Abstract：Metallized film capacitors (MFCs) are essential components in modular multilevel converters (MMCs) used for flexible direct current (DC) transmission. The assessment of their aging state is critical to ensuring the reliability of MMCs. This study aims to establish a non-intrusive aging evaluation method for MFCs based on the analysis of phase-resolved partial discharge (PRPD) spectra derived from ultrasonic signals, thereby providing real-time condition monitoring without interrupting system operation. An experimental setup was constructed to facilitate accelerated aging of MFCs and to capture discharge events through ultrasonic sensing. Metallized polypropylene film capacitor samples, each with a rated capacitance of 18 µF and rated voltage of 2 kV, were subjected to an elevated voltage of 1.5 times their nominal rating under a controlled temperature of 65℃. The ultrasonic signals generated during discharge events were recorded using high-sensitivity ultrasonic sensors placed at the grounded terminals of the capacitors. The recorded ultrasonic data were processed to obtain PRPD spectra, which characterize the discharge event phase distribution and amplitude. Several key metrics were extracted, including phase entropy, amplitude entropy, and their respective standard deviations. These metrics were used to construct a comprehensive health index (HI) that was combined with the observed capacitance decline data. A linear regression model was subsequently developed to relate the HI to the aging state, with optimal weights for the HI parameters determined through nonlinear optimization. The experimental results revealed distinct changes in PRPD characteristics as aging progressed. Initially, the self-healing discharges dominated, but as the capacitor aged, partial discharges became more significant. As the capacitance degraded from 100% to 94% of its nominal value (C0), the proportion of self-healing discharges decreased from 47.6% to 18.5%, while the proportion of partial discharges increased from 52.4% to 81.5%. The PRPD spectra showed that the phase distribution of discharges became more dispersed, while discharge amplitudes concentrated at lower levels during the aging process. The health index effectively captured the trends in PRPD spectra, with the linear regression model demonstrating an error of less than 1 percentage point compared to offline capacitance measurements conducted using a high-precision bridge. This finding indicates that the health index can reliably represent the MFC aging state, providing a basis for real-time evaluation without invasive electrical testing. The proposed method presents a novel, non-intrusive approach for assessing the aging of metallized polypropylene film capacitors, particularly suitable for use in MMCs within flexible DC transmission systems. The ultrasonic-based analysis of PRPD spectra not only avoids interference with electrical circuitry but also provides strong anti-interference capability and high precision. The health index, constructed from phase entropy, amplitude entropy, and their standard deviations, correlates effectively with the decline in capacitance, enabling a quantitative assessment of the aging state. This contributes to the development of non-electrical parameter-based monitoring techniques for power electronic capacitors. Future work will focus on further refining the health index model and exploring its application to other capacitor types or components in high-voltage power systems. Expanding the use of non-electrical monitoring parameters could enhance the reliability of aging assessment methods in critical power electronics applications.
许馨愉, 汲胜昌, 郑琳子, 闫昕旖, 祝令瑜. 基于超声信号的金属化膜电容器老化状态评估方法[J]. 电工技术学报, 2025, 40(5): 1652-1661.
Xu Xinyu, Ji Shengchang, Zheng Linzi, Yan Xinyi, Zhu Lingyu. Aging State Evaluation Method of Metallized Film Capacitors Based on Ultrasonic Signals. Transactions of China Electrotechnical Society, 2025, 40(5): 1652-1661.
[1] 岳国华, 杜志叶, 蔡泓威, 等. 基于风速概率分布与风切变指数的直流输电线路离子流场数值模拟方法[J]. 电工技术学报, 2024, 39(9): 2907-2915. Yue Guohu, Du Zhiye, Cai Hongwei, et al.Numerical simulation method of ion flow field in DC transmission line based on wind speed probability distribution and wind shear exponent[J]. Transactions of China Electrotechnical Society, 2024, 39(9): 2907-2915. [2] 王淏, 谢开贵, 邵常政, 等. 柔性互联输配一体化电网有损潮流的精细化建模及应用[J]. 电工技术学报, 2024, 39(9): 2593-2607. Wang Hao, Xie Kaigui, Shao Changzheng, et al.Precise lossy power flow modeling and application of integrated transmission and distribution grids with multi-terminal flexible interconnected[J]. Transactions of China Electrotechnical Society, 2024, 39(9): 2593-2607. [3] 张国豪, 李化, 林福昌, 等. 金属化聚丙烯膜电容器自愈产气特性与保护技术[J]. 高压电器, 2024, 60(6): 197-202, 211. Zhang Guohao, Li Hua, Lin Fuchang, et al.Study on self-healing gas generation characteristics and protection technology of metallized polypropylene film capacitor[J]. High Voltage Apparatus, 2024, 60(6): 197-202, 211. [4] 雷万钧, 刘进军, 吕高泰, 等. 大容量电力电子装备关键器件及系统可靠性综合分析与评估方法综述[J]. 高电压技术, 2020, 46(10): 3353-3361. Lei Wanjun, Liu Jinjun, Lü Gaotai, et al.Review of reliability comprehensive analysis and evaluation methods for key components and system of large capacity power electronic equipment[J]. High Voltage Engineering, 2020, 46(10): 3353-3361. [5] 王雨橙, 李化, 王哲豪, 等. 结晶度对金属化膜电容器保压性能的影响[J]. 高电压技术, 2022, 48(9): 3643-3650. Wang Yucheng, Li Hua, Wang Zhehao, et al.Voltage maintaining performance of metallized film capacitors based on crystallinity regulation[J]. High Voltage Engineering, 2022, 48(9): 3643-3650. [6] 付华, 陈浩轩, 李秀菊, 等. 含边界元件的MMC-MTDC直流侧单端量故障辨识方法[J]. 电工技术学报, 2021, 36(1): 215-226. Fu Hua, Chen Haoxuan, Li Xiuju, et al.MMC-MTDC DC side single-ended quantity fault identification method with boundary elements[J]. Transactions of China Electrotechnical Society, 2021, 36(1): 215-226. [7] 张午宇, 齐磊, 张翔宇, 等. 计及金属化薄膜电容器与IGBT模块退化过程相关性的柔直换流阀组件可靠性评估方法[J]. 电工技术学报, 2024, 39(14): 4508-4518. Zhang Wuyu, Qi Lei, Zhang Xiangyu, et al.Reliability evaluation method for VSC-HVDC valve submodules considering the correlation between the degradation process of metallized polypropylene film capacitors and IGBT modules[J]. Transactions of China Electrotechnical Society, 2024, 39(14): 4508-4518. [8] 吴云杰, 张金保, 赖伟, 等. 基于金属化薄膜电容器状态在线监测的剩余寿命评估方法[J]. 电工技术学报, 2024, 39(22): 7239-7255. Wu Yunjie, Zhang Jinbao, Lai Wei, et al.Remaining lifetime assessment method based on on-line condition monitoring of metallized film capacitors[J]. Transactions of China Electrotechnical Society, 2024, 39(22): 7239-7255. [9] Vogelsberger M A, Wiesinger T, Ertl H.Life-cycle monitoring and voltage-managing unit for DC-link electrolytic capacitors in PWM converters[J]. IEEE Transactions on Power Electronics, 2011, 26(2): 493-503. [10] Pu Xingsi, Nguyen T H, Lee D C, et al.Fault diagnosis of DC-link capacitors in three-phase AC/DC PWM converters by online estimation of equivalent series resistance[J]. IEEE Transactions on Industrial Electronics, 2013, 60(9): 4118-4127. [11] Wang Hanyu, Wang Huai, Wang Zhongxu, et al.Condition monitoring for submodule capacitors in modular multilevel converters[J]. IEEE Transactions on Power Electronics, 2019, 34(11): 10403-10407. [12] Geng Zhi, Han Minxiao, Zhou Guangyang.Switching signals based condition monitoring for submodule capacitors in modular multilevel converters[J]. IEEE Transactions on Circuits and Systems II: Express Briefs, 2021, 68(6): 2017-2021. [13] 夏宏鉴, 陈民铀, 赖伟, 等. 基于频带能量的模块化多电平换流阀中金属化薄膜电容器失效检测方法[J]. 中国电机工程学报, 2021, 41(22): 7782-7793. Xia Hongjian, Chen Minyou, Lai Wei, et al.Failure detection method for metalized polypropylene film capacitor in modular multilevel converter based on band energy[J]. Proceedings of the CSEE, 2021, 41(22): 7782-7793. [14] Shrivastava A, Azarian M H, Morillo C, et al.Detection and reliability risks of counterfeit electrolytic capacitors[J]. IEEE Transactions on Reliability, 2014, 63(2): 468-479. [15] 张力, 李军, 张林元, 等. 开关柜局部放电检测技术应用及研究现状[J]. 科技创新与应用, 2022, 12(26): 172-175. [16] 国家市场监督管理总局, 国家标准化管理委员会. 电力电子电容器: GB/T 17702—2021[S]. 北京: 中国标准出版社, 2021. [17] 杜一鸣, 潘亮, 祝令瑜, 等. 金属化膜电容器交流和直流电压劣化特性分析[J]. 电力工程技术, 2020, 39(6): 151-158. Du Yiming, Pan Liang, Zhu Lingyu, et al.AC and DC voltage degradation characteristics of metallized film capacitors[J]. Electric Power Engineering Technology, 2020, 39(6): 151-158. [18] Wang Huai, Nielsen D A, Blaabjerg F.Degradation testing and failure analysis of DC film capacitors under high humidity conditions[J]. Microelectronics Reliability, 2015, 55(9/10): 2007-2011. [19] 程璐, 李志元, 王镜然, 等. 高压直流电场与谐波耦合作用下金属化膜电容器失效研究[J]. 中国电机工程学报, 2023, 43(22): 8955-8965. Cheng Lu, Li Zhiyuan, Wang Jingran, et al.Mechanism study on the failure of metalized film capacitor under HVDC field superimposed harmonics[J]. Proceedings of the CSEE, 2023, 43(22): 8955-8965. [20] Gallay R.Metallized film capacitor lifetime evaluation and failure mode analysis[C]// Proceedings of the 2014 CAS-CERN Accelerator School: Power Converters, Baden, Switzerland, 2014: 45-56. [21] 郑宇锋, 江汉红. 高压脉冲储能电容器特性分析[J]. 海军工程大学学报, 2016, 28(增刊1): 44-49. Zheng Yufeng, Jiang Hanhong.Characteristic analysis of high voltage pulse storage capacitor[J]. Journal of Naval University of Engineering, 2016, 28(S1): 44-49. [22] 吕霏. 层间空气对金属化膜电容器工作特性影响的研究[D]. 武汉: 华中科技大学, 2012. Lü Fei.Research on the influence of interlayer air on the performance of metallized film capacitors[D]. Wuhan: Huazhong University of Science and Technology, 2012. [23] 陈温良, 董燕, 贾华. 对金属化膜电容器局部放电和自愈放电性能的初步研究[J]. 电力电容器与无功补偿, 2008, 29(1): 31-36. Chen Wenliang, Dong Yan, Jia Hua.Preliminary research on partial discharge and self-healing characteristics of metallized film capacitors[J]. Power Capacitor & Reactive Power Compensation, 2008, 29(1): 31-36. [24] 黄雪莜, 熊俊, 张宇, 等. 基于残差卷积神经网络的开关柜局部放电模式识别[J]. 中国电力, 2021, 54(2): 44-51. Huang Xueyou, Xiong Jun, Zhang Yu, et al.Partial discharge pattern recognition of switchgear based on residual convolutional neural network[J]. Electric Power, 2021, 54(2): 44-51. [25] Ma Yusheng, Shen Haitao, Pei Chunming, et al.Detection of self-healing discharge in metallized film capacitors using an ultrasonic method[J]. Electronics, 2020, 9(11): 1893.
2025, Vol. 40 
