Dynamic Inductance Identification Method and Rotor Position Estimation Error Compensation Strategy for IPMSM
Li Feng1, Che Jin1, Liu Daming1, Xia Chaoying2, Wang Hongyan3
1. School of Physics and Electronic-Electrical Engineering Ningxia University Yinchuan 750021 China; 2. School of Electrical and Information Engineering Tianjin University Tianjin 300072 China; 3. Ningxia Agricultural Internet of things Engineering Technology Research Center Yinchuan 750004 China
Abstract：Sensorless control of interior permanent magnet synchronous motor (IPMSM) can be achieved usually by using the rotating high-frequency voltage injection method at low and zero speed. However, the rotor position estimation error occurs when the cross coupling effect exists in d-axis and q-axis magnetic circuits. Moreover, the rotor position estimation error is concerned with d-axis and q-axis dynamic inductances and cross coupling dynamic inductance. To overcome impacts of the magnetic circuit saturation effect and cross coupling effect on dynamic inductances and rotor position estimation, a fractional-step identification method of dynamic inductances and a compensation strategy of the rotor position estimation error were proposed in this paper. After an inductance proportionality factor was obtained offline using a d-axis high-frequency voltage injection algorithm, a dynamic inductance identification algorithm based on rotating high-frequency voltage injection was applied to sensorless control of IPMSM, and then not only the identification of dynamic inductances but the calculation and compensation of the rotor position estimation error could be achieved online. Finally the feasibility and availability of the dynamic inductance identification method and rotor position estimation error compensation strategy were validated by experimental results.
李峰, 车进, 刘大铭, 夏超英, 王红艳. IPMSM动态电感辨识方法及转子位置估计误差补偿策略[J]. 电工技术学报, 2018, 33(23): 5418-5426.
Li Feng, Che Jin, Liu Daming, Xia Chaoying, Wang Hongyan. Dynamic Inductance Identification Method and Rotor Position Estimation Error Compensation Strategy for IPMSM. Transactions of China Electrotechnical Society, 2018, 33(23): 5418-5426.
[1] Rafaq M S, Mwasilu F, Kim J, et al.Online parameter identification for model-based sensorless control of interior permanent magnet synchronous machine[J]. IEEE Transactions on Power Electronics, 2017, 32(6): 4631-4643. [2] 吴春, 齐蓉, 李兵强, 等. 考虑饱和效应的永磁同步电动机全程无位置传感器控制[J]. 电工技术学报, 2017, 32(2): 171-179. Wu Chun, Qi Rong, Li Bingqiang, et al.Whole speed range sensorless control of permanent magnet synchronous motor considering saturation effect[J]. Transactions of China Electrotechnical Society, 2017, 32(2): 171-179. [3] 李峰, 夏超英. 考虑磁路饱和的内置式永磁同步电动机电感参数旋转辨识算法[J]. 电工技术学报, 2016, 31(21): 203-211. Li Feng, Xia Chaoying.Inductance parameters identification algorithms of IPMSM under rotating state taking magnetic circuit saturation into account[J]. Transactions of China Electrotechnical Society, 2016, 31(21): 203-211. [4] 李旭春, 张鹏, 严乐阳, 等. 具有参数辨识的永磁同步电动机无位置传感器控制[J]. 电工技术学报, 2016, 31(14): 139-147. Li Xuchun, Zhang Peng, Yan Leyang, et al.Sensorless control of permanent magnet synchronous motor with online parameter identification[J]. Transactions of China Electrotechnical Society, 2016, 31(14): 139-147. [5] Corley M J, Lorenz R D.Rotor position and velocity estimation for a salient-pole permanent magnet synchronous machines at standstill and high speeds[J]. IEEE Transactions on Industry Applications, 1998, 34(4): 784-789. [6] Kim S I, Im J H, Song E Y, et al.A new rotor position estimation method of IPMSM using all-pass filter on high-frequency rotating voltage signal injection[J]. IEEE Transactions on Industrial Electronics, 2016, 63(10): 6499-6509. [7] Jang J H, Sul S K, Ha J I, et al.Sensorless drive of surface-mounted permanent-magnet motor by high-frequency signal injection based on magnetic saliency[J]. IEEE Transactions on Industry Applications, 2003, 39(4): 1031-1039. [8] Chen J L, Tseng S K, Liu T H.Implementation of high-performance sensorless interior permanent-magnet synchronous motor control systems using a high-frequency injection technique[J]. IET Electric Power Applications, 2012, 6(8): 533-544. [9] Stumberger B, Stumberger G, Dolina D, et al.Evaluation of saturation and cross-magnetization effects in interior permanent magnet synchronous motor[J]. IEEE Transactions on Industry Applications, 2000, 39(5): 1264-1271. [10] Bianchi N, Fornasiero E, Bolognani S.Effect of stator and rotor saturation on sensorless rotor position detection[J]. IEEE Transactions on Industry Applications, 2013, 49(3): 1333-1342. [11] Zhu Z Q, Gong L M.Investigation of effectiveness of sensorless operation in carrier-signal-injection-based sensorless-control methods[J]. IEEE Transactions on Industrial Electronics, 2011, 58(8): 3431-3439. [12] Guglielmi P, Pastorelli M, Vagati A.Cross-saturation effects in IPM motors and related impact on sensorless control[J]. IEEE Transactions on Industry Applications, 2006, 42(6): 1516-1522. [13] Seilmeier M, Boehm A, Hahn I, et al.Identification of time-variant high frequency parameters for sensorless control of PMSM using an internal model principle based high frequency current control[C]//2012 XXth International Conference on Electrical Machines, Marseille, France, 2012: 987-993. [14] Seilmeier M, Ebersberger S, Piepenbreier B.Identification of high frequency resistances and inductances for sensorless control of PMSM[C]//2013 IEEE International Symposium on Sensorless Control for Electrical Drives and Predictive Control of Electrical Drives and Power Electronics, Munich, Germany, 2013: 1-8. [15] Ebersberger S, Piepenbreier B.Identification of differential inductance of permanent magnet synchronous machines using test current signal injection[C]// International Symposium on Power Electronics Power Electronics, Electrical Drives, Automation and Motion, Sorrento, Italy, 2012: 1342-1347. [16] El-Murr G, Giaouris D, Finch J W.Online cross-coupling and self incremental inductances determination of salient permanent magnet synchronous machines[C]// 5th IET International Conference on Power Electronics, Machines and Drives, Brighton, UK, 2010. [17] Li Yi, Zhu Z Q, Howe D, et al.Modeling of cross-coupling magnetic saturation in signal-injection- based sensorless control permanent-magnet brushless AC motors[J]. IEEE Transactions on Magnetics, 2007, 43(6): 2552-2554. [18] 张立红. 基于高频注入法的永磁同步电动机无传感器控制系统研究[D]. 天津: 天津大学, 2008.
2018, Vol. 33 
