Abstract：As the “nerve endings” of the power grid, wireless sensor networks play a more and more important role in the construction of smart grid. How to provide energy for sensor networks stably and reliably has attracted people's attention, and magnetic field energy harvesting technology has become the most promising technology to solve this problem. However, the increase in the magnetic field strength around the power line will cause the magnetic flux density of the magnetic core to reach the maximum value, and the deep saturation of the magnetic core will cause power loss and threaten the safety of the harvester. In order to solve this problem, a power enhancement method of electromagnetic induction magnetic field energy harvester based on flux control is proposed in this paper. By adding controllable capacitor components in the circuit, the core saturation is alleviated and the energy collection power is significantly improved. The proposed magnetic field energy harvesting circuit adds a capacitor module which can change the series-parallel state between the load and the magnetic core coil, and its energy transmission process is as follows. At the beginning of each energy transfer cycle, the capacitor components are in parallel. Then, at the appropriate starting time of series, the capacitor module is controlled to be in series state, the voltage on the capacitor module is doubled, the voltage on the capacitor module is greater than the load voltage, the core voltage is reversed, and the accumulated flux is consumed. Core saturation is alleviated. Next, the control capacitor module returns to the state of parallel connection, and at the same time, the rising rate of core voltage is reduced by the larger capacitance in parallel, and the transmission time is prolonged. Simulation and experimental results show that the series start time t1, capacitance value C0 of capacitor module, load voltage Vload and primary current I1 all affect the effectiveness of the proposed method. Among them, the influence of t1 on the effect of the method is related to the voltage of the corresponding capacitor module, and the appropriate voltage of the capacitor module can give full play to the role of core reverse voltage in alleviating core saturation. C0 affects the voltage change rate of capacitor components. The large change rate will lead to the rapid saturation of the magnetic core, while the small change rate will limit the effect of this method to alleviate the magnetic core saturation. After the load voltage is enough to make the core saturated, the larger the Vload and the deeper the saturation, the better the effect of the method. When the load voltage is not enough to make the magnetic core saturated, the average output current is increased by promoting the magnetic core saturation, and then the energy harvesting power is increased. With the increase of I1, the change rate of capacitor module voltage increases, the reverse time of core voltage shortens, and the ability to alleviate core saturation decreases, which finally leads to the decrease of lifting efficiency. At this time, increasing C0 and reducing the voltage change rate of capacitor components will help to alleviate the core saturation and improve the efficiency of energy harvesting. The following conclusions can be drawn from the simulation and experimental analysis: ①The proposed method can alleviate the magnetic core saturation and improve the magnetic field energy harvesting power by adding capacitor components in the circuit and controlling its series-parallel state. ②There is the best series start time and the best capacitance value of the capacitor module to maximize the harvesting power, which increases at first and then decreases with the increase of the series start time and the capacitance value, respectively. ③When the load voltage is 5~15V, the proposed method can effectively alleviate the core saturation and improve the energy harvesting power, and the lifting effect increases with the increase of the load voltage. When the load voltage is 2~5V, the energy harvesting power is increased by promoting core saturation.④With a primary current of 4A at 50Hz, the proposed method increases the harvesting power by 36.8% to 153.2% under different constant voltage loads studied in this paper.
叶凯, 刘柱, 赵鹏博, 杨爱军, 袁欢, 王小华, 荣命哲. 一种基于磁通控制的电磁感应式磁场能量收集器功率提升方法[J]. 电工技术学报, 2023, 38(1): 37-46.
Ye Kai, Liu Zhu, Zhao Pengbo, Yang Aijun, Yuan Huan, Wang Xiaohua, Rong Mingzhe. A Power Boosting Method of Electromagnetic Induction Magnetic Field Energy Harvester Based on Magnetic Flux Control. Transactions of China Electrotechnical Society, 2023, 38(1): 37-46.
[1] 邓丰, 徐帆, 曾哲, 等. 基于多源暂态信息融合的单端故障定位方法[J]. 电工技术学报, 2022, 37(13): 3201-3212. Deng Feng, Xu Fan, Zeng Zhe, et al.Single-ended fault location method based on multi-source transient information fusion[J]. Transactions of China Electrotechnical Society, 2022, 37(13): 3201-3212. [2] 卢志刚, 李丹, 吕雪姣, 等. 含分布式电源的冰灾下配电网多故障抢修策略[J]. 电工技术学报, 2018, 33(2): 423-432. Lu Zhigang, Li Dan, Lü Xuejiao, et al.Multiple faults repair strategy under ice storm for distribution network with distributed generators[J]. Transactions of China Electrotechnical Society, 2018, 33(2): 423-432. [3] Wei Qinglai, Shi Guang, Song Ruizhuo, et al.Adaptive dynamic programming-based optimal control scheme for energy storage systems with solar renewable energy[J]. IEEE Transactions on Industrial Electronics, 2017, 64(7): 5468-5478. [4] Kim J Y, Lee J W, Jung H S, et al.High-efficiency perovskite solar cells[J]. Chemical Reviews, 2020, 120(15): 7867-7918. [5] 马天智. 基于光伏获能的WSNs节点能量管理策略[D]. 重庆: 重庆大学, 2018. [6] Moghaddam I N, Chowdhury B H, Mohajeryami S.Predictive operation and optimal sizing of battery energy storage with high wind energy penetration[J]. IEEE Transactions on Industrial Electronics, 2018, 65(8): 6686-6695. [7] 杨恩, 王岩, 王建业, 等. 基于薄膜拍打型摩擦纳米发电机的风能收集研究[J]. 中国科学: 技术科学, 2021, 51(6): 684-698. Yang En, Wang Yan, Wang Jianye, et al.Research on a film-flapping triboelectric nanogenerator for wind energy harvesting[J]. Scientia Sinica (Technologica), 2021, 51(6): 684-698. [8] 许利通, 程明, 魏新迟, 等. 考虑损耗的无刷双馈风力发电系统功率反馈法最大功率点跟踪控制[J]. 电工技术学报, 2020, 35(3): 472-480. Xu Litong, Cheng Ming, Wei Xinchi, et al.Power signal feedback control of maximum power point tracking control for brushless doubly-fed wind power generation system considering loss[J]. Transactions of China Electrotechnical Society, 2020, 35(3): 472-480. [9] 刘慧芳, 曹崇东, 赵强, 等. 悬臂式铁镓合金振动能量收集的存储方法[J]. 电工技术学报, 2020, 35(14): 3137-3146. Liu Huifang, Cao Chongdong, Zhao Qiang, et al.The method of vibration energy collection and storage of cantilever gallium-iron alloy[J]. Transactions of China Electrotechnical Society, 2020, 35(14): 3137-3146. [10] 王东伟, 刘明星, 吴霄, 等. 压电式摩擦振动能量收集的试验研究与仿真分析[J]. 机械工程学报, 2021, 57(9): 89-98. Wang Dongwei, Liu Mingxing, Wu Xiao, et al.Experimental and numerical study on the response characteristics of piezoelectric energy harvester via friction-induced vibration[J]. Journal of Mechanical Engineering, 2021, 57(9): 89-98. [11] Dobzhanskyi O, Hossain E, Amiri E, et al.Axial-flux PM disk generator with magnetic gear for oceanic wave energy harvesting[J]. IEEE Access, 2019, 7: 44813-44822. [12] Shi Xiaolei, Chen Wenyi, Zhang Ting, et al.Fiber-based thermoelectrics for solid, portable, and wearable electronics[J]. Energy & Environmental Science, 2021, 14(2): 729-764. [13] 李国能, 朱智浩, 郑友取, 等. 介观尺度燃烧驱动温差发电的实验研究[J]. 中国电机工程学报, 2021, 41(24): 8502-8509. Li Guoneng, Zhu Zhihao, Zheng Youqu, et al.Experimental study on mesoscale combustion powered thermoelectric generator[J]. Proceedings of the CSEE, 2021, 41(24): 8502-8509. [14] 李春龙, 黄辉, 梁云, 等. 面向电力传感器的环境能量收集技术发展趋势及面临的挑战[J]. 中国电力, 2021, 54(2): 27-35. Li Chunlong, Huang Hui, Liang Yun, et al.Power sensor-oriented development and challenges of environmental energy harvesting technologies[J]. Electric Power, 2021, 54(2): 27-35. [15] 王黎明, 李宗, 孟晓波, 等. 一种交流电场无线取能电源的优化设计[J]. 高压电器, 2020, 56(5): 121-127. Wang Liming, Li Zong, Meng Xiaobo, et al.Optimization design of an AC electric field wireless power supply[J]. High Voltage Apparatus, 2020, 56(5): 121-127. [16] 于宙, 肖文勋, 张波, 等. 电场耦合式无线电能传输技术的发展现状[J]. 电工技术学报, 2022, 37(5): 1051-1069. Yu Zhou, Xiao Wenxun, Zhang Bo, et al.Development status of electric-field coupled wireless power transmission technology[J]. Transactions of China Electrotechnical Society, 2022, 37(5): 1051-1069. [17] Wang Z, Hu J, Han J, et al.A novel high-performance energy harvester based on nonlinear resonance for scavenging power-frequency magnetic energy[J]. IEEE Transactions on Industrial Electronics, 2017, 64(8): 6556-6564. [18] Moon J, Leeb S B.Power loss analysis with high primary current in magnetic energy harvesters[C]//IEEE 16th Workshop on Control and Modeling for Power Electronics, Vancouver, BC, Canada, 2015: 1-8. [19] Zhuang Yuan, Xu Chen, Song Chaoyun, et al.Improving current transformer-based energy extraction from AC power lines by manipulating magnetic field[J]. IEEE Transactions on Industrial Electronics, 2020, 67(11): 9471-9479. [20] 卢治江. 宽电流范围的电流互感器取能技术[D] . 淄博:山东理工大学, 2019. [21] 刘铮, 樊绍胜, 胡劼睿. 基于阻抗匹配的输电线路在线取能方法研究[J]. 中国电机工程学报, 2019, 39(23): 6867-6876, 7100. Liu Zheng, Fan Shaosheng, Hu Jierui.Research on on-line energy acquisition method for transmission lines based on impedance matching[J]. Proceedings of the CSEE, 2019, 39(23): 6867-6876, 7100. [22] 程志远, 隋立程, 宋凯, 等. 谐振补偿式电流互感器取能方法的研究[J]. 电网技术, 2021, 45(12): 4896-4902. Cheng Zhiyuan, Sui Licheng, Song Kai, et al.Resonance compensation current transformer energy extraction[J]. Power System Technology, 2021, 45(12): 4896-4902. [23] 张鹏, 王玮, 徐丙垠, 等. 基于自适应功率输出控制的电流互感器取能电源设计方法[J]. 电力系统自动化, 2020, 44(3): 194-200. Zhang Peng, Wang Wei, Xu Bingyin, et al.Design method of energy-gaining power supply for current transformer based on self-adaptive power output control[J]. Automation of Electric Power Systems, 2020, 44(3): 194-200. [24] 刘亚东, 盛戈皞, 王葵, 等. 基于相角控制法的电流互感器取电电源设计[J]. 电力系统自动化, 2011, 35(19): 72-76. Liu Yadong, Sheng Gehao, Wang Kui, et al.A new design of current transformer energy harvesting power supply based on phase angle control method[J]. Automation of Electric Power Systems, 2011, 35(19): 72-76. [25] 陈吴. 基于PWM整流的CT取电电源的研究[D]. 淄博: 山东理工大学, 2021. [26] 赵强松, 陈宝林, 叶永强, 等. 基于五级电荷泵能量收集的电流互感器取能电源[J]. 电力系统自动化, 2014, 38(15): 118-123. Zhao Qiangsong, Chen Baolin, Ye Yongqiang, et al.A current transformer energy-obtaining power supply based on five-level charge pump circuit[J]. Automation of Electric Power Systems, 2014, 38(15): 118-123. [27] Moghe R, Lambert F C, Divan D.Smart “stick-on” sensors for the smart grid[J]. IEEE Transactions on Smart Grid, 2012, 3(1): 241-252. [28] Paul S, Bashir S, Chang J.Design of a novel electromagnetic energy harvester with dual core for deicing device of transmission lines[J]. IEEE Transactions on Magnetics, 2019, 55(2): 1-4. [29] 任晓东, 陈树勇, 姜涛. 电子式电流互感器高压侧取能装置的设计[J]. 电网技术, 2008, 32(18): 67-71, 76. Ren Xiaodong, Chen Shuyong, Jiang Tao.Design of a high side energy extracting device for active electronic current transformer[J]. Power System Technology, 2008, 32(18): 67-71, 76. [30] Moon J, Leeb S B.Analysis model for magnetic energy harvesters[J]. IEEE Transactions on Power Electronics, 2015, 30(8): 4302-4311.
2023, Vol. 38 
