An Insulation Test Method Based on the Dielectric Insulation Life for Windings in High-Frequency Transformer
Zhao Yikun1,2, Zhang Guoqiang1,2, Han Dong1,2, Li Kang1, Yang Fuyao3
1. Institute of Electrical Engineering Chinese Academy of Sciences Beijing 100190 China 2. University of Chinese Academy of Sciences Beijing 100039 China 3. Global Energy Interconnection Research Institute Beijing 102209 China
Abstract：Although the increase in frequency improves the transmission efficiency of high-frequency transformers, the winding insulation problem is noticeable under high-frequency electro-thermal coupling effect. In order to ensure the long-term stable operation of high-frequency transformer, a method for determining the withstand voltage based on the insulation life of insulating materials was proposed. The ratio of breakdown voltage of 1min to the breakdown voltage of expected life and high-frequency/power frequency conversion factor were obtained based on the V-t characteristics. The recommended values of the applied withstand voltages under high-frequency and power-frequency test conditions were given respectively. In addition, the V-f characteristics of insulting materials were obtained based on Weibull distribution, and the recommended value of the induced withstand test voltage was proposed in combination with increasing frequency and increasing voltage method.
赵义焜, 张国强, 韩冬, 李康, 杨富尧. 基于材料绝缘寿命的高频变压器绕组绝缘试验电压确定方法[J]. 电工技术学报, 2020, 35(13): 2932-2939.
Zhao Yikun, Zhang Guoqiang, Han Dong, Li Kang, Yang Fuyao. An Insulation Test Method Based on the Dielectric Insulation Life for Windings in High-Frequency Transformer. Transactions of China Electrotechnical Society, 2020, 35(13): 2932-2939.
[1] Xu S, Alex Q H, Burgos R.Review of solid-state transformer technologies and their application in power distribution systems[J]. IEEE Journal Emerging Selected Topics in Power Electronics, 2013, 1(3): 186-198. [2] 涂春鸣, 黄红, 兰征, 等. 微电网中电力电子变压器与储能的协调控制策略[J]. 电工技术学报, 2019, 34(12): 2627-2636. Tu Chunming, Huang Hong, Lan Zheng, et al.Coordinated control strategy of power electronic transformer and energy storage in microgrid[J]. Transactions of China Electrotechnical Society, 2019, 34(12): 2627-2636. [3] 曹小鹏, 陈武, 宁光富, 等. 基于多目标遗传算法的大功率高频变压器优化设计[J]. 中国电机工程学报, 2018, 38(5): 1348-1355. Cao Xiaopeng, Chen Wu, Ning Guangfu, et al.Optimization design of high-power high-frequency transformer based on multi-objective genetic algorithm[J]. Proceedings of the CSEE, 2018, 38(5): 1348-1355. [4] 陈彬, 李琳, 赵志斌, 等. 电感集成式大容量高频变压器精细化设计方法[J]. 中国电机工程学报, 2018, 38(5): 1356-1368. Chen Bin, Li Lin, Zhao Zhibin, et al.Design method of inductor-integrated high-power high-frequency transformers[J]. Proceedings of the CSEE, 2018, 38(5): 1356-1368. [5] 张雪垠, 徐永海, 肖湘宁. 适用于中高压配电网的高功率密度谐振型级联H桥固态变压器[J]. 电工技术学报, 2018, 33(2): 310-321. Zhang Xueyin, Xu Yonghai, Xiao Xiangning.A high power density resonance cascaded H-bridge solid-state transformer for medium and high voltage distribution network[J]. Transactions of China Electrotechnical Society, 2018, 33(2): 310-321. [6] 王鹏, 赵政嘉, 刘雪山, 等. 电力电子设备中的电气绝缘问题[J]. 高电压技术, 2018, 44(7): 2309-2322. Wang Peng, Zhao Zhengjia, Liu Xueshan, et al.Electrical insulation problems in power electronics devices[J]. High Voltage Engineering, 2018, 44(7): 2309-2322. [7] Zhao Yikun, Zhang Guoqiang. Guo Runrui, et al.The breakdown characteristics of thermostable insulation materials under high-frequency square waveform[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2019, 26(4): 1073-1080. [8] 周远翔, 邢晓亮, 聂琼, 等. 高频下电树老化引起的高密度聚乙烯击穿现象[J]. 高电压技术, 2007, 33(12): 14-18. Zhou Yuanxiang, Xing Xiaoliang, Nie Qiong, et al.Breakdown phenomena caused by electrical tree degradation in high density polyethylene under high frequency voltage[J]. High Voltage Engineering, 2007, 33(12): 14-18. [9] Zhao Yikun, Zhang Guoqiang, Guo Runrui, et al.Effect of frequency on discharge characteristics of inter-layer materials in HV-HF transformers[C]// International Conference on Electrical Materials and Power Equipment, Guangzhou, China, 2019: 530-534. [10] Tourkhani F, Viarouge P.Accurate analytical model of winding losses in round Litz wire windings[J]. IEEE Transactions on Magnetics, 2001, 37(1): 538-543. [11] 杨晔, 马玲, 李凯明. 10kV级箔式绕组变压器设计方案的选取[J]. 变压器, 2001, 38(12): 15-16. Yang Ye, Ma Ling, Li Kaiming.Selection of design scheme for 10kV foil winding transformer[J]. Transformer, 2001, 38(12): 15-16. [12] Delaforge T, Chazal H, Schanen J L, et al.Increasing windings efficiency at high frequencies: hollow conductors and clad metal conductors[C]//IEEE Energy Conversion Congress and Eposition, Montreal, 2015: 5689-5695. [13] Kjellqvist T, Norrga S, Ostlund S.Design considerations for a medium frequency transformer in a line side power conversion system[C]//Proceedings of the 35th Annual Power Electronics Specialists Conference, Aachen, Germany, 2004: 704-710. [14] 王有元, 刘玉, 王施又, 等. 电热老化对干式变压器中环氧树脂特性的影响[J]. 电工技术学报, 2018, 33(16): 3906-3916. Wang Youyuan, Liu Yu, Wang Shiyou, et al.The effect of electrothermal aging on the properties of epoxy resin in dry-type transformer[J]. Transactions of China Electrotechnical Society, 2018, 33(16): 3906-3916. [15] Rauls M S, Novotny D W, Divan D M.Design considerations for high-frequency coaxial winding power transformers[J]. IEEE Transactions on Industry Applications, 1993, 29(2): 375-381. [16] Liserre M, Buticchi G, Andresen M, et al.The smart transformer: impact on the electric grid and technology challenges[J]. IEEE Industrial Electronics Magazine, 2016, 10(2): 46-58. [17] IEC 60664—1 Insulation coordination for equipment within low-voltage systems[S]. 2007. [18] GB/T 1094B/T 1094.3—2007 电力变压器第3部分: 绝缘水平、绝缘试验和外绝缘空气间隙[S]. 北京: 中国标准出版社, 2017. [19] 谢毓城. 电力变压器手册[M]. 北京: 机械工业出版社, 2014. [20] GB/T 29310—2012 电气绝缘击穿数据统计分析导则[S]B/T 29310—2012 电气绝缘击穿数据统计分析导则[S]. 北京: 中国标准出版社, 2012. [21] GB/T 1408B/T 1408.1—2006 绝缘材料电气强度试验方法[S]. 北京: 中国标准出版社, 2006. [22] 李英葆, 陈京生. 绝缘材料便查手册[M]. 北京: 中国电力出版社, 2010.
2020, Vol. 35 
