDG), Kiel, Germany, 2022: 1-6.
[26] 邹铭锐, 曾正, 孙鹏, 等. 基于变电阻驱动的SiC器件开关轨迹协同调控[J]. 电工技术学报, 2023, 38(16): 4286-4300.
Zou Mingrui, Zeng Zheng, Sun Peng, et al.Coor- dinated switching trajectory regulation of SiC device using variable resistance gate driver[J]. Transactions of China Electrotechnical Society, 2023, 38(16): 4286-4300.
[27] 周郁明, 穆世路, 杨华, 等. Si/SiC混合开关最优门极延时及其在逆变器中的应用[J]. 电子学报, 2023, 51(6): 1468-1473.
Zhou Yuming, Mu Shilu, Yang Hua, et al.Optimal gate turn-off delay-time of Si/SiC hybrid switch and its application in inverter[J]. Acta Electronica Sinica, 2023, 51(6): 1468-1473.
[28] 蒋潇锋. Si IGBT和SiC MOSFET并联分流特性研究[D]. 重庆: 重庆大学, 2022.
Jiang Xiaofeng.Study on shunt characteristics of Si IGBT and SiC MOSFET in parallel[D]. Chongqing: Chongqing University, 2022.
[29] 涂春鸣, 韩硕, 龙柳, 等. 面向Si/SiC混合器件逆变器全寿命周期安全工作区的多开关模式主动切换策略[J]. 电力自动化设备, 2023, 43(10): 128-135.
Tu Chunming, Han Shuo, Long Liu, et al.Multi-mode active switching strategy for safe operating area of Si/SiC-hybrid-switch-based inverter throughout life cycle[J]. Electric Power Automation Equipment, 2023, 43(10): 128-135.