Space Electric Field Characteristics in Oil of Large-Scale Oil-Pressboard Structure under Various Voltage Stresses
Gao Chunjia1, Qi Bo1, Han Hao1, Gao Yuan2, Li Chengrong1
1. State Key Laboratory of Alternate Electrical Power System with Renewable Energy SourcesNorth China Electric Power University Beijing 102206 China; 2. State Grid Shandong Rizhao Power Supply Company Rizhao 276800 China
Abstract：The design of oil-pressboard/paper insulation structure mainly relies on simulation and verification test with simple equivalent test models, which lacks the physical entity verification under the large-scale structure. Based on Kerr electro-optic effect, a novel electric field measuring sensor was developed to capture the electric field in a large-scale converter transformer outlet device model under AC voltage, DC voltage and polarity reversal voltage. The test results indicated that ①under the positive DC voltage, as the voltage duration prolongs, the electric field in outer oil spacing decreases while those in inner and middle oil spacing both increase, and the field strength in steady state is increased by 2.04 times compared with the calculation results via RC (Resistance-Capacitance) model. Under the negative DC voltage, the tendency of electric field is similar to that under positive voltage; ②Under AC voltage, the maximum error between measured field strength and simulation result is 4.08%; ③Under the polarity reversal voltage, the faster the polarity reversal time, the higher the electric field strength after polarity reversal in the oil. In addition, the different interface charge accumulation conditions in each oil spacing could cause the zero-crossing point of electric field to be asynchronous with that of applied voltage. Based on the dynamic process of interface charge and its influence on space electric field, this paper proposes an electric analysis method for explaining the time-dependent characteristic mechanisms of electric field and interface charge in oil under DC voltage and polarity voltage.
高春嘉, 齐波, 韩昊, 高原, 李成榕. 大尺寸油纸绝缘结构多电压应力下空间电场特性[J]. 电工技术学报, 2019, 34(22): 4816-4826.
Gao Chunjia, Qi Bo, Han Hao, Gao Yuan, Li Chengrong. Space Electric Field Characteristics in Oil of Large-Scale Oil-Pressboard Structure under Various Voltage Stresses. Transactions of China Electrotechnical Society, 2019, 34(22): 4816-4826.
[1] CIGRE Joint Working Group A2/B4.28. HVDC converter transformers guide lines for conducting design reviews for HVDC converter transformers[R]. Paris: CIGRE, 2010. [2] 舒印彪, 张文亮. 特高压输电若干关键技术研究[J]. 中国电机工程学报, 2007, 27(31): 1-6 Shu Yinbiao, Zhang Wenliang.Research of key technologies for UHV transmission[J]. Proceedings of the CSEE, 2007, 27(31): 1-6. [3] 郝建, 伏进, 侯兴哲, 等. 基于改进电声脉冲测试系统的油纸绝缘混合体系空间电荷动态行为特性[J]. 电工技术学报, 2016, 31(10): 34-41. Hao Jian, Fu Jin, Hou Xingzhe, et al.Space charge migration characteristics of transformer oil-paper insulation based on the improved pulsed electro- acoustic measurement system[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 34-41. [4] 廖瑞金, 王季宇, 袁媛, 等. 换流变压器下新型纤维素绝缘纸特性综述[J]. 电工技术学报, 2016, 31(10): 1-15. Liao Ruijin, Wang Jiyu, Yuan Yuan, et al.Review on the characteristic of new cellulose insulation paper used in the converter transformer[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 1-15. [5] 杨丽君, 张将, 陆云才, 等. 电场对变压器绕组油纸绝缘油硫腐蚀的影响及机理研究[J]. 电工技术学报, 2018, 33(7): 1616-1625. Yang Lijun, Zhang Jiang, Lu Yuncai, et al.Study on influence and mechanism of oil sulfur corrosion in oil-paper insulation of transformer winding under the electric field[J]. Transactions of China Electro- technical Society, 2018, 33(7): 1616-1625. [6] 穆海宝, 张冠军, 郑楠, 等. Pockels效应表面电荷测量中电荷反演算法的研究[J]. 中国电机工程学报, 2011, 31(13): 135-141. Mu Haibao, Zhang Guanjun, Zheng Nan, et al.Charge inversion algorithm in surface charge measurement based on Pockels effect[J]. Proceedings of the CSEE, 2011, 31(13): 135-141. [7] 廖瑞金, 柳海滨, 周年荣, 等. 绝缘纸热老化对油浸绝缘纸空间电荷生成及迁移特性的影响[J]. 电工技术学报, 2015, 30(22): 206-214. Liao Ruijin, Liu Haibin, Zhou Nianrong, et al.Influence of insulation paper’s thermal aging on the formation and migration behavior of space charge in oil-paper insulation dielectrics[J]. Transactions of China Electrotechnical Society, 2015, 30(22): 206-214. [8] 周远翔, 王宁华, 王云衫, 等. 固体电介质空间电荷研究进展[J]. 电工技术学报, 2008, 23(9): 16-25. Zhou Yuanxiang, Wang Ninghua, Wang Yunshan, et al.Review of research on space charge in solid dielectrics[J]. Transactions of China Electrotechnical Society, 2008, 23(9): 16-25. [9] 连启祥, 杜志叶, 杨知非, 等. 油纸绝缘内部合成电场数值模拟方法[J]. 电工技术学报, 2017, 32(20): 53-61. Lian Qixiang, Du Zhiye, Yang Zhifei, et al.Numerical simulation method of electric field in oil-paper insulation[J]. Transactions of China Elec- trotechnical Society, 2017, 32(20): 53-61. [10] Hebner R E, Malewski R A, Cassidy E C.Optical methods of electrical measurement at high voltage levels[J]. Proceedings of IEEE, 1977, 65(11): 1524-1548. [11] Gafvert U, Jaksts A, Tornkvist C, et al.Electrical field distribution in transformer oil[J]. IEEE Transactions on Electrical Insulation, 1992, 27(3): 647-660. [12] Gafvert U, Hjortstam O, Serdyuk Y, et al.Modeling and measurements of electric fields in composite oil/cellulose insulation[C]//2006 IEEE Conference on Electrical Insulation and Dielectric Phenomena, Kansas City, USA, 2006: 154-157. [13] Inoue N, Wakamatsu M, Kato K, et al.Charge accumulation mechanism in oil/pressboard composite insulation system based on optical measurement of electric field[J]. IEEE Transactions on Electrical Insulation, 2003, 10(3): 491-497. [14] Kato K, Okubo H, Endo F, et al.Investigation of charge behavior in low viscosity silicone liquid by Kerr electro-optic field measurement[J]. IEEE Transactions on Electrical Insulation, 2010, 17(4): 1214-1220. [15] 吴昊. 换流变压器油纸绝缘结构油中电场和界面电荷特性的研究[D]. 北京: 华北电力大学, 2013. [16] 吴昊, 齐波, 李成榕, 等. 基于Kerr效应法的油纸复合绝缘交直流复合电场测量[J]. 电工技术学报, 2013, 28(4): 28-34. Wu Hao, Qi Bo, Li Chengrong, et al.The measurement of AC-DC composite field for oil-paper insulation system based on the Kerr electro-optic effect[J]. Transactions of China Electrotechnical Society, 2013, 28(4): 28-34. [17] 齐波, 赵晓林张书琦, 等. 冲击电压下变压器油中电场特性及电荷运动模型[J]. 中国电机工程学报, 2017, 37(增刊1): 218-229. Qi Bo, Zhao Xiaolin, Zhang Shuqi, et al.Electric field characteristics and charge motion model in transformer oil under impulse voltage[J]. Proceedings of the CSEE, 2017, 37(S1): 218-229. [18] 吴昊, 李成榕, 齐波, 等. 直流电压下油、纸绝缘结构不连续界面空间电荷积聚特性[J]. 高电压技术, 2013, 30(6): 1419-1425. Wu Hao, Li Chengrong, Qi Bo, et al.Accumulation characteristics of interface charge in the oil-paper insulation under DC voltage[J]. High Voltage Engineering, 2013, 30(6): 1419-1425. [19] Qi Bo, Gao Chunjia, Zhao Xiaolin, et al.Interface charge polarity effect based analysis model for electric field in oil-pressboard insulation under DC voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(5): 2704-2711. [20] 高原. 变压器油中空间电场测量传感器的研制[D]. 北京: 华北电力大学, 2017. [21] IEC International Standard.IEC 61378-3-2015 converter transformers-Part 3: application guide[S]. 2015. [22] Qi Bo, Zhao Xiaolin, Li Chengrong, et al.Transient electric field characteristics in oil-pressboard com- posite insulation under voltage polarity reversal[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2015, 22(4): 2148-2155.
2019, Vol. 34 
