Characteristic Analysis of PMSM Rotor Position Measurement and Estimation Methods with Signal Injection
Fu Xinghe1, Wang Xinyuan1, Liu Chengjun2
1. School of Electrical Engineering Southeast University Nanjing 210096 China; 2. School of Electrical Engineering and Automation Harbin Institute of Technology Harbin 150001 China
Abstract:The essence of inductosyn and resolver technology is a “generator” based on the principle of electromagnetic induction. It can be viewed as a rotor position measurement method based on the injection of high-frequency signals. The high-frequency signal injection method in rotor position estimation is also excited by a high-frequency signal. However, the literature mainly focuses on the internal comparison of measurement or estimation methods. The specific structural differences, algorithm correlation, and parameter sensitivity of the two methods require further study. The position measurement or estimation method is interpreted from the perspective of system identification. It can be summarized as two steps: applying excitation to the physical carrier and generating an output response, and processing the output response to obtain state information. Under the premise of high-frequency signal injection, PMSM rotor position acquisition methods can be divided into two categories: direct measurement methods based on inductosyn or resolver, and indirect estimation methods based on the motor. The physical carrier of the rotor position acquisition method based on high-frequency signal injection is simplified from the initial “sensor + motor” combination to a single-motor process, where the motor serves as the detection element and the driving motor. The physical carrier characteristics of the two methods are compared, and the equivalent circuit diagrams of the physical carriers are given. Although the rotor position estimation method does not need additional position detection elements, it is comparable to transferring the problem to the system control level. The position solution method in rotor position acquisition is divided into open-loop and closed-loop position solutions. The closed-loop position solution method, represented by the phase-locked loop, is emphatically analyzed. The unified negative feedback block diagram of rotor position identification under closed-loop negative feedback and the negative feedback interpretation are summarized and established. Compared with the measurement method, the PMSM estimation method has a greater impact on model simplification and the signal processing process. Finally, the comprehensive characteristics, advantages, and disadvantages of the measurement and estimation methods are compared, and the key technology prospects are given. The following conclusions are drawn. (1) The core idea of the rotor position estimation method is the same as the position measurement principle of inductosyn or resolver. (2) The solution method of the PMSM rotor position mainly adopts the phase-locked loop structure. The purpose is to ensure that the position deviation signal approaches zero, so that the solution method exhibits unity characteristics. (3) The PMSM rotor position information is hidden in the amplitude or phase of the constructed sine and cosine functions. The purpose of information processing is to extract the position signal from the amplitude or phase. (4) The error of the PMSM rotor position measurement method mainly comes from the process of sensor manufacturing and installation, and the influence of the solution method is minor. The processes of model simplification, excitation injection, and signal demodulation primarily influence the error of the estimation method.
付兴贺, 王新元, 刘承军. 依托信号注入的PMSM转子位置测量与估计方法的特征分析[J]. 电工技术学报, 2026, 41(2): 457-474.
Fu Xinghe, Wang Xinyuan, Liu Chengjun. Characteristic Analysis of PMSM Rotor Position Measurement and Estimation Methods with Signal Injection. Transactions of China Electrotechnical Society, 2026, 41(2): 457-474.
[1] 王奇维, 李斌兴, 潘冠丞, 等. 基于转子位置误差解耦阻抗建模的永磁同步电机电感在线辨识方法[J]. 电工技术学报, 2025, 40(2): 439-451. Wang Qiwei, Li Binxing, Pan Guancheng, et al.Impedance model based online inductance identi- fication method of permanent magnet synchronous motor decoupled from rotor position error[J]. Transa- ctions of China Electrotechnical Society, 2025, 40(2): 439-451. [2] 罗力岩, 樊启高. 一种改进型永磁同步电机无模型预测电流控制策略[J]. 电工技术学报, 2025, 40(4): 1034-1045. Luo Liyan, Fan Qigao.An improved model-free predictive current control strategy for permanent magnet synchronous motors[J]. Transactions of China Electrotechnical Society, 2025, 40(4): 1034-1045. [3] 秦毅, 王阳阳, 彭东林, 等. 电感式角位移传感器技术综述[J]. 仪器仪表学报, 2022, 43(11): 1-14. Qin Yi, Wang Yangyang, Peng Donglin, et al.Inductive angular displacement sensors technologies: a review[J]. Chinese Journal of Scientific Instrument, 2022, 43(11): 1-14. [4] Luo Xin, Tang Qipeng, Shen Anwen, et al.A combining FPE and additional test vectors hybrid strategy for IPMSM sensorless control[J]. IEEE Transactions on Power Electronics, 2017, 33(7): 6104-6113. [5] 陈涛, 周扬忠, 屈艾文, 等. 基于旋转高频电压注入的六相串联三相永磁同步电机系统转子初始位置解耦观测[J]. 电工技术学报, 2023, 38(8): 2073-2085. Chen Tao, Zhou Yangzhong, Qu Aiwen, et al.Decoupling observation of rotor initial position of six-phase and three-phase permanent magnet syn- chronous motors series-connected system based on rotating high-frequency voltage injection[J]. Transa- ctions of China Electrotechnical Society, 2023, 38(8): 2073-2085. [6] 张彦平, 尹忠刚, 苏明, 等. 基于共振扩张状态观测器的内置式永磁同步电机统一全速域无位置传感器控制[J]. 电工技术学报, 2023, 38(22): 6070-6081. Zhang Yanping, Yin Zhonggang, Su Ming, et al.Unified full speed sensorless control of interior permanent magnet synchronous motor based on resonance extended state observer[J]. Transactions of China Electrotechnical Society, 2023, 38(22): 6070-6081. [7] Hind D, Li Chen, Sumner M, et al.Realising robust low speed sensorless PMSM control using current derivatives obtained from standard current sen- sors[C]//2017 IEEE International Electric Machines and Drives Conference (IEMDC), Miami, FL, USA, 2017: 1-6. [8] Zhang Guoqiang, Wang Gaolin, Xu Dianguo.Saliency- based position sensorless control methods for PMSM drives-a review[J]. Chinese Journal of Electrical Engineering, 2017, 3(2): 14-23. [9] 于艳君, 王本振, 朱春波, 等. 载波频率成分法估算IPMSM转子位置的误差分析[J]. 电工技术学报, 2010, 25(12): 61-66. Yu Yanjun, Wang Benzhen, Zhu Chunbo, et al.Analysis of rotor position estimated error for IPMSM using carrier frequency component method[J]. Transac- tions of China Electrotechnical Society, 2010, 25(12): 61-66. [10] Briz F, Degner M W, Garcia P, et al.Rotor position estimation of AC machines using the zero sequence carrier signal voltage[C]//Conference Record of the IEEE Industry Applications Conference, 39th IAS Annual Meeting, Seattle, WA, USA, 2004: 1305-1312. [11] 王菁, 颜建虎, 季国东, 等. 一种基于双位置观测器的永磁同步电机低速无位置传感器控制方法[J]. 电工技术学报, 2023, 38(2): 375-386. Wang Jing, Yan Jianhu, Ji Guodong, et al.A sensor- less control method for permanent magnet syn- chronous machine based on dual position observers at low speed[J]. Transactions of China Electrotechnical Society, 2023, 38(2): 375-386. [12] 许培林, 邓智泉, 王宇, 等. 12/10极永磁磁通切换电机转子初始位置检测[J]. 中国电机工程学报, 2013, 33(9): 104-114. Xu Peilin, Deng Zhiquan, Wang Yu, et al.Initial rotor position detection of 12/10 flux-switching permanent magnet motors[J]. Proceedings of the CSEE, 2013, 33(9): 104-114. [13] Rovere L, Formentini A, Gaeta A, et al.Sensorless finite-control set model predictive control for IPMSM drives[J]. IEEE Transactions on Industrial Electronics, 2016, 63(9): 5921-5931. [14] 陈卓易, 邱建琪, 金孟加. 内置式永磁同步电机无位置传感器自适应集总电动势模型预测控制[J]. 电工技术学报, 2018, 33(24): 5659-5669. Chen Zhuoyi, Qiu Jianqi, Jin Mengjia.Sensorless adaptive lumped electromotive-force model predictive control of interior permanent magnet synchronous motors[J]. Transactions of China Electrotechnical Society, 2018, 33(24): 5659-5669. [15] Accetta A, Cirrincione M, Pucci M, et al.Sensorless control of PMSM fractional horsepower drives by signal injection and neural adaptive-band filtering[J]. IEEE Transactions on Industrial Electronics, 2011, 59(3): 1355-1366. [16] Wang Henghong, Wang Jiyao, Xu Wei.A high precision initial position estimation method for low saliency ratio machine based on image tracking[J]. IEEE Transactions on Power Electronics, 2023, 38(11): 13612-13624. [17] 王恒泓, 王激尧, 徐炜, 等. 基于领域对抗网络的永磁同步电机初始位置估计[J]. 电工技术学报, 2025, 40(2): 425-438. Wang Henghong, Wang Jiyao, Xu Wei, et al.Initial position estimation of surface permanent magnet synchronous motor base on domain-adversarial neural networks[J]. Transactions of China Electrotechnical Society, 2025, 40(2): 425-438. [18] Ferreira O C, Kennel R.Encoderless control of industrial servo drives[C]//2006 12th International Power Electronics and Motion Control Conference, Portoroz, Slovenia, 2006: 1962-1967. [19] Acarnley P P, Watson J F.Review of position- sensorless operation of brushless permanent-magnet machines[J]. IEEE Transactions on Industrial Elec- tronics, 2006, 53(2): 352-362. [20] Sul S K, Kwon Y C, Lee Y.Sensorless control of IPMSM for last 10 years and next 5 years[J]. CES Transactions on Electrical Machines and Systems, 2017, 1(2): 91-99. [21] Wang Gaolin, Valla M, Solsona J.Position sensorless permanent magnet synchronous machine drives: a review[J]. IEEE Transactions on Industrial Elec- tronics, 2019, 67(7): 5830-5842. [22] 刘计龙, 肖飞, 沈洋, 等. 永磁同步电机无位置传感器控制技术研究综述[J]. 电工技术学报, 2017, 32(16): 76-88. Liu Jilong, Xiao Fei, Shen Yang, et al.Position- sensorless control technology of permanent-magnet synchronous motor-a review[J]. Transactions of China Electrotechnical Society, 2017, 32(16): 76-88. [23] 李浩源, 张兴, 杨淑英, 等. 基于高频信号注入的永磁同步电机无传感器控制技术综述[J]. 电工技术学报, 2018, 33(12): 2653-2664. Li Haoyuan, Zhang Xing, Yang Shuying, et al.Review on sensorless control of permanent magnet synchronous motor based on high-frequency signal injection[J]. Transactions of China Electrotechnical Society, 2018, 33(12): 2653-2664. [24] 马瑞卿, 陈鹏. 永磁同步电机初始位置辨识方法研究与进展[J]. 航空学报, 2024, 45(3): 028776. Ma Ruiqing, Chen Peng.Research and development trend of initial position identification methods for permanent magnet synchronous motors[J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(3): 028776. [25] 倪荣刚, 蔡亚倩, 韩思雨, 等. 基于匝数气隙双分段的改进绕组函数解析分析方法[J]. 电气工程学报, 2023, 18(4): 66-73. Ni Ronggang, Cai Yaqian, Han Siyu, et al.Modified winding function analytical analysis method based on segmentation of both coil and air gap distributions[J]. Journal of Electrical Engineering, 2023, 18(4): 66-73. [26] 孙明阳, 和阳, 邱先群, 等. 随机频率三角波注入永磁同步电机无位置传感器降噪控制[J]. 电工技术学报, 2023, 38(6): 1460-1471. Sun Mingyang, He Yang, Qiu Xianqun, et al.Random-frequency triangular wave injection based sensorless control of PMSM drives for audible noise reduction[J]. Transactions of China Electrotechnical Society, 2023, 38(6): 1460-1471. [27] Chen Shuo, Ding Wen, Wu Xiang, et al.Sensorless control of IPMSM drives using high-frequency pulse voltage injection with random pulse sequence for audible noise reduction[J]. IEEE Transactions on Power Electronics, 2023, 38(8): 9395-9408. [28] Xu P L, Zhu Z Q.Novel carrier signal injection method using zero-sequence voltage for sensorless control of PMSM drives[J]. IEEE Transactions on Industrial Electronics, 2016, 63(4): 2053-2061. [29] Xu P L, Zhu Z Q.Novel square-wave signal injection method using zero-sequence voltage for sensorless control of PMSM drives[J]. IEEE Transactions on Industrial Electronics, 2016, 63(12): 7444-7454. [30] Li Haoyuan, Zhang Xing, Yang Shuying, et al.Unified graphical model of high-frequency signal injection methods for PMSM sensorless control[J]. IEEE Transactions on Industrial Electronics, 2020, 67(6): 4411-4421. [31] 杨健, 杨淑英, 李浩源, 等. 基于旋转高频电压注入的永磁同步电机转子初始位置辨识方法[J]. 电工技术学报, 2018, 33(15): 3547-3555. Yang Jian, Yang Shuying, Li Haoyuan, et al.Initial rotor position estimation for IPMSM based on high frequency rotating voltage injection[J]. Transactions of China Electrotechnical Society, 2018, 33(15): 3547-3555. [32] 鲁家栋, 刘景林, 卫丽超. 永磁同步电机转子初始位置检测方法[J]. 电工技术学报, 2015, 30(7): 105-111. Lu Jiadong, Liu Jinglin, Wei Lichao.Estimation of the initial rotor position for permanent magnet synchronous motors[J]. Transactions of China Elec- trotechnical Society, 2015, 30(7): 105-111. [33] Sarma S, Agrawal V K, Udupa S.Software-based resolver-to-digital conversion using a DSP[J]. IEEE Transactions on Industrial Electronics, 2008, 55(1): 371-379. [34] Shuang Bo, Zhu Ziqiang.A novel sensorless initial position estimation and startup method[J]. IEEE Transactions on Industrial Electronics, 2021, 68(4): 2964-2975. [35] Sun Le, Nalakath S, Callegaro A D, et al.Investi- gation of a practical convex-optimization-based sensorless scheme for IPMSM drives[J]. IEEE Transactions on Power Electronics, 2019, 34(12): 12437-12452. [36] Sun Le, Li Xiaoxiang, Chen Longmiao.Motor speed control with convex optimization-based position estimation in the current loop[J]. IEEE Transactions on Power Electronics, 2021, 36(9): 10906-10919. [37] 吴春, 应王瑞, 郑露华, 等. 一种旋转变压器双采样差分位置解码方法[J]. 电工技术学报, 2024, 39(15): 4896-4908. Wu Chun, Ying Wangrui, Zheng Luhua, et al.A dual-sampling differential position decoding method for resolvers[J]. Transactions of China Electro- technical Society, 2024, 39(15): 4896-4908. [38] 王兴华, 孙纯祥, 周成岩. 基于AD2S80A的高精度测角测速系统设计[J]. 微电机, 2008, 41(10): 50-53, 80. Wang Xinghua, Sun Chunxiang, Zhou Chengyan.High precision angle and velocity measuring system based on AD2S80A[J]. Micromotors, 2008, 41(10): 50-53, 80. [39] 李浩源, 张兴, 杨淑英, 等. 基于旋转高频注入的内置式永磁同步电机初始位置检测算法[J]. 电工技术学报, 2018, 33(8): 1723-1731. Li Haoyuan, Zhang Xing, Yang Shuying, et al.A detecting algorithm for initial position of interior permanent magnet synchronous motor based on rotating high frequency injection[J]. Transactions of China Electrotechnical Society, 2018, 33(8): 1723-1731. [40] Corley M J, Lorenz R D.Rotor position and velocity estimation for a salient-pole permanent magnet synchronous machine at standstill and high speeds[J]. IEEE Transactions on Industry Applications, 2002, 34(4): 784-789. [41] Wu Ximeng, Zhu Ziqiang, Wu Zhanyuan.A rotor initial position estimation method for surface- mounted permanent magnet synchronous machine[J]. IEEE Transactions on Energy Conversion, 2021, 36(3): 2012-2024. [42] Raca D, Harke M C, Lorenz R D.Robust magnet polarity estimation for initialization of PM syn- chronous machines with near-zero saliency[J]. IEEE Transactions on Industry Applications, 2008, 44(4): 1199-1209. [43] 李洁, 周波, 刘兵, 等. 表贴式永磁同步电机无位置传感器起动新方法[J]. 中国电机工程学报, 2016, 36(9): 2513-2520. Li Jie, Zhou Bo, Liu Bing, et al.A novel starting strategy of sensorless control for surface mounted permanent magnet synchronous machines[J]. Pro- ceedings of the CSEE, 2016, 36(9): 2513-2520. [44] 李海霞, 张嵘, 韩丰田. 感应同步器测角系统误差测试及补偿[J]. 清华大学学报(自然科学版), 2016, 56(6): 611-616. Li Haixia, Zhang Rong, Han Fengtian.Error testing and compensation of an inductosyn-based angular measurement system[J]. Journal of Tsinghua Univer- sity (Science and Technology), 2016, 56(6): 611-616. [45] 李景灿, 廖勇. 考虑饱和及转子磁场谐波的永磁同步电机模型[J]. 中国电机工程学报, 2011, 31(3): 60-66. Li Jingcan, Liao Yong.Model of permanent magnet synchronous motor considering saturation and rotor flux harmonics[J]. Proceedings of the CSEE, 2011, 31(3): 60-66. [46] Wang Jianmin, Gao Jianzhuo.Influence of speed EMF on position estimation error in carrier signal injection based sensorless control of PMSM[C]//2012 15th International Conference on Electrical Machines and Systems (ICEMS), Sapporo, Japan, 2012: 1-6. [47] Raca D, Garcia P, Reigosa D, et al.A comparative analysis of pulsating vs. rotating vector carrier signal injection-based sensorless control[C]//2008 Twenty- Third Annual IEEE Applied Power Electronics Conference and Exposition, Austin, TX, USA, 2008: 879-885. [48] Staines C S, Caruana C, Raute R.A review of saliency- based sensorless control methods for alternating current machines[J]. IEEJ Journal of Industry Appli- cations, 2014, 3: 86-96. [49] 李海斌, 蔡伟, 李国英. 圆感应同步器方位测角系统误差产生与消除[J]. 传感器技术, 2005, 24(6): 17-19, 22. Li Haibin, Cai Wei, Li Guoying.Error source and elimination of inductosyn azimuth angular measure- ment system[J]. Journal of Transducer Technology, 2005, 24(6): 17-19, 22. [50] 刘海东, 周波, 郭鸿浩, 等. 脉振高频信号注入法误差分析[J]. 电工技术学报, 2015, 30(6): 38-44. Liu Haidong, Zhou Bo, Guo Honghao, et al.Error analysis of high frequency pulsating signal injection method[J]. Transactions of China Electrotechnical Society, 2015, 30(6): 38-44. [51] Gabriel F, De Belie F, Neyt X, et al.High-frequency issues using rotating voltage injections intended for position self-sensing[J]. IEEE Transactions on Indu- strial Electronics, 2012, 60(12): 5447-5457. [52] Song Li, Kang Jianbing, Li Jing.A design of indu- ctosyn angle measurement system based on AD2S80A and FPGA[C]//2017 36th Chinese Control Conference (CCC), Dalian, China, 2017: 5350-5353. [53] 汪剑鸣, 袁臣虎, 刘瑞, 等. 基于四线旋转变压器及AD2S1200的叉车线控转向永磁同步电机角度解码研究[J]. 电工技术学报, 2015, 30(增刊2): 95-100. Wang Jianming, Yuan Chenhu, Liu Rui, et al.Research on PMSM rotor position decoding of the forklift steer-by-wire system based on the four-line resolver and AD2S1200[J]. Transactions of China Electrotechnical Society, 2015, 30(S2): 95-100. [54] 麦志勤, 肖飞, 刘计龙, 等. 基于改进型自调整轴系幅值收敛电流解调算法的旋转高频电压注入法[J]. 电工技术学报, 2021, 36(10): 2049-2060. Mai Zhiqin, Xiao Fei, Liu Jilong, et al.Rotating high-frequency voltage injection method based on improved self-adjusting frame amplitude convergence current demodulation algorithm[J]. Transactions of China Electrotechnical Society, 2021, 36(10): 2049-2060. [55] Xu Peilin, Zhu Z Q.Initial rotor position estimation using zero-sequence carrier voltage for permanent- magnet synchronous machines[J]. IEEE Transactions on Industrial Electronics, 2017, 64(1): 149-158. [56] Lin Zhichen, Li Xinmin, Wang Zhiqiang, et al.Minimization of additional high-frequency torque ripple for square-wave voltage injection IPMSM sensorless drives[J]. IEEE Transactions on Power Electronics, 2020, 35(12): 13345-13355.