变频电机匝间绝缘故障放电信号电磁辐射特性研究

doi:10.19595/j.cnki.1000-6753.tces.230477

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (2821 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

Insulation degradation and flaws can be identified using the partial discharge (PD) test. Ultra-high-frequency (UHF) antenna sensors are commonly used for the detection of PD signals which are helpful to diagnose the insulation performance of inverter-fed motor. The electromagnetic signal generated by the PD contains a large amount of helpful information. The frequency content of the collected PD is closely related to the type of PD, the type of sensor antenna and the signal receiving device, but it is unclear whether the collected signal is the characteristic of the PD or the characteristic of the tested sample as the transmitting antenna. The turn-turn insulation sample of the motor and its simplified insulation sample (such as single-point cross-insulated sample) have the physical form of a typical dipole antenna. Theoretically, PD is a radiation source. The creation of PD is a normal electromagnetic radiation process, and the insulating sample can be utilized as a transmitting antenna for electromagnetic radiation. Therefore, this paper investigates the electromagnetic radiation characteristics of the turn-turn insulation sample as the transmitting antenna. Then, a PD detection platform for the turn-turn sample was built using a wide-band antenna (0.5-2 GHz Archimedes spirl antenna) to analyse the PD signals in the frequency spectrum.
First, the dipole antenna is modeled using a single point cross polyimide sample. Using high-frequency electromagnetic simulation software, the antenna resonance frequency is calculated, and the radiation characteristics of the test antenna under various lengths and cross-angles are simulated. Then, an experimental platform for PD detection of turn-turn insulation is built by using a repetitive impulse voltage source. Experimental research the impacts of insulation sample length, environment, and impulse voltage parameters on the frequency domain characteristics of PD signal.
The outcomes are as follows: firstly, as insulation sample length is increased, the resonant frequency of the sample antenna and the frequency domain of the PD signal shift to low frequency. The resonant frequency of the 10 cm sample antenna is 2.15 GHz, and the PD information discovered by the experiment with this insulation sample is substantially missing in the frequency domain and has a much reduced amplitude in the time domain. Second, the distribution of PD frequency domain is unaffected by the cross Angle of a single-point cross-insulated sample, changes in atmospheric pressure, changes in impulse voltage rise time, or changes in duty cycle. Finally, the turn-turn insulation sample from the flat wire motor exhibits multi-band characteristics as a transmitting antenna, and its effective working bandwidth completely covers the PD frequency domain distribution of the turn-turn insulation. Additionally, the properties of the sample antenna's multi-resonant band are unaffected by the change in the feed point. The PD frequency domain distribution produced by the turn-turn insulation of the same structure is consistent and is unaffected by changes in PD position.
According to the aforementioned findings, the PD characteristic of the turn-turn insulation is related to its radiation characteristic as a transmitting antenna. In other words, while partial discharge is happening, the insulating sample as a transmitting antenna is actively involved in radiating the electromagnetic wave signal.

Key words： Inverter-fed motors insulation system partial discharge repetitive square wave voltages ultra-high frequency antenna

PACS:

TM855

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Ma Shijin
	Wang Peng
	Zhu Yingwei
	Huang Wendong

Cite this article:

Ma Shijin,Wang Peng,Zhu Yingwei等. Electromagnetic Radiation Characteristics of PD in Inverter-fed Motor Turn-Turn Insulation[J]. Transactions of China Electrotechnical Society, 0, (): 9023-23.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.230477 OR https://dgjsxb.ces-transaction.com/EN/Y0/V/I/9023

[1] Benmamas L, Teste P, Odic E, et al.Contribution to the analysis of PWM inverter parameters influence on the partial discharge inception voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2019, 26(1): 146-152.
[2] B. Hu et al., "A Partial Discharge Study of Medium-Voltage Motor Winding Insulation Under Two-Level Voltage Pulses With High Dv/Dt," in IEEE Open Journal of Power Electronics, vol. 2, pp. 225-235, 2021, doi: 10.1109/OJPEL.2021.3069780.
[3] T. Han and A. Cavallini, "Dielectric properties and partial discharge endurance of thermally aged nano-structured polyimide," in IEEE Electrical Insulation Magazine, vol. 36, no. 3, pp. 39-46, May-June 2020, doi: 10.1109/MEI.2020.9063562.
[4] H. Yoon and G. Chen, "Space Charge Characteristics of Natural Ester oil-impregnated Paper with Different Moisture Contents," in IEEE Transactions on Dielectrics and Electrical Insulation, 2022, doi: 10.1109/TDEI.2022.3202740.
[5] M. Pastura et al., "Partial Discharges in Electrical Machines for the More Electric Aircraft—Part I: A Comprehensive Modeling Tool for the Characterization of Electric Drives Based on Fast Switching Semiconductors," in IEEE Access, vol. 9, pp. 27109-27121, 2021, doi: 10.1109/ACCESS.2021.3058083.
[6] Y. Xu et al., "Impact of High Switching Speed and High Switching Frequency of Wide-Bandgap Motor Drives on Electric Machines," in IEEE Access, vol. 9, pp. 82866-82880, 2021, doi: 10.1109/ACCESS.2021.3086680.
[7] A. Rumi, J. G. Marinelli, D. Barater, A. Cavallini and P. Seri, "The Challenges of Reliable Dielectrics in Modern Aerospace Applications: The Hazard of Corona Resistant Materials," in IEEE Transactions on Transportation Electrification, vol. 8, no. 4, pp. 4646-4653, Dec. 2022, doi: 10.1109/TTE.2022.3191064.
[8] Rotating electrical machines - Part 18-41: Partial discharge free electrical insulation systems (Type I) used in rotating electrical machines fed from voltage converters - Qualification and quality control tests, IEC 60034-18-41, 2014.
[9] International Electrotechnical Commission.Rotating electrical machines- Part 27-5: Off-line partial discharge tests on winding insulation of rotating electrical machine during repetitive impulse voltage excitation: IEC TS 60034-27-5[S]. 2021.
[10] International Electrotechnical Commission.Rotating electrical machines- Part 27-1: Off-line partial discharge measurements on the winding insulation: IEC TS 60034-27-1[S]. 2017.
[11] P. Wang, P. Li, S. Akram, P. Meng, G. Zhu and G.C. Montanari, "Considering the Parameters of PWM Voltage to Improve the SNR of PD Tests for Inverter fed Motors," in IEEE Transactions on Industrial Electronics, doi: 10.1109/TIE.2021.3086433.
[12] G. V. R. Xavier, E. G. da Costa, A. J. R. Serres, L. A. M. M. Nobrega, A. C. Oliveira and H. F. S. Sousa, "Design and Application of a Circular Printed Monopole Antenna in Partial Discharge Detection," in IEEE Sensors Journal, vol. 19, no. 10, pp.3718-3725, 15 May15, 2019, doi: 10.1109/JSEN.2019.2896580.
[13] 芮逸凡,王亚林,周明瑜,罗艺,王海田,孙浩,尹毅.基于柔性馈电螺旋天线和硅光电倍增管的GIS局部放电联合传感技术[J/OL].中国电机工程学报:1-12[2023-04-05].http://kns.cnki.net/kcms/detail/11.2107.TM.20220819.1809.008.html. RUI Yifan, WANG Yalin, ZHOU Mingyu, et al. Partial Discharge Optic-electric Integrated Sensing Technology Based on Helical Antenna Attached Flexible Feeding Network and Silicon Photomultiplier in GIS [J]. Proceedings of the CSEE, 1-12[<date-in-citation content-type="access-date">2023-04-05</date-in-citation>].http://kns.cnki.net/kcms/detail/11.2107.TM.20220819.1809.008.html.
[14] 张国治,胡栩焜,邓广宇等.SF6及SF6故障分解气体与局部放电柔性特高频天线传感器基底相容性实验研究[J/OL].电工技术学报:1-12[2023-04-05].https://doi.org/10.19595/j.cnki.1000-6753.tces.222358. Zhang Guozhi Hu Xukun Deng Guangyu, et al. Experimental Study on Substrate Compatibility of SF6 and SF6 FaultDecomposing Gases with Partial Discharge Flexible UHF Antenna Sensors[J]. Transactions of China Electro-technical Society, 1-12[2023-04-05].https://doi.org/10.19595/j.cnki.1000-6753.tces.222358.
[15] P. Wanget al., "Design of an Effective Antenna for Partial Discharge Detection in Insulation Systems of Inverter-fed Motors," in IEEE Transactions on Industrial Electronics, vol. 69, no. 12, pp. 13727-13735, Dec. 2022, doi: 10.1109/TIE.2021.3130335.
[16] 杨旗,杨帆,高兵等.基于惠更斯原理的电气设备局部放电电磁传播计算方法[J].电工技术学报,2019,34(21):4419-4427.DOI:10.19595/j.cnki.1000-6753.tces.181375. Yang Qi Yang Fan Gao Bing, et al. Research on Electromagnetic Propagation of Partial Discharge for Electrical Equipment Using Huygens Principle [J]. Transactions of China Electrotechnical Society, 2019,34(21):4419-4427.DOI10.19595/j.cnki.1000-6753.tces.181375.
[17] T. Tiengthong, A. M.Jaya Marindra, N. Pattanadech and S. Promwong, "Characterization of Electromagnetic Wave Propagation in Transformer for PD Detection Analysis," 2022 8th International Conference on Engineering, Applied Sciences, and Technology (ICEAST), Chiang Mai, Thailand, 2022, pp. 79-82, doi: 10.1109/ICEAST55249.2022.9826332.
[18] 邹阳,周求宽,刘明军,唐志国,张达.局部放电特高频检测装置抗电磁干扰性能的量化评估方法研究[J].电工技术学报,2020,35(10):2275-2282.DOI:10.19595/j.cnki.1000-6753.tces.190502.
Zou Yang Zhou Qiukuan Liu Mingjun, et al. Research on Quantitative Evaluation on Anti-Electromagnetic Interference Capability of Ultra High Frequency Partial Discharge Detection Instrument[J]. Transactions of China Electrotechnical Society, 2020,35(10):2275-2282.DOI:10.19595/j.cnki.1000-6753.tces.190502.
[19] 王艳新,闫静,王建华,耿英三,刘志远.基于域对抗迁移卷积神经网络的小样本GIS绝缘缺陷智能诊断方法[J].电工技术学报,2022,37(09):2150-2160.DOI:10.19595/j.cnki.1000-6753.tces.211512. Wang Yanxin Yan Jing Wang Jianhua, et al. Intelligent Diagnosis for GIS with Small Samples Using a Novel Adversarial Transfer Learning in Convolutional Neural Network[J]. Transactions of China Electrotechnical Society, 2022,37(09):2150-2160.DOI10.19595/j.cnki.1000-6753.tces.211512.
[20] 贾骏,陶风波,杨强,付慧,杨景刚,陆云才,赵恒阳.复杂多径传播条件下变压器局部放电定位方法研究[J].中国电机工程学报,2022,42(14):5338-5348.DOI:10.13334/j.0258-8013.pcsee.210283. JIA Jun, TAO Fengbo, YANG Qiang, et al. Research on Partial Discharge Location Method of Transformer under Complex Multipath Propagation [J]. Proceedings of the CSEE, 2022,42(14):5338-5348.DOI10.13334/j.0258-8013.pcsee.210283.
[21] 刘青,常丁戈,邓军波.用于变电站站域局部放电特高频测向的空间谱估计算法优化选择[J].电工技术学报,2020,35(16):3551-3560.DOI:10.19595/j.cnki.1000-6753.tces.190821.
Liu Qing, Chang Dingge, Deng Junbo, et al.Optimal Selection on Spatial Spectrum Estimation Algorithms for UHF Direction Finding of Partial Discharge in Substation[J]. Proceedings of the CSEE, 2020,35(16):3551-3560.DOI:10.19595/j.cnki.1000-6753.tces.190821.
[22] A. Rumi, L. Righetti, A. Cavallini and P. Seri, "Electromagnetic UHF Emission of Motor Turn-Turn Insulation Samples fed by SiC Converter," 2022 IEEE Conference on Electrical Insulation and Dielectric Phenomena (CEIDP), Denver, CO, USA, 2022, pp. 1-4, doi: 10.1109/CEIDP55452.2022.9985312.