Current Decoupling and Force Disturbance Suppression of Dual Three-Phase Permanent Magnet Linear Synchronous Motors with Section Power Supply
Guo Keyu1,2, Li Yaohua1,2, Shi Liming1,2
1. Key Laboratory of Power Electronics and Electric Drive Institute of Electrical Engineering Chinese Academy of Sciences Beijing 100190 China; 2. University of Chinese Academy of Sciences Beijing 100049 China
Abstract：Section power supply strategy is usually adopted to reduce the voltage and capacity of the inverters in the drive system of the permanent magnet linear synchronous machines (PMLSM) with long primary. However, the sectionally powered armature windings will generate the imbalanced inductance matrix. During the mover entering and leaving progress, the coupling and disturbance of the currents in the linear machine are caused, resulting in fluctuation of current and consequently thrust force ripple. To regulate the current precisely and diminish the thrust force ripple, a feedback decoupling controller is designed, and the effectiveness of the designed feedback decoupling controller is evaluated by using a dynamic relative gain array (DRGA). Furthermore, the disturbance caused by the dynamic process in back-EMF and the mismatches of machine parameters are estimated and compensated by an extended state observer based on the second-order sliding mode. The experimental results show that the proposed current control strategy can effectively reduce the fluctuation in current and diminish the force ripple.
郭科宇, 李耀华, 史黎明. 分段供电双三相永磁同步直线电机电流解耦与扰动抑制[J]. 电工技术学报, 2022, 37(24): 6332-6344.
Guo Keyu, Li Yaohua, Shi Liming. Current Decoupling and Force Disturbance Suppression of Dual Three-Phase Permanent Magnet Linear Synchronous Motors with Section Power Supply. Transactions of China Electrotechnical Society, 2022, 37(24): 6332-6344.
[1] 蒋钱, 卢琴芬, 李焱鑫. 双三相永磁直线同步电机的推力波动及抑制[J]. 电工技术学报, 2021, 36(5): 883-892. Jiang Qian, Lu Qinfen, Li Yanxin.Thrust ripple and depression method of dual three-phase permanent magnet linear synchronous motors[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 883-892. [2] 张晓虎, 赵吉文, 王立俊, 等. 基于自适应互联扩展卡尔曼观测器的永磁同步直线电机高精度抗干扰在线多参数辨识[J]. 中国电机工程学报, 2022, 42(12): 4571-4580. Zhang Xiaohu, Zhao Jiwen, Wang Lijun, et al.High precision anti-interference online multiparameter estimation of PMSLM with adaptive interconnected extend Kalman observer[J]. Proceedings of the CSEE, 2022, 42(12): 4571-4580. [3] 张康, 王丽梅. 基于反馈线性化的永磁直线同步电机自适应动态滑模控制[J]. 电工技术学报, 2021, 36(19): 4016-4024. Zhang Kang, Wang Limei.Adaptive dynamic sliding mode control of permanent magnet linear synchronous motor based on feedback linearization[J]. Transa- ctions of China Electrotechnical Society, 2021, 36(19): 4016-4024. [4] 李雄松, 崔鹤松, 胡纯福, 等. 平板型永磁直线同步电机推力特性的优化设计[J]. 电工技术学报, 2021, 36(5): 916-923. Li Xiongsong, Cui Hesong, Hu Chunfu, et al.Optimal design of thrust characteristics of flat-type permanent magnet linear synchronous motor[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 916-923. [5] 王璨, 李国冲, 杨桂林, 等. 基于生物智能环状耦合的嵌入式永磁同步直线电机高精度位置协同控制研究[J]. 电工技术学报, 2021, 36(5): 935-943. Wang Can, Li Guochong, Yang Guilin, et al.Research on position cooperative control of high-precision embedded permanent magnet synchronous linear motor based on biological intelligence loop coupling[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 935-943. [6] 宋文祥, 任航, 叶豪. 基于MRAS的双三相永磁同步电机无位置传感器控制研究[J]. 中国电机工程学报, 2022, 42(3): 1164-1173. Song Wenxiang, Ren Hang, Ye Hao.Position sensorless control of dual three phase permanent magnet synchronous motor based on MRAS[J]. Proceedings of the CSEE, 2022, 42(3): 1164-1173. [7] 张建亚, 王凯, 朱姝姝, 等. 双三相永磁同步电机多谐波电流协同控制策略[J]. 中国电机工程学报, 2020, 40(2): 644-652. Zhang Jianya, Wang Kai, Zhu Shushu, et al.Control strategies of dual three-phase permanent magnet machines with multi-harmonics[J]. Proceedings of the CSEE, 2020, 40(2): 644-652. [8] 王琛琛, 王堃, 游小杰, 等. 低开关频率下双三相感应电机矢量控制策略[J]. 电工技术学报, 2018, 33(8): 1732-1741. Wang Chenchen, Wang Kun, You Xiaojie, et al.Vector control strategy for dual three-phase induction machines under low switching frequency[J]. Transa- ctions of China Electrotechnical Society, 2018, 33(8): 1732-1741. [9] 徐质闲, 王政, 王学庆, 等. T型三电平双三相永磁同步电机驱动零共模电压模型预测控制[J]. 中国电机工程学报, 2020, 40(13): 4301-4309. Xu Zhixian, Wang Zheng, Wang Xueqing, et al.A predictive current control method for a T-type three- level dual three-phase PMSM with zero common- mode voltage[J]. Proceedings of the CSEE, 2020, 40(13): 4301-4309. [10] 张志锋, 吴雪松, 刘晓东. 低共模干扰的双三相永磁同步电机SVPWM控制[J]. 电工技术学报, 2018, 33(增刊1): 58-66. Zhang Zhifeng, Wu Xuesong, Liu Xiaodong.Low common mode interference SVPWM control for dual three phase permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2018, 33(S1): 58-66. [11] 鲁军勇, 马伟明, 孙兆龙, 等. 多段初级直线感应电机静态纵向边端效应研究[J]. 中国电机工程学报, 2009, 29(33): 95-101. Lu Junyong, Ma Weiming, Sun Zhaolong, et al.Research on static longitudinal end effect of linear induction motor with multi-segment primary[J]. Proceedings of the CSEE, 2009, 29(33): 95-101. [12] 聂世雄, 付立军, 许金, 等. 分段供电直线感应电机动子不对称模型及参数计算[J]. 电机与控制学报, 2017, 21(2): 10-17. Nie Shixiong, Fu Lijun, Xu Jin, et al.Asymmetrical model and parameter calculation of segment-powered linear inductive motor mover[J]. Electric Machines and Control, 2017, 21(2): 10-17. [13] 许金, 马伟明, 鲁军勇, 等. 分段供电直线感应电机气隙磁场分布和互感不对称分析[J]. 中国电机工程学报, 2011, 31(15): 61-68. Xu Jin, Ma Weiming, Lu Junyong, et al.Analysis of air-gap magnetic field distribution and mutual inductance asymmetry of sectionally powered linear induction motor[J]. Proceedings of the CSEE, 2011, 31(15): 61-68. [14] 牟树君, 柴建云, 孙旭东, 等. 分段供电交流直线电机三相互感不对称分析及抑制[J]. 电工技术学报, 2015, 30(1): 81-88. Mu Shujun, Chai Jianyun, Sun Xudong, et al.Analysis and restrain of mutual inductance asymmetry in the sectionally powered AC linear motor[J]. Transactions of China Electrotechnical Society, 2015, 30(1): 81-88. [15] 许实章. 交流电机的绕组理论[M]. 北京: 机械工业出版社, 1985. [16] Xu Wei, Zou Jianqiao, Mu Chaoxu.New model predictive current control strategy based rotor flux for linear induction machines[C]//2015 IEEE International Conference on Applied Superconductivity and Elec- tromagnetic Devices (ASEMD), Shanghai, China, 2015: 58-59. [17] Zou Jianqiao, Xu Wei, Yu Xinghuo, et al.Multistep model predictive control with current and voltage constraints for linear induction machine based urban transportation[J]. IEEE Transactions on Vehicular Technology, 2017, 66(12): 10817-10829. [18] Yang Rui, Wang Mingyi, Li Liyi, et al.Robust predictive current control with variable-gain adaptive disturbance observer for PMLSM[J]. IEEE Access, 6: 13158-13169. [19] 尹忠刚, 白聪, 杜超, 等. 基于内模干扰观测器的永磁同步直线电机无差拍电流预测控制方法[J]. 电工技术学报, 2018, 33(24): 5741-5750. Yin Zhonggang, Bai Cong, Du Chao, et al.Deadbeat predictive current control for permanent magnet linear synchronous motor based on internal model dis- turbance observer[J]. Transactions of China Electro- technical Society, 2018, 33(24): 5741-5750. [20] Wang Zhen, Zhao Jiwen, Wang Lijun, et al.Com- bined vector resonant and active disturbance rejection control for PMSLM current harmonic suppression[J]. IEEE Transactions on Industrial Informatics, 2020, 16(9): 5691-5702. [21] 黎明, 赵吉文, 胡月鹏, 等. 基于降阶双环自抗扰的永磁同步直线电机电流谐波抑制[J]. 光学精密工程, 2020, 28(5): 1055-1065. Li Ming, Zhao Jiwen, Hu Yuepeng, et al.Current harmonic suppression of permanent magnet syn- chronous linear motor based on reduced-order double closed-loop ADRC[J]. Optics and Precision Engin- eering, 2020, 28(5): 1055-1065. [22] 李争, 安金峰, 肖宇, 等. 基于自适应观测器的永磁同步直线电机模型预测控制系统设计[J]. 电工技术学报, 2021, 36(6): 1190-1200. Li Zheng, An Jinfeng, Xiao Yu, et al.Design of model predictive control system for permanent magnet synchronous linear motor based on adaptive observer[J]. Transactions of China Electrotechnical Society, 2021, 36(6): 1190-1200. [23] 文通, 张思磊, 王中仪. 定子分段式永磁直线同步电机速度波动抑制方法研究[J]. 光学精密工程, 2020, 28(4): 933-945. Wen Tong, Zhang Silei, Wang Zhongyi.Speed ripple suppression method of PMLSM with segmented stators[J]. Optics and Precision Engineering, 2020, 28(4): 933-945. [24] 李立毅, 祝贺, 刘家曦, 等. 初级绕组分段永磁直线电机段间推力优化控制[J]. 电机与控制学报, 2014, 18(4): 79-87. Li Liyi, Zhu He, Liu Jiaxi, et al.Optimal inter- segment thrust control applied in primary winding segmented PMLSM[J]. Electric Machines and Control, 2014, 18(4): 79-87. [25] Lee K, Ha J I, Simili D.Analysis and suppression of slotting and cross-coupling effects on current control in PM synchronous motor drives[J]. IEEE Transa- ctions on Power Electronics, 2019, 34: 9942-9956. [26] Wang Yingjie, Wang Wenchao, Wang Chao, et al.Coupling analysis on current control at low switching frequency for the three-phase PWM converter based on RGA and a novel output feedback decoupling method[J]. IEEE Transactions on Industrial Electro- nics, 2016, 63(11): 6684-6694. [27] 张庆超, 马瑞卿, 皇甫宜耿, 等. 电机转速环节Super-Twisting算法二阶滑模控制律设计与研究[J]. 西北工业大学学报, 2016, 34(4): 669-676. Zhang Qingchao, Ma Ruiqing, Huangfu Yigeng, et al.Second-order sliding mode control based on super- twisting algorithm for the speed outer loop of motors[J]. Journal of Northwestern Polytechnical University, 2016, 34(4): 669-676. [28] Davila J, Fridman L, Levant A.Second-order sliding- mode observer for mechanical systems[J]. IEEE Transactions on Automatic Control, 2005, 50(11): 1785-1789. [29] 郭科宇, 李耀华, 史黎明, 等. 电枢分段供电永磁直线同步电机的非线性数学模型[J]. 电工技术学报, 2021, 36(6): 1126-1137. Guo Keyu, Li Yaohua, Shi Liming, et al.Non-linear mathematic model of a segmented powered permanent magnet linear synchronous machine[J]. Transactions of China Electrotechnical Society, 2021, 36(6): 1126-1137. [30] 杨金波. 双三相永磁同步电机驱动技术研究[D]. 哈尔滨: 哈尔滨工业大学, 2011. [31] Shtessel Y, Edwards C, Fridman L, et al.Sliding mode control and observation[M]. New York: Springer, 2015. [32] Lee J S, Choi G.Modeling and hardware-in-the-loop system realization of electric machine drives—a review[J]. CES Transactions on Electrical Machines and Systems, 2021, 5(3): 194-201.
2022, Vol. 37 
