Abstract：On the basis of analyzing the principle structure of the dual-winding three-phase fault tolerant motor,this paper discusses the torque ripples and copper loss under motor open-circuit and short-circuit conditions.Then the doubling current fault-tolerant strategy,the optimal torque control,and the current vector fault-tolerant control are discussed in detail.The characteristics of these fault-tolerant control strategies are discussed and analyzed by calculation and simulation.Finally,the correctness of the proposed current vector fault-tolerant control is verified by the hardware experiment setup under healthy and open-circuit conditions.
白洪芬,朱景伟,孙军浩,周博文,李小庆. 双绕组永磁容错电机不同故障容错控制策略的比较研究[J]. 电工技术学报, 2016, 31(13): 189-199.
Bai Hongfen, Zhu Jingwei, Sun Junhao ,Zhou Bowen, Li Xiaoqing. Comparative Study of Different Fault Tolerant Control Strategies for Dual-Winding Fault Tolerant Permanent Magnet Motor. Transactions of China Electrotechnical Society, 2016, 31(13): 189-199.
[1] 肖丽,范书瑞,刘卫朋,等.基于电流分析的四相开关磁阻电机气隙偏心故障综合检测方法[J].电工技术学报,2015,30(6):122-132. Xiao Li,Fan Shurui,Liu Weipeng,et al.Fault detection method of air gap eccentricity for switched reluctance motors based on analysis of current[J].Transactions of China Electrotechnical Society,2015,30(6):122-132. [2] Mecrow B C,Jack A G,Haylock J A,et al.Fault-tolerant permanent magnet machine drives[J].IEE Proceedings-Electric Power Applications,1996,143(6):437-442. [3] Ede J D,Atallah K,Wang J,et al.Effect of optimal torque control on rotor loss of fault-tolerant permanent-magnet brushless machines[J].IEEE Transactions on Magnetics,2002,38(5):3291-3293. [4] Haylock J A,Mecrow B C,Jack A G,et al.Enhanced current control of high-speed PM machine drives through the use of flux controller[J].IEEE Transactions on Industry Applications,1999,35(5):1030-1038. [5] de Kock H W,Rix A J,Kamper M J.Optimal torque control of interior permanent magnet synchronous machines in the full speed range[C]//18th International Conference on Electrical Machines,Vilamoura,Portugal,2008:1-6. [6] Wang J B,Atallah K,Howe D.Optimal torque control of fault-tolerant permanent magnet brushless machines[J].IEEE Transactions on Magnetic,2003,39(5):2962-2964. [7] Bianchi N,Bolognani S,Pre M D.Strategies for the fault-tolerant current control of a five-phase permanent-magnet motor[J].IEEE Transactions on Industry Applications,2007,43(4):960-970. [8] 齐蓉,陈峥,林辉.永磁容错电机解耦控制研究[J].西北工业大学学报,2007,25(6):809-813. Qi Rong,Chen Zheng,Lin Hui.A method for implementing torque decoupling control in fault tolerant permanent magnet motor for aircraft[J].Journal of Northwestern Polytechnical University,2007,25(6):809-813. [9] 任元,孙玉坤,朱纪洪.四相永磁容错电机的SVPWM控制[J].航空学报,2009,30(8):1490-1496. Ren Yuan,Sun Yukun,Zhu Jihong.SVPWM control of four-phase fault-tolerant permanent magnet motor for aircraft[J].Acta Aeronautica Et Astronautica Sinica,2009,30(8):1490-1496. [10]郝振洋.六相永磁容错电机及其控制系统的设计和研究[D].南京:南京航空航天大学,2010. [11]荀倩,秦海鸿,马亚飞,等.基于最优转矩控制六相永磁容错电机故障补救策略的仿真研究[J].电源学报,2015,13(1):28-34. Xun Qian,Qin Haihong,Ma Yafei,et al.Research of six phase fault tolerant permanent magnet motor simulation based on optimal torque control[J].Journal of Power Supply,2015,13(1):28-34. [12]余文涛,胡育文,郝振洋,等.永磁容错电机最优转矩控制策略实验[J].航空学报,2010,30(8):1622-1628. Yu Wentao,Hu Yuwen,Hao Zhenyang,et al.Experimental study on optimal torque control of fault tolerant permanent magnet motor[J].Acta Aeronautica Et Astronautica Sinica,2010,30(8):1622-1628. [13]郝振洋,胡育文,沈天珉.永磁容错电机的直接转矩控制策略[J].电工技术学报,2014,29(3):180-188. Hao Zhenyang,Hu Yuwen,Shen Tianmin.Director torque control strategy of fault tolerant permanent magnet motors[J].Transactions of China Electrotechnical Society,2014,29(3):180-188. [14]郑萍,雷雨,吴帆,等.电动汽车用六相永磁容错电机的分析和设计[J].电机与控制学报,2013,17(6):29-36. Zheng Ping,Lei Yu,Wu Fan,et al.Analysis and design of a six-phase fault-tolerant PM machine used for EVs[J].Electric Machines and Control,2013,17(6):29-36. [15]司宾强,朱纪洪,吉敬华.四相永磁容错电机短路故障容错策略[J].控制与决策,2014,29(8):1489-1494. Si Binqiang,Zhu Jihong,Ji Jinghua.Two short-circuit fault tolerant strategies for four-phase permanent magnet fault-tolerant machine[J].Control and Decision,2014,29(8):1489-1494. [16]吉敬华,刘文庆,赵文祥.一种永磁容错电机短路故障的补偿控制[J].微电机,2014,47(2):24-28. Ji Jinghua,Liu Wenqing,Zhao Wenxiang.Remedial shortcircuit control of permanent magnet fault-tolerant motor[J].Micromotors,2014,47(2):24-28. [17]Ertugrul N,Soong W,Dostal G,et al.Fault tolerant motor drive system with redundancy for critical applications[C]//Power Electronics Specialists Conference,2002,3:1457-1462. [18]Zhu J W,Ertugrul N,Soong W L.Fault analysis and remedial strategies on a fault-tolerant motor drive with redundancy[C]//IEEE International Electric Machines & Drives Conference,Antalya,2007,2:1119-1124. [19]Hu Yashan,Zhu Ziqiang,Liu Kan.Current control for dual three-phase permanent magnet synchronous motors accounting for current unbalance and harmonics[J].IEEE Journal of Emerging and Selected Topics in Power Electronics,2014,2(2):272-284. [20]张晓晨,朱景伟.双余度永磁容错电机开路故障补救策略研究[J].微电机,2011,44(9):5-8. Zhang Xiaochen,Zhu Jingwei.Study on open circuit fault remedial strategy of a dual fault tolerant permanent magnet motor with redundancy[J].Micromotors,2011,44(9):5-8. [21]朱景伟,刁亮,任宝珠.具有冗余特性的永磁容错电机短路故障分析与控制[J].电工技术学报,2013,28(3):80-86. Zhu Jingwei,Diao Liang,Ren Baozhu.Analysis and control of short-circuit fault in a fault-tolerant permanent magnet motor drive with redundancy[J].Transactions of China Electrotechnical Society,2013,28(3):80-86. [22]Guo Hong,Xu Jinquan,Kuang Xiaolin.A novel fault tolerant permanent magnet synchronous motor with improved optimal torque control for aerospace application[J].Chinese Journal of Aeronautics,2015,28(2):535-544. [23]李小庆,朱景伟,孙军浩,等.双绕组永磁容错电机矢量控制系统研究[J].电工技术学报,2016,31(5):26-34. Li Xiaoqing,Zhu Jingwei,Sun Junhao,et al.Study on the vector control system for dual winding fault-tolerant permanent magnet motors[J].Transactions of China Electrotechnical Society,2016,31(5):26-34. [24]黄义红,郝振洋,穆晓敬.基于双绕组永磁容错电机双余度控制系统研究[J].电工电能新技术,2014,33(6):36-40,74. Huang Yihong,Hao Zhenyang,Mu Xiaojing.Dual-redundancy fault tolerant permanent magnet motor control system[J].Advanced Technology of Electrical Engineering and Energy,2014,33(6):36-40,74. [25]蒋雪峰,黄文新,郝振洋,等.双绕组永磁容错电机的余度电驱动系统[J].电工技术学报,2015,30(6):22-29. Jiang Xuefeng,Huang Wenxin,Hao Zhenyang,et al.Redundant control system of dual-winding fault-tolerant permanent magnet motor[J].Transactions of China Electrotechnical Society,2015,30(6):22-29. [26]吴一丰,邓智泉,王宇,等.六相永磁容错磁通切换电机及其单相故障的容错控制[J].电工技术学报,2013,28(3):71-79,106. Wu Yifeng,Deng Zhiquan,Wang Yu,et al.Six-phase fault-tolerant flux switching permanent magnet motor and control strategy for single-phase fault condition[J].Transactions of China Electrotechnical Society,2013,28(3):71-79,106.
2016, Vol. 31 
